REPAIR AND MAINT OF DG SETS, STREET LIGHTS AT AREA UNDER AGE(I) POKARANREPAIR AND MAINT OF DG SETS, STREET LIGHTS AT AREA UNDER AGE(I) POKARAN

Amount

M&L maintenance of DG Sets and carrying out 'B' check after 250 hours run or 3 months period which ever is earlier including cost of replacement of new 'B' check kit such as oil filter, bypass filter, airfilter, CR element and CR plates complete with 'O' rings and draining of engine oil and filling up new engine oil, spares as required and calibration of ijectors and pumps including testing complete all as specified and directed for the DG sets of the following capacities of any make/type at Zone II A, B & C and various areas under AOR of AGE (I) Pokaran. Notes :- (i) Engine oil will be measured and paid seperately (ii) Labour &Transportation shall deemed to be included in the unit rate quoted. (iii) Location, Make of DG Sets, SM No, Engine Serial No shall be mentioned in MB while entering the measurements. (iv) Repairs to DG Sets shall be carried out through authorised representative of OEM Make of DG Sets to be Repaired:- Kirloskar/Cummin/Cater Pillar/Greaves Cotton

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

M & L for dismantling the cylinder heads from diesel engine and sent to foundry work(work shop) for calibration and repairs by replacing the spares such as Valves, Valve Guides, Valves seats and repairs kit and re-assembling to its original position with necessary Engine cylinder head gasket and O rings for the following capacities including testing complete all as specified and directed:-

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

M&L for disconnecting all electrical connections from the unserviceable self starter of any type /make /model, opening and dismantling of self starter suitable for the following capacities of DG set for carrying out repair, complete overhauling of the system including replacing the unserviceable parts such as bearing, carbon brushes, clutch plates etc assembling and refixing the self starter in its original position and connecting all connections and testing complete all as specified and directed. Note:- Armature coil and D coil field shall be measured seperatly under relevent items of schedule 'A'.

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

S&F armature coil suitable for any make/type of DG set of 12 volts including testing and taking down old unserviceable armature coil from self starter for the DG sets of the following capacities complete all as specified and directed:-

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

M&L rewinding of field coil for self starter of 12 volts with fine enamelled copper conductor of same gauge with 'F' class insullation, size twins and weight with necessary insulating materials, guage of conductor suitable for any make or type of DG set as required for the DG sets of the following capacities and testing complete all as specified and directed:-

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

M&L for removing the defective charging dynamo of capacity 24 V DC of any type / model / make of any capacity and opening it by removing all nuts and bolts, cleaning with necessary cleaning agent and overhauling and lubricating of the same replacing the armature and field coils reconnecting the same and refixing all items in original position testing and commissioning complete all as specified and directed.

M&L for removing the defective charging dynamo of capacity 12 V DC of any type / model / make of any capacity and opening it by removing all nuts and bolts, cleaning with necessary cleaning agent and overhauling and lubricating of the same replacing the armature and field coils reconnecting the same and refixing all items in original position testing and commissioning complete all as specified and directed.

M&L for disconnecting and dismantling of fuel pump assembly from its original position by opening of nuts and bolts, renewing of pump repair kit and fuel pipe refixing the same after overhauling including calibration and testing complete for the DG sets of the following capacities all as specified and directed:-

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

M&L for calibration of water pump complete, overhauling, replacing of gaskets, nuts, washers etc and reassembling the same and refixing the pump to the engine and testing including taking down the old unservicable water pump of any capacity of DG set from the engine and taking it to out side workshop, for the DG sets of the following capacities complete all as specified and directed:-

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

M&L disconnecting the cooler from any capacity and any type of DG set/make/size from the existing location duly removing of all mechanical and electrical connections and taking down the same for servicing, opening the parts and cleaning thoroughly by using suitable material and acid complete all as specified and directed.

M&L disconnecting the unservicable DC wiring from DG set of any type and rewiring the same with suitable new wire of existing guage by providing flexible pipe and testing complete for any type of DG set/make/size etc complete all as specified and directed.

M&L disconnecting the oil cooler of any DG set of any make and model from the existing location duly removing of all the mechanical and electrical connections and taking down the same for complete servicing, opening the connected parts and cleaning thoroughly by using with suitable material and acid complete all as specified and directed for the following capacities of DG sets:-

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

M&L taking down defective Turbo Charger Assembly duly disconnecting the mechanical and electrical connections from DG Set, opening and thoroughly checking to carry out repairs complete to the Turbo Charger Kit and spares as required at site including any mechanical and reassembling and refixing the turbo charger assembly to its original position and reconnecting the same for the following capacities of DG sets including testing complete all as specified and directed.

