Contract for periodic preventive maintenance of Motor Control Centre, blower motors of AC Ventilation systems, power distribution systems and other electrical maintenance works in general areas and radiation areas at MCMFCG, IGCAR, Kalpakkam

Amount

Preventive maintenance of 40 HP to 60 HP Motors & its associated control modules of AC Ventilation Systems.

Preventive maintenance of 15 HP to 30 HP Motors & its associated control modules of AC Ventilation Systems.

Preventive maintenance of 1 HP to 12.5 HP Motors & its associated control modules of laboratories and AC Ventilation Systems of RCL.

Preventive maintenance of Power distribution panel / Motor Control Centre

Overhauling of 40 HP to 60 HP motors in ACV plant

Overhauling of 15 HP to 30 HP motor in ACV plant

Overhauling of 1 HP to 12.5 HP motors in ACV plant

Calibration of Thermal Over load relay for various motors used in ACV plant & other systems.

Maintenance of Earth Pits including supply of Sodium Bentonite, and measurement of Earth Pit Resistance as per the specification. (Refer Sec VI (MNC), Clause No.2).

Supply and installation of Philips 2" X 2" LED Lights Model RC099V G2 LED36/840 PSU W60L60 OC.

Supply and installation of 2x 20 W 4' LED luminaire with suitable sheet steel box type batten with powder coated finish(IGP162LT8-16 Twin holder fixture with 2 Nos. of 4 FT. LED Lamp LT8-865-2) of crompton make or equivalent

Supply and installation of 16 pin FEEDTHROUGH Allied connector SET, Female connector MS 3106F 28L-61S & Male connector MS 3100E 28L-61P in 12 mm thick SS Flanges Glove Boxes.

Surveillance of Emergency lighting, blackout lighting system

Surveillance and performance check of UPS system up to 10 kVA

Identification & rectification of fault in 10W to 40W LED/FTL luminaries including replacement of Lamps/starters/holders (Refer Sec VI (MNC), Clause No.4).

Identification of fault and Replacement of 5A to 16A switches/sockets, telephone jacks, 20A Modular motor starters, Modular plates of different sizes in Flush/Concealed type MS switch boxes, 3/4pole MCBs up to 63 Amps in labs and low bay areas (Refer Sec VI (MNC), Clause No.4).

Identification and rectification of shunt or series fault in lighting or power circuit wiring in labs / building as per scope of work –minor fault

Identification and rectification of shunt or series fault in lighting or power circuit wiring in labs / building as per scope of work- major fault

Attending to Fuse off calls in lighting circuits/Power Points/ Power boards (Refer Sec VI (MNC), Clause No.22).

Overhauling and servicing of ceiling /pedestal/wall mounting / Exhaust/Air circulator fans (single phase) as per the Scope of work. (Refer Sec VI (MNC), Clause No.14).

power system