Design, Supply, Erection, Testing & Commissioning of 25 KV, 50 Hz Single Phase AC OHE in connection with the following works over Lucknow Division of Northern Railway: (i) Conversion of Barsethi Halt into Crossing station. (ii) Conversion of Salkhapur halt into Crossing station. (iii) Provision of New 1x25 KV SSP at Varanasi Station one at Kashi End and One at Lohta End along with associated Modification works in OHE

4-OHE SOR SECTION-IV (NON-FERROUS) 8397351.74 Below/Pa

Item Breakup - 1-OHE SOR SECTION-I (GENERAL)

Each Supply without insulator and erection of material for termination of Single conductor of Over head equipment or terminating wire.

Each Supply without Insulator and erection of material for termination of all aluminium 25KV Feeder / return conductor (Single SPIDER)

Each Supply without insulator and erection of materials for termination of copper cross feeder with gantries.

Set Supply without Insulator and erection of cut-in(9Tonne) Insulator

Each Supply without Insulator and erection of a suspension (9Tonne) Insulator

Each Supply without Insulator and erection of 25 KV Post Insulator

Each Suuply & Erection of 25kV Vacuum type Interrupter

Each DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY Supply and Erection of 25kV Potential Transformers Type-I

Each Supply and Erection of 42KV Lightning Arrestors (station class)

Each Supply and Erection of Terminal Boards in control cubicles.

Each Supply and Erection of an Iron clad 110 V.D.C Fuse Box.

Each Supply and erection of an Iron clad 230 V.A.C Fuse Box.

Each Supply and Erection of Lead Acid Batteries including wooden stand, electrolyte & tool board.

Set Supply and Erection of Battery chargers.

Each Supply & Installation of cables for Control and indication circuit

Metre Supply & Installation of cables for Heater supply

Metre Supply & Installation of cables for Catenary indication

Metre Supply & Installation of cables for L.T. Power supply

Metre Supply & Installation of cables for 110V D.C. supply

Metre Supply, Erection, oil- filtration, testing and commissioning of L.T. supply transformers (10 kVA).

Each Supply without Insulator & erection of 25 kV D.O. fuse switch.

Each Modification to erected equipments :Transfer of equipment from one mast or support to another.

Each Modification to erected equipments :Dismantling of a Section Insulator Assembly

Each Total 4776242.00 Item- 2 Erection S No. Item No Description of Item Unit Qty Rate Amount Preparation of designs and drawings for overhead equipment and verification of purchaser's pegging plan.

Per Track Erection KM Preparation of designs and drawings for switching stations (FP/SP/SSP)

Each DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY Supply without insulator and erection of mounting arrangements for span wire.

Each Marking/painting of temperature & 'Y'- Measurement of OHE mast at BWA locations

Each Supply without insulator and erection of material for termination of Single conductor of Over head equipment or terminating wire.

Each Supply without Insulator and erection of material for termination of all aluminium 25KV Feeder / return conductor (Single SPIDER)

Each Supply without insulator and erection of materials for termination of copper cross feeder with gantries.

Set Supply without Insulator and erection of cut-in(9Tonne) Insulator

Each Supply without Insulator and erection of a suspension (9Tonne) Insulator

Each Supply without Insulator and erection of 25 KV Post Insulator

Each Extra for special embedment of earth electrode.

Each Suuply & Erection of 25kV Vacuum type Interrupter

Each Supply and Erection of 25kV Potential Transformers Type-I

Each Supply and Erection of 42KV Lightning Arrestors (station class)

Each Supply and Erection of Terminal Boards in control cubicles.

Each Supply and Erection of an Iron clad 110 V.D.C Fuse Box.

Each Supply and erection of an Iron clad 230 V.A.C Fuse Box.

Each Supply and Erection of Lead Acid Batteries including wooden stand, electrolyte & tool board.

Set Supply and Erection of Battery chargers.

Each Supply & Installation of cables for Control and indication circuit

Metre Supply & Installation of cables for Heater supply

Metre DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY Supply & Installation of cables for Catenary indication

Metre Supply & Installation of cables for L.T. Power supply

Metre Supply & Installation of cables for 110V D.C. supply

Metre Supply, Erection, oil- filtration, testing and commissioning of L.T. supply transformers (10 kVA).

