Urgent Track Maintenance for TOK-PNMB Bye-pass line under SSE/UD section on Konkan Railway in Karnataka state (e file : 57465)

SWR USSOR 2022 ITEM NO 063050 Lubrication of fish plated rail joints under traffic, 10 by using Grease Graphite Grade 'O' (IS:408) and Black oil supplied by contractor, for all types of rail sections as per procedure laid down in latest version of IRPWM and as directed by Engineer In charge. Note: Release U/S bolt & nuts is to be deposited back. If any fish bolts is jammed it should be cut with chisel and hammer and replaced with fresh fish bolt supplied.

SWR USSOR 2022 ITEM NO 063090 Lubrication of ERCs and its liner contact area by removal of ERCs and Metal / GFN liners in rail panel, cleaning of rust / scale of ERC, Metal / GFN 11 liners & SGCI insert by using wire brush, scrapper / sand emery paper etc supply and application of graphite grease, as prescribed by Railway for under side of liners & corresponding area of rail foot & SGCI insert with ERCs and re-fixing the same as per procedure prescribed in latest edition of IRPWM with contractors grease and all other tools & plants complete and as directed. Note: Each ERC in this item shall constitute 1 ERC and its Liner Contact area

SWR USSOR 2022 ITEM NO 063100 Removing seized ERC from SGCI inserts of existing track by using suitable approved chemicals and re-fixing after greasing of insert eye and 12 ERC with Contractor's grease of specified quality as per provisions of IRPWM, as directed by Engineer in charge. Note: 1 List of Seized ERC along with location shall be prepared after inspection of SSE/P.Way and marked prior to execution of this item. 2 Due care shall b e taken to avoid any damage to the sleeper 3.A penalty of 50% of the basic cost of new sleeper in nearest sleeper factory shall be levied on each, if SGCI insert is broken or sleeper gets cracked in the process.

SWR USSOR 2022 ITEM NO Manual deep screening of Plain track/ turnouts as per procedure prescribed in IRPWM, June 2020 or latest, on PSC sleepers of any density and throwing away screened muck arising out of screening on toe of bank or on cess, if low or on spoil banks 18 above top of cutting (including throwing and leveling, if required beyond minimum 5m from the edge of cutting which are up to 3m deep or alternatively carting it up to 50m for disposing it off beyond cutting or platforms) as per direction o f Engineer in-charge, including cutting c e s s for effective drainage on both sides, one round of kutcha packing with screened ballast and further attending to track parameter to make track fit for 20 kmph speed complete in all respect.

SWR USSOR 2022 ITEM NO 211040 Dismantling Check Rail on curves on track of all rail sections, duly removing fish plates and bolts including removing chairs from sleepers, leading and stacking released materials away from track clear of infringements, complete and as directed.

Fixing of check rails o n curves o n track o f a l l rail sections a s per drawing and to 20 correct alignment and level with Railways fastenings including leading of rails and fittings, crossing o f tracks, greasing of plate screws with approved grease etc., as per drawing and directions of Engineer in charge with all contractors labour, tools, plants, machinery, consumables etc. complete. Note:Required P.Way fittings will be supplied at SSE/P.Way stores. Above/

Supply of unskilled labour for USFD and other works. (Man day is 8 hrs shift per day). Note : The basic rate includes EPF-12%, ESI-3.25% and and administrative charges-1% Above/

Removal of corroded/seized bolts and nuts of points and xings/guard rails joints/ check rails and fish plate bolt and nuts etc. In yard/mid section.

Item Breakup - 1-SCHEDULE-A

RM Total 1416.00 SWR USSOR 2022 ITEM NO 062030 :Replacement of any type of sleepers in track with PSC sleepers lying on cess or at Bridge Approaches for casual renewal at isolated locations with all fittings complete to specified gauge & cross level with contractor's tools including packing and dressing of Item- 2 ballast, as directed by Engineer in-charge. Released materials shall be neatly stacked and handed over at specified location within an average lead of 250 m or near either side of Bridge approaches as directed. S No. Item Description of Item Unit Qty Rate Amount No

Each Total 23242.80 SWR USSOR 2022 ITEM NO : nsertion of rails of all types & length in track, laid on any type & density of sleeper to the specified gauge under traffic block. Rates include fastening of rail with Item- 3 sleepers with standard set of fastenings and fixing of fish plates and bolts or, if required, providing gap for welding and stacking of released material without infringement within 250m as directed by Engineer-in- Charge. Note: Rail drilling and cutting to be paid separately. S No. Item Description of Item Unit Qty Rate Amount No

RM Total 1498.50 SWR USSOR 2022 ITEM NO 073010 Lifting for increase in ballast cushion of existing points & crossing layouts up to 75mm or part thereof including approach and exit sleepers including one Item- 5 round of through packing, correcting the disturbed sleeper spacing, tightening of fittings, boxing of ballast and ramping out on either side at slope not steeper than 1 in 1000 or as directed. Note: Item will be paid only when lifting is 50mm or more. S No. Item Description of Item Unit Qty Rate Amount No

