PROVN OF CONVERSION OF OVERHEAD ELECTRIC LINES WITH LT UG CABLE INSIDE PERIMETER AT AMN SUB DEPOT OF COD AND PROVN OF WATER SUPPLY SYSTEM AT BOFORS BAY COMPLEX OF 506 ABW JABALPUR UNDER GE (E) JABALPUR

Dismantling of ACSR/AAC conductor of any size from LT poles or distribution span, GI earthing wire etc complete all as specified and directed.

Dismantling of MS channel or angle sections, insulators any type and size, brackets, clamps, nut, bolts, washers, GI earthing wire of any size from LT poles or distribution span etc complete all as specified and directed.

M&L for excavation in trenches for laying of cable, poles and stay in any type of soil n.exc 1.5 mtr wide and n.exc 1.5 mtr deep and getting out in any type of soil complete all as specified ad dirtected.

M&L for returning & filling in including spreading and leveling, watering and well ramming in layers n.exc 25 cm complete all as specified and directed.

M&L for unwashed sand cushoining to under ground cable provided with a layer of 8 cm deep before laying and 15 cm covering above the top edge of cable after laying complete all as specified and directed. Note: Punned thickness shall be measured for payment.

M&L for removing excavated material n.exc 50 mtr and depositing were directed complete all as specified and directed.

M&L for fly Ash bricks sub class 'B' locally available laid flat in trenches over sand cushoining for cable protection complete all as specified and directed.

Demolition of cement concrete unreinforced in ground floor and pavings n.exc 15 cm thickness(below or above ground level) complete all as specified and directed.

M&L for PCC 1:2:4 type B-2 using 40 mm graded crushed stone aggregate as in filling in surface channels and drains etc complete all as specified and directed.

M&L for PCC 1:3:6 type C-1 using 20 mm graded crushed stone aggregate as in coping of pole etc including form work & finishing the surfaces even & smoothe without using extra cement complete all as specified and directed.

M&L for crossing hole under road/hard standing for passing cable through GI pipe including GI pipe light grade 32 mm with all fitting complete all as specified and directed.

M&L for crossing hole under road/hard standing for passing cable through GI pipe including GI pipe light grade 40 mm with all fitting complete all as specified and directed.

M&L for crossing hole under road/hard standing for passing cable through GI pipe including GI pipe light grade 50 mm with all fitting complete all as specified and directed.

M&L for crossing hole under road/hard standing for passing cable through GI pipe including GI pipe light grade 80 mm with all fitting complete all as specified and directed.

S&F XLPE insulated armoured and PVC sheated heavy duty electric cable with aluminium conductor 