Each Supply and Erection, oil- filtration, testing and commissioning of L.T. supply transformers (25 kVA).

Each Supply without Insulator & erection of 25 kV D.O. fuse switch.

Each Modification to erected equipments :Transfer of equipment from one mast or support to another.

Each Modification to erected equipments :Dismantling of overhead equipment.

Kilometre Modification to erected equipments :Splicing & extension of an anchored overhead equipment.

Each Modification to erected equipments :Dismantling of a Section Insulator Assembly

Each Modification to erected equipments :Slewing and putting back of OHE in original shape

Each Span Modification to erected equipments :Dismantling of an Isolator

Each Modification to erected equipments :Dismantling of a Post/ Pedestal Insulator.

Each Modification to erected equipments :Manning of Switching stations (SP/SSP)

Each/month Supply and erection of materials for internal wiring and external lighting of Switching Station building(SP/SSP)

Each Extra on erection rates (Items of sub- section - I) for work under a power block @ 100%

8.00 mounting arrangement of span wire

4.00 material for termination of Single conductor of Over head equipment or terminating wire. DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY

10.00 material for termination of all aluminium 25KV Feeder / return conductor (Single SPIDER)

20.00 materials for termination of copper cross feeder with gantries.

90.00 cut-in(9Tonne) Insulator

24.00 suspension (9Tonne) Insulator

30.00 KV Post Insulator

2.00 commissioning of L.T. supply transformers (10 kVA).

2.00 kV D.O. fuse switch.

120.00 support to another.

& extension overhead equipment.

Each Total 1106664.40

Item Breakup - 2-OHE SOR SECTION-II (CONCRETE)

cum Total 2140000.00 Item- 2 Erection S No. Item No Description of Item Unit Qty Rate Amount Concrete for foundation and plinth In other than hard soil and rock

cum "Earth work, excavation for foundation In normal soil

cum Total 566250.00

Item Breakup - 3-OHE SOR SECTION-III (FERROUS)

MT S u p p l y and erection of fabricated and galvanised structures (O,N & R type portals) with necessary components other than masts.

MT DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY Supply and erection of Structure steel(traction masts) fabricated and galvanised Type : B-Series Mast

MT Supply & Erection of special fabricated and galvanised steel structures other than Portals & traction- Masts not covered under items 3(b)(i) &3(b)(ii)

MT Supply only of fabricated steel other than masts

MT Supply and erection of a Guy Rod Assembly

Each Supply and erection of 25KV Caution Boards including staff caution Board

Each Supply without insulator and erection of Single bracket assembly.

Each Supply without Insulator and erection of a pull off arrangement for one OHE.

Each Supply and erection of Regulating Equipment (3-Pulley type) with counter weight assembly for conventional/ composite OHE.

Each Supply without Insulator and erection of materials for termination of Double overhead equipment conductor.

Each Supply without Insulator and erection of anticreep with galvanized steel wire.

Each Supply and erection of a structure bond.

Each Supply and erection of a longitudinal bond

Each Supply & erection of a transverse and special bond.

Each Supply & erection of a single earth electrode.

Each Supply and erection of earth bus

Metre Supply and erection of fencing panels at switching stations.

Metre Supply and erection of fencing uprights

MT Supply and erection of anticlimbing device for Switching stations

Metre Supply and erection of anticlimbing device for L.T. Supply Transformer Stations.

Each Total 19640195.00 Item- 2 Erection S No. Item No Description of Item Unit Qty Rate Amount DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY Supply & Erection of traction masts, main masts of switching stations, Booster transformer station, fabricated from Rolled mild steel joist (RSJ) of size 203mm x 152 mm x 52.0 Kg/m and galvanised in various lengths .

MT S u p p l y and erection of fabricated and galvanised structures (O,N & R type portals) with necessary components other than masts.