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

Draining out fuel from fuel tank of DG set of any type and keeping it in separate container safely, disconnecting all the fuel lines and other electrical and mechanical connections and taking out the fuel tank for cleaning of tank both internally and externally for removing all the accumulated dusts or sediments, leak testing the tank, welding and brazing including one coat of synthetic enamel paint and refixing the tank to its original position, replacing the drain plug and PVC pipe protecting with flexible pipe, calibrating the fuel tank, refilling the drained out fuel back in to the tank and marking of litres in guage and provision of locking arrangement complete all as specified and directed for the following capacities of DG sets :-

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

Supply only engine oil of grade 20W/40 for DG sets complete all as specified and directed. Make: Castrol/Volvoline/SAE

Supply only engine oil of grade15W/40 (Multi grade) for DG sets complete all as specified and directed. Make: Castrol/Volvoline/SAE

Supply and topping up of Acid Mixture suitable for Lead Acid Batteries of capacity 12V / 24V Complete all as specified and as directed.

Supply and topping up of distilled water suitable for Lead Acid Batteries of capacity 12V / 24V Complete all as specified and as directed.

S&F Automatic Voltage Regulator (AVR) suitable to DG set of following capacities including disconnecting of all electrical connections of existing unserviceable automatic voltage regugator of any size/make complete all as specified and directed.

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

M&L attending complaints for any type of DG set of emergency basis to clear/rectify both electrical and mechanical faults of DG set installed at various locations under AGE(I) Pokaran Complete all as specified and directed.

M&L repairs to AMF Panel of the following capacity of DG Set including checking of wiring / circuits and locating or rectfying faults including replacement of Relays, Timer set and other required items if any for its function as per OEM of manufacture firm complete all as specified and as directed.

DG Set of capacity 100 KVA To 160 KVA

S&F in replacement of Line Voltage Monitors (LVMS) of existing make to DG set of 100 KVA to 160 KVA capacity with all listed parameters including testing complete all as specified and as directed.

S&F in replacement of Rectifiers of existing Make to DG Set of 100 KVA to 160 KVA capacity with all listed parameters including testing complete all as specified and directed.

S&F 12V, 180 AH maintenance free battery suitable for DG set complete all as specified and directed. Make:- AMARON/EXIDE/EXPRESS/CANON

S&F heavy duty battery cable lead of copper conductor with copper lugs terminal for the 12V 180 AH maintenance free battery suitable for DG set complete all as specified and directed.

S&F battery brass terminal and jelly complete all as specified and directed.

M&L taking down the old unservicable Radiator assembly by unscrewing all mechanical and electrical connections from the existing mounting and disconnecting all the incoming and outgoing rubber hoses and draining out the water from the choked radiator assembly, transporting the same to civil workshop for carrying out servicing, opening the top and bottom covers of the radiator and cleaning throughly the chocked pipes of the radiator by using detergent like castic soda, cotton watse etc. cleaning of the all deposited sediments/rust in the pipe, including arresting of leakage by means of soldering/brazing and transporting back to site after completion of the above works including replacement of the new clamps, rubber hoses and Anti Vibrating Mounting (AVM) pads as required and refixing the same to its original position with suitable size of nuts and bolts, washers etc complete all as specified and directed for the following capacities of DG sets:-

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

S&F in repairs the following spare parts for any type/make of DG sets, as and when required by the department complete all as specified and directed.

Water temparature gauge-500108 Q

Starting key

Volt Meter 0-500V

Amps Meter

Frequency Meter

S.D Valve assembly

Oil safety control

Water separator bowl 3247715

Hour Meter

Oil pressure gauge

Water safety control

Flexible Hose from Pump to Engine

Diesel Pipe Metal (circulation) (5 mtr length)

Diesel Filter bracket

Hose-AK5028-SS

Hose-4030-MS

Hose-AK-5016-SS

Hose-AK-4103-SS

Hose-AK-4060-SS

Hose-AK-1608-06MO

Hose-AK-16015-06MS

Hose-AK-6054-ST

Hose-AK-4014-SS

Hose-AK-5030-SS

Radiator Metal Pipes

Hose Flexible AK4019SS Diesel Tank to Engine

Termostat-135675

Auxiliary Contactor 240V-2Nos (+2 NC) Make: L&T or equivalent as approved.