Set Total 50314.42 SWR USSOR 2022 ITEM NO 063120 : Lubrication of Plate/Rail screws of Points and crossings, SEJs, Bridges, Curves etc., with greases graphite, including removal of screws carefully without damaging sleepers, cleaning with wire brush etc., both screws and dowel hole, applying grease graphite, Item- 6 refixing the screw and sealing the top and sides of screw with grease graphite to prevent ingress of moisture and corrosion with contractors labour, tools, consumables under traffic condition all lead and lift S No. Item Description of Item Unit Qty Rate Amount No

Each Total 140888.00 SWR USSOR 2022 ITEM NO 131010 Through packing of track, as per procedure prescribed in latest Item- 7 edition of Indian Railways Permanent Way Manual S No. Item Description of Item Unit Qty Rate Amount No

1400.00 Sleepers/Km or more Total 116088.00 SWR USSOR 2022 ITEM NO 131020 Picking up of slacks in track of all sleeper density, duly opening up ballast, gauging, alignment, correcting longitudinal & cross levels, packing, boxing of ballast and dressing the same under traffic conditions as per procedure prescribed in latest edition of IRPWM Item- 8 andasdirected by Engineer in- charge. Note: In-charge section Engineer should identify locations requiring packing and obtain prior approval of DEN/XEN before execution of the work when there is no Zonal Track Maintenance agency deployed in the section. S No. Item Description of Item Unit Qty Rate Amount No KARWAR-DIVISION-ENGINEERING/KRCL

TRM Total 71080.00 SWR USSOR 2022 ITEM NO 131030 First or Second Through Packing of track of all sleeper density including giving a general lift, as desired to eliminate sag after Deep Screening work, lifting of track, Item- 9 lowering of track and major realignment of curves and formation rehabilitation as per procedure prescribed in latest edition of IRPWM. Note: General lift is normally 25 mm and isolated lift may be S No. Item Description of Item Unit Qty Rate Amount No

2800.00 Total 306488.00 SWR USSOR 2022 ITEM NO 063050 Lubrication of fish plated rail joints under traffic, by using Grease Graphite Grade 'O' (IS:408) and Black oil supplied by contractor, for all types of rail sections Item- 10 as per procedure laid down in latest version of IRPWM and as directed by Engineer In charge. Note: Release U/S bolt & nuts is to be deposited back. If any fish bolts is jammed it should be cut with chisel and hammer and replaced with fresh fish bolt supplied. S No. Item Description of Item Unit Qty Rate Amount No

200.00 plates. Joint Total 14384.00 SWR USSOR 2022 ITEM NO 161010 Quick cutting with abrasive rail cutter of all types of rail sections including wear resistant, head hardened rails up to 110 UTS, with contractors tools & plants, equipment, consumable with all lead & lift etc. complete as directed by Engineer in-charge. Item- 14 Abrasive Rail Cutter will be as per RDSO Specification No. TM/SM/1 (Rev. 01 of 2012) with latest status of RDSO; Rail Cutting Wheel Abrasive Disc will be as per RDSO Specification No.TM/SM/2 (Rev. 01 of 2020) S No. Item Description of Item Unit Qty Rate Amount No

Each Total 1297.00 SWR USSOR 2022 ITEM NO 171030 Loading, leading and unloading of 52Kg / 60Kg rail up to 13 metre length by Railway's Rail Dolly / Dip Lorry to the nominated location under traffic with line Item- 15 protection in case road carriage is not possible with different lead with a lift up to 5 metre during block period. S No. Item Description of Item Unit Qty Rate Amount No

5.00 contractor's Rail Dolly / Dip Lorry Total 3549.40 SWR USSOR 2022 ITEM NO 172030 Loading, leading and unloading of PSC Sleepers of 52Kg / 60Kg Item- 16 by Railway's Rail Dolly/ Dip Lorry to the nominated location under traffic in case road carriage is not possible for different leads and lift up to 5 metres. S No. Item Description of Item Unit Qty Rate Amount No

20.00 contractor's Rail Dolly/Dip Lorry. Total 12037.20 SWR USSOR 2022 ITEM NO Loading, leading and unloading of all types of P.Way fittings and all other miscellaneous material except Rails, sleepers, switches, crossings, SEJs and Glued Joints by Item- 17 road vehicles for different leads. Note: Lead shall be the shortest motorable road length between the points of loading and unloading. S No. Item Description of Item Unit Qty Rate Amount No

MT Total 7083.60 KARWAR-DIVISION-ENGINEERING/KRCL SWR USSOR 2022 ITEM NO Manual deep screening of Plain track/ turnouts as per procedure prescribed in IRPWM, June 2020 or latest, on PSC sleepers of any density and throwing away screened muck arising out of screening on toe of bank or on cess, if low or on spoil banks above top of cutting (including throwing and leveling, if required beyond minimum 5m from the edge of Item- 18 cutting which are up to 3m deep or alternatively carting it up to 50m for disposing it off beyond cutting or platforms) as per direction of Engineer in-charge, including cutting cess for effective drainage on both sides, one round of kutcha packing with screened ballast and further attending to track parameter to make track fit for 20 kmph speed complete in all respect. S No. Item Description of Item Unit Qty Rate Amount No

1400.00 Plain Track :

1000.00 081021 to 081028 for disposal of muck at a distance beyond 50m for every additional lead of 50 metres or part thereof up to 500 metres for 1 TRM in station yard / cutting. Total 578250.00