MT Supply and erection of Structure steel(traction masts) fabricated and galvanised Type : B-Series Mast

MT Supply & Erection of special fabricated and galvanised steel structures other than Portals & traction- Masts not covered under items 3(b)(i) &3(b)(ii)

MT Supply and erection of a Guy Rod Assembly

Each Supply and erection of 25KV Caution Boards including staff caution Board

Each Supply without insulator and erection of Single bracket assembly.

Each Supply without Insulator and erection of a pull off arrangement for one OHE.

Each Supply and erection of Regulating Equipment (3-Pulley type) with counter weight assembly for conventional/ composite OHE.

Each Supply without Insulator and erection of materials for termination of Double overhead equipment conductor.

Each Supply without Insulator and erection of anticreep with galvanized steel wire.

Each Supply and erection of a structure bond.

Each Supply and erection of a longitudinal bond

Each Supply & erection of a transverse and special bond.

Each Supply & erection of a single earth electrode.

Each Supply and erection of earth bus

Metre Supply and erection of fencing panels at switching stations.

Metre Supply and erection of fencing uprights

MT Supply and erection of anticlimbing device for Switching stations DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY

Metre Supply and erection of anticlimbing device for L.T. Supply Transformer Stations.

Each Extra on erection rates(Items of sub- section - III) for work under a power block @ 100%

8.00 masts of switching stations, Booster transformer station, fabricated from Rolled mild steel joist (RSJ) of size 203mm x 152 mm x 52.0 Kg/m and galvanised in various lengths .

65.00 galvanised structures (O,N & R type portals & Special Portals ) with necessary components other than masts.

and steel(traction masts) fabricated and galvanised Type : B-Series Mast

55.00 galvanised steel structures other than Portals & traction- Masts not covered under items 3(b)(i) &3(b)(ii)

120.00 Single bracket assembly.

8.00 pull off arrangement for one OHE.

and Equipment (3-Pulley type) with counter weight assembly for conventional / composite OHE.

20.00 materials for termination of Double overhead equipment conductor.

3.00 anticreep with galvanized steel wire. Extra on erection rates for steel work manually under item 3(a)(i), 3(a)(ii), 3(b) (i),3(b)(ii) &3(b)(iii) @ 50%.

14.00 masts of switching stations, Booster transformer station, fabricated from Rolled mild steel joist (RSJ) of size 203mm x 152 mm x 52.0 Kg/m and galvanised in various lengths .

140.00 galvanised structures (O,N & R type portals & Special Portals ) with necessary components other than masts.

and steel(traction masts) fabricated and galvanised Type : B-Series Mast

85.00 galvanised steel structures other than Portals & traction- Masts not covered under items 3(b)(i) &3(b)(ii) Total 2386807.00

Item Breakup - 4-OHE SOR SECTION-IV (NON-FERROUS)

Each DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY Supply & Erection of contact wire only

Kilometre Supply and Erection of copper cross feeder wires (37/2.25 mm HDBC) across the track at SP/SSP/FP/BT locations

Kilometre Extra on item 6(az) for supply and erection of additional fittings at a turn-out, diamond crossing or overlap

Each Extra on item 6(bz) for supply and erection of additional fittings required at a turnout, diamond crossing or overlap.

Each Supply & erection of a double wire section insulator assembly without insulators.

Each Supply without Insulators & erection of two 25 kV Single Pole Isolator gang operated without earth contact assembly.

Each Extra for supply & erection of an earth contact assembly in an Isolator.

Each Supply & erection of large copper jumpers

Each Supply & erection of small copper jumpers

Each Supply & erection of copper jumpers

Each Supply & erection of a copper jumper for drop out fuse switch

Each Supply and erection of an aluminum jumper.

Each Supply of materials and erection of Large copper jumper 160 Sq. mm between cross feeder and OHE

Each Supply and erection of copper strips for equipment earthing.

Metre Supply & erection of : Aluminum bus-bars 36mm x 28mm.