ON and OFF delay timer 240V AC & 240V DC Make: L&T or equivalent

Earth fault relay Make: L&T or equivalent

Over load relay Make: L&T or equivalent

Under voltage relay Make: L&T or equivalent

Power contactor 3 pole type MNX AC3 rating 12 Amps. Make : L&T Cat Part No CS 94108

Power contactor 3 pole type MNX AC3 rating 22 Amps. Make : L&T Cat Part No CS 94980

Power contactor 3 pole type MNX AC3 rating 25 Amps. Make : L&T Cat Part No CS 94110

Power contactor 3 pole type MNX AC3 rating 40 Amps. Make : L&T Cat Part No CS 94190

Self Starter solenoid switch 12V DC

Self Starter solenoid switch 24V DC

S&F in replacement of Timers

S&F in replacement of microprocessor based control unit suitable to DG set of 100 KVA to 160 KVA capacity with all listed parameters including testing complete all as specified and directed.

S&F in replacement of 'V' Belts for any capacity/make of DG Set complete all as specified and directed.

S&F in replacement of Fan Belts for any capacity/make of DG Set complete all as specified and directed.

S&F in replacement of Dinamo Belts for any capacity/make of DG Set complete all as specified and directed.

S&F in replacement of Water Belts for any capacity/make of DG Set complete all as specified and directed.

M&L preparation of old painted surfaces of the DG Sets of the 20 KVA to 30 KVA capacity including degreasing and spray painting the DG sets with one coat of synthetic enamel paint of approved colour and writing SM/MES No including painting on concrete surfaces of foundations with black paint complete all as specified and directed.

All as per Item No. 34 above but for DG Set of capacity of 45 to 63 KVA

All as per Item No. 34 above but for DG Set of capacity of 100 to 160 KVA

S&F MCCB 3 pole of the following capacities for fixing in distribution board/panel board/sheet metal enclosures with cable connections, aluminum lugs, glands and testing including taking down old unserviceable one complete all as specified and directed. Make:- Havells/L&T/Legrand/Indo Asian.

MCCB 63 Amps, 415Volts 16 KA breaking capacity

MCCB 100 Amps, 415Volts 25 KA breaking capacity

S&F MCCB 4 pole of the following capacities for fixing in distribution board/panel board/sheet metal enclosures with cable connections, aluminum lugs, glands and testing including taking down old unserviceable one complete all as specified and directed. Make:- Havells/L&T/Legrand/Indo Asian.

MCCB 63 Amps, 415Volts 16 KA breaking capacity

MCCB 100 Amps, 415Volts 16 KA breaking capacity

MCCB 125 Amps, 415Volts 16 KA breaking capacity

MCCB 200 Amps, 415Volts 35 /36 KA breaking capacity

MCCB 250 Amps, 415Volts 35/36 KA breaking capacity

M&L on load change over switch 200 Amps capacity suitable for 3 phase, 4 pole, 415 Volts with sheet steel enclosure in repairs complete all as specified and directed Make:- INDOASIAN Cat No: ICAS0200 or equivalent make in Havels or C & S.

Supply only coolent (DFC 50%) for DG sets complete all as specified and directed. Make: Castrol/Volvoline/SAE

S & F in repairs air cleaning element inner and outer with necessary 'O' ring for the DG sets of following capacities as that of existing make and model complete all as directed.

DG Set of capacity 20 KVA to 30 KVA

DG Set of capacity 45 KVA To 63 KVA

DG Set of capacity 100 KVA To 160 KVA

S&F in repairs automatic cut off Battery charger suitable for 12V, up to 10 Amp Battery complete all as directed. Make: SMPS/Phonix

S&F in repairs automatic cut off Battery charger suitable for 24V, up to 10 Amp Battery complete all as directed. Make: SMPS/Phonix

S&F in replacement of single phase preventor as directed.

Supply only the Battery charger 24V/10A panel mounting type as directed.

Calibration of PT Pump and replacement of PT Pump kit, gasket, etc whichever is required for smooth functioning of DG set complete all as directed.

Calibration of injectors by replacing injector cup, barrel plunger for smooth fuctioning of engine, testing complete all as directed.

S&F Flexible Bellow suitable upto 100 KVA to 160 KVA Gen set. Make as per OEM

M&L for lifting the Gen Set of 20 KVA to 160 KVA after disconnecting complete from cables, shifting to other place within 50 KM surrounding area mentioned by Engr-in-Charge, provision of PCC 1:2:4 type B1 (Using 20mm graded stone aggregate) as in foundation of size suitable to existing DG set (Approx size 3.5 mtr x2.5 Mtr x 0.3 mtr) including smooth finishing and necessary excavation and fixing the DG set on new foundation with all necessary arrangement of cable connections, Testing and commissioning complete all as directed Notes :- Cost of all items & Manpower including Crane for lifting up of DG set and placing again on new foundation shall be included in quoted rate

Supply & fix and test run the Fly wheel Ring of existing model size suitable for DG set of any capacity including taking down old unserviceable fly wheel ring complete all as directed.