Metre Supply & erection of Solid copper bus-bars 18mm.:

Metre Supply and erection of Aluminum bus-bar connectors:- Bus terminal (6480)

Each Supply and erection of Aluminum bus-bar connectors:- Bus splice (6490)

Each Supply and erection of Aluminum bus-bar connectors:- Bus tee connector (6500)

Each Supply and erection of Aluminum bus-bar connectors:- Terminal connector 36/20 (6530)

Each DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY Supply & erection of solid copper bus-bar connectors: Bus splice (6320)

Each Supply & erection of solid copper bus-bar connectors: Bus tee joint (6330)

Each Supply & erection of solid copper bus-bar connectors: Bus terminating tee (6351)

Each Total 2846967.00 Item- 2 Erection S No. Item No Description of Item Unit Qty Rate Amount Supply without insulator and erection of Suspension/ registration of contact wire only.

Each Supply & Erection of contact wire only

Kilometre Supply and Erection of copper cross feeder wires (37/2.25 mm HDBC) across the track at SP/SSP/FP/BT locations

Kilometre Extra on item 6(az) for supply and erection of additional fittings at a turn-out, diamond crossing or overlap

Each Extra on item 6(bz) for supply and erection of additional fittings required at a turnout, diamond crossing or overlap.

Each Supply & erection of a double wire section insulator assembly without insulators.

Each Supply without Insulators & erection of two 25 kV Single Pole Isolator gang operated without earth contact assembly.

Each Extra for supply & erection of an earth contact assembly in an Isolator.

Each Supply & erection of large copper jumpers

Each Supply & erection of small copper jumpers

Each Supply & erection of copper jumpers

Each Supply & erection of a copper jumper for drop out fuse switch

Each Supply and erection of an aluminum jumper.

Each Supply of materials and erection of Large copper jumper 160 Sq. mm between cross feeder and OHE

Each Supply and erection of copper strips for equipment earthing.

Metre Supply & erection of : Aluminum bus-bars 36mm x 28mm.

Metre DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY Supply & erection of Solid copper bus-bars 18mm.:

Metre Supply and erection of Aluminum bus-bar connectors:- Bus terminal (6480)

Each Supply and erection of Aluminum bus-bar connectors:- Bus splice (6490)

Each Supply and erection of Aluminum bus-bar connectors:- Bus tee connector (6500)

Each Supply and erection of Aluminum bus-bar connectors:- Terminal connector 36/20 (6530)

Each Supply & erection of solid copper bus-bar connectors: Bus splice (6320)

Each Supply & erection of solid copper bus-bar connectors: Bus tee joint (6330)

Each Supply & erection of solid copper bus-bar connectors: Bus terminating tee (6351)

Each Extra on erection rates (Items of sub- section - IV) for work under a power block @ 100%

of equipment only

1.50 aluminium 25KV Feeder/ Return conductor (Single Spider)

0.25 wires (37/2.25 mm HDBC) across the track at SP/SSP/FP/BT locations

40.00 of additional fittings at a turn-out, diamond crossing or overlap

12.00 section insulator assembly

4.00 25 KV single pole isolator without earth contact assembly.

16.00 25kV Double Pole Isolator.

4.00 contact assembly in an Isolator.

4.00 drop out fuse switch

10.00 copper jumper 160 Sq. mm between Aluminium bus and cross feeders

16.00 copper jumper 160 Sq. mm between cross feeder and OHE

60.00 connectors:- Bus terminal (6480)

3.00 connectors:- Bus splice (6490) DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY

1.00 connectors:- Bus tee connector (6500)

18.00 connectors: Bus terminal (6310)

6.00 connectors: Bus splice (6320)

4.00 connectors: Bus tee joint (6330) Extra on erection rates for stinging work manually under item 6(a),(b),(c)&(d) @ 50%.

of equipment only Total 371007.25

Item Breakup - 5-OHE SOR SECTION-V (INSULATOR)

Each Supply of 9- Tonne insulators for item 5(a) (i), 5(b) & 5(c)

Set Supply of 9- Tonne insulators for item 8(b) (i),(ii),(iii), (iv),(vi),(vii), (viii)&(ix)

Each Supply of 9- Tonne insulators for item 9(a), (b), (c), (d) & (e)

Each Supply of 9- Tonne insulator for item 11(a) (i) &11(a)(ii)

80.00 11(b) Supply of 9 - Tonne and Sectioning Insulators for item No.12(a)

mm) Sectioning Insulator Supply of 9 - Tonne and Sectioning Insulators for item No.12(b)

18.00 item 13(a)

16.00 item 13(c)

Set Total 2331625.68

Item Breakup - 6-OHE NS ITEMS

Numbers DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY NS-1 (D): Supply and erection of OHE caution board with supply of fixing material (Clamp, back flat strip & fasteners) for- E l e c t r i c Engine stop board size 900x600x2mm as per RDSO specification no ETI/OHE/33 (8/85) or latest as per RDSO Drawing no ETI/OHE/P/7572 Rev-B or latest as per Scope of work and explanatory note

Numbers NS-1 (E)Supply and erection of "caution clearance to OHE nearby restricted board" size 400 x 270 x 2 mm as per RDSO specification no ETI/OHE/33 (8/85) or latest as per RDSO Drawing no RE/33/436, Rev-C or latest as per scope of work and explanatory note

Numbers NS-1 (F)Supply and erection of "Dead section caution board" (Power block working limit board) Size 400 x 400 x 2 mm as per RDSO specifiaction no ETI/OHE/33 (8/85) or latest as per RDSO drawing no ETI/OHE/P/7574 or latest as per scope of work and explanatory note

Numbers NS-1 (G):-Supply and erection of enamled type caution live wire board size 450 X 225 x 2 mm as per RDSO specification no ETI/OHE/33 (8/85) or latest as per RDSO drawing no ETI/OHE/T/7574 Rev-A or latest as per scope of work and explanatory note

Numbers NS-1 (I):-Supply and erection of Shock treatment chart (glass framed) size 22x 18 " complete with aluminium angle beading 1/4" x 3/4 "all around

Numbers NS-1 (J):-Supply and erection of Gate man/station master instruction board (glass framed) size 11.6" x 8.2 " complete with aluminium angle beading all around

Numbers NS-1 (K):-Fabrication and supply of pre compressed particle laminated borads white in colour with aluminium beading 1/2" x 1/2" all around and an arrangement of fixing /hanging on wall of adequate strengh on top of boards required in size

Square Material + Erection Foot NS-1 (L) Development the sectioning diagram schematic diagram and TSWR diagram with computerised digital printing on adhesive vinyl of adequate size as per annexure -A and colour of as per provided in drawing

Square Material + Erection Foot NS-1 (M):-Modificaiton in already developed diagram in different size with computerised digital printing on adhesive vinyl of adequate size and color as provided in Drawing

Square Material + Erection Foot NS-1 (O)Supply and erection of telephone box wooden size 18" x 12 " x 8 "

Numbers DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY NS-1 (P):-Supply and erection of OHE wooden key box size 15"x10"x4.5"

Numbers NS-1 (Q)Replacement of enamaled type number plate and supply & erection of retro reflective number plate in place of replaced enameled number plate as per RDSO Drg no ETI/OHE/P/7053 or latest along with fixing arrangement and stenciling on mast.

Numbers NS-1 (R):-Supply and erection of fire bucket stand as per drg no RE/UMB/FB/SK/07 mod A (Approx wt 51 kg) legs will be grouted with cement concrete (1:3:6 mix) size 12"x12"x18" along with four no fire bucket 09 ltr capacity (approx weight 1.4 kg) per stand filled with dry flowing stand

Numbers NS-1 (S)Supply and erection of fire extinguisher 6 kg capacity suitable for ABC class of fire dry chemical powder ISI make stored pressure type initially charged with discharge hose & nozzle including fixing clamp.

Numbers NS-1 (T)Providing and fixing 10 mm thick heavy duty acid and alkali restant factory made tiles confirming to V-RD series of approved make and color using acid or alkali resistant mortar beining and joint filled with acid and for alkali resisting cement as per IS 4457 including cost of acid/alkali resistant cement. In dado /skirting on 12 mm thick mortar 1:4 (1 appropriate cement :4 course sand)

Square Material + Erection Foot NS-2 |(A):-Design Manufacturing supply of retro reflective type sigma board as per RDSO drawing no TI/DRG/OHE/PLTBRD/RDSO/00036/12/0(Size 450mmx60mm) and RDSO specification no ETI/OHE/33A(12/97) Rev.8

Numbers NS-2 (B) Cost of GI clamp for mounting arrangement suitable for sigma board (4 nos ) including transportation.