S&F 12V, 150 AH maintenance free battery suitable for DG set complete all as specified and directed. Make:- AMARON / EXIDE / EXPRESS / CANON

S & F in repairs to Voltage stabilizer of capacity from 50 to 100 KVA by servicing of spares like dimmer (Variable Transformer), Carbon brush, servo motor (Synchronizing motors, Buck boost transformer (Series Transformer), Contactor or relay, MCB, MCCB, Electronic circuit etc complete all as specified and directed by Engineer-in-Charge.

S&F PCB kit control card suitable for 50/75/100 KVA voltage stabilizer incl removing old unsv PCB kit all as specified and directed by Engr In Charge

Repair to single phase voltage stabilizer of following capacity rewinding of transformer, replacement of new wiring with relays, switches & suitable voltmeter including testing and commissioning all as per direction of Engr in Charge

a) 5.0 KVA capacity

b) 3.0 / 2.0 / 1.0 KVA capacity

Supply and fix 4 Sqmm 2 core, 240 volts Al conductor cable heavy duty PVC insulated ISI marked all as specified and directed by Engr In charge.

S & F LED street light fitting 35 Watt 230 V AC outdoor type with high pressure die cast aluminum hosing and heat resistant complete with driver, lamp bracket with impact and corrosion resistant including thermal management in multiple optics complete with IP 65/66 protection complete.

Taking down old unserviceable LT cable, supply and Laying in trenches/through pipes/ducts or on poles/walls jointing to O/H conductor, LT panels, main switch with cable size aluminum lugs and testing. XLPE insulated, armoured heavy duty electric cables with aluminum conductor, 1100 volt grade, all as specified directed by Engineer In charge of cross sectional area and core of following sizes:-

(a) Size of cable 10 Sq.mm 2 Core Note : Excavation and earth work , sand, will be measured and paid separately

Excavation in trenches not exc 1.5m wide and n. exc 1.5M deep for fdn / trenches and getting out for soft / loose soil.

Removing excavated material any type n exc 50m and depositing at a level n.exc 1.5M above ground.

Returning/filling in layers, spreading leveling, watering and well ramming in layers n.exc 25m in sof/loose soil.

M&L for sand cushioning to PVC cable with tibba sand and punning to provide required cover all as directed.

M&L for cleaning down complete body including fitting and fixture of desert cooler of air flowing capacity 4000/5000 Cum/per hour of any make with wire including removal of all sludges, loose paints, dust, dirt etc and prepared the surface clean for painting and applying two coats of rubber based paint inside the water tank complete, including rewriting of MES No. complete all as specified & directed by Engr-in -charge.

S&F fan motor of single phase 230 Volt, 1400 RPM 3 speed 1/8 HP for desert cooler incl cast iron rings for motor with clamps nuts & bolts complete all as specified & directed by Engr-in -charge. MAKE : COOL HOME/ KHAITAN/ POLAR/CG

"-do- all as item No 68 above but fan motor 24" sweep 900RPM

S&F PVC flexible pipe of 16 mm outer dia complete with PVC elbow, tee as required complete all as specified & directed by Engr-in -charge.

S&F repair, wood wool pad (set of three) minimum weight 0.8 Kg, proper fixed in 3 side of panels of desert cooler complete all as specified & directed by Engr-in -charge.

S&F in repair, plug top 3 pin 5 Amp with cable upto 2mtr, 230 Volt (ISI marked) complete all as specifide & directed by Engr-in -charge.

S&F in repair, PVC insulated and PVC sheathed round flexible three core copper conductor cable of size 40/0.0076 Sqmm including making necessary connections for desert coolers complete all as specifide & directed by Engr-in -charge.

S&F capacitor 4 Mfd for fan motor of desert cooler complete all as specifide & directed by Engr-in -charge.

Supply and replace water spray pump 1/30 HP for desert cooler . MAKE : COOL HOME/ KHAITAN/ POLAR/CG

S&F iron fan blade aluminium coated for fan motor of desert cooler of 20 inch sweep complete all as specifide & directed by Engr-in -charge.

star electricals

Manisha Enterprises