Each NS-2 (C) Erection of GI clamps (4 nos ) including 4 nos 12 mm dia GI nuts & bolts 300 mm long (fully threaded) with necesssary washer spring wahser including retro reflective type sigma board on non reflective back gound at different OHE mast and portals including transportation

Each Total 506515.00 Item- 2 SECTION-6B S No. Item No Description of Item Unit Qty Rate Amount NS-11:Dismantling of Mast

MT NS-11 (A):-Extra on erection rates (for work under power block) for item no NS-11 @ 100% of erection rate

MT DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY NS-12:Dismantling of Portal

MT NS-12(A):-Extra on erection rates (for work under power block) for item no NS-12 @ 100% of erection rate

MT NS-13:Dismantling of a Copper/ Aluminium jumper.

Each NS-13 (A):-Extra on erection rates (for work under power block) for item no NS-13 @ 100% of Erection rate

Each NS-14:Shifting of OHE termination (Regulated) from one mast or support to another

Each NS-14(A):-Extra on erection rates (for work under power block) for item no NS-14 @ 100% of erection rate

Each NS-15:Adjustment on bracket assemblies for lowering/raising the height of contact and catenary wires where Encumbrance is changed.

Each NS-15 (A):-Extra on erection rates (for work under power block) for item no NS-15 @ 100% of erection rate

Each NS-16:Adjustment on bracket assemblies for lowering/raising the height of contact and catenary wires where Encumbrance is not changed.

Each NS-16(A):-Extra on erection rates (for work under power block) for item no NS- 16 @ 100% of erection rate

Each NS-17:Shifting of OHE termination (Fixed ) from one mast or support to another

Each NS-17 (A)Extra on erection rates (for work under power block) for item no NS-17 @ 100% of erection rate

Each NS-19:Loading, leading, transportation, unloading and stacking of steel structures & Conductors etc. from TRD stores to site and released material from site to the store

MT NS-22 Supply and erection of earthing station as per special maintenance instruction no TI/SMI/0032 rev 2

Each NS-28:Dismantling of Foundation of RCC/MCC cement concrete anywhere in Yard/Block section upto required level for all heights

cum DYCEE-C-LKO-ELECTRICAL/NORTHERN RLY NS-29:Hiring and operating multi utility vehicle (maximum 03 vehicle in a month) of loading capacity one MT with sitting capacity of 4-6 persons, 4 strokes, 4 cylinder engine, facorty built metal body, cargo box type passenger cabin type or bith (with 24 hours availability) including cost of fuel lubricants operating and maintenance including on pucca kucha road along the track the contractor shall arrange road permit for vehicle for all the states of opeation as per instruction of engineer in charge and vehicle shall not be more than three years old

Each/month NS-30: Extra on NS 29 for every additional Km or part thereof over 1200 Km

Vehicle Km 18000.00 NS-31: Route Mapping of OHE mast by OLIVER-G Kit with use of GPS system in 25 KV AC OHE System between section of Lucknow Division

Kilometre NS@45"58@Provision of double contact wire under ROB/FOB complete with supply of cactenary wire & contact wire excluding supply of contact wire

Each NS-35:-Extra on erection rates (for work under power block) for item no NS- 34 @ 100% of erection rate

Each NS 36:- Supply and erection of large copper jumper of 160 sqmm size

Each NS-37:- Extra On erection Rates (for work under power block) for item no NS 36@ 100% of the erection Rates

Each NS 38:-- Provision of light weight section insulators assebmbly as per RDSO specification no TI/SPC/OHE/LWTSI/0060 Rev-1 with A&C slip no , STR: TI STR 024 rev 3 (Accepted make Arthur Flurry)

Each NS 39 :-Supply of battery Charger for 110 V 150 AH low maintenance lead acid batteries as per RDSO specification no TI/SPC/PSI/40-150/CHGR/1210 or latest.

Each NS-40:-Supply of LOW maintenance lead acid battery 110 V, 150 AH as per RDSO specification no RDSO/PE/SPEC/TL/0040 rev

Each Total 4962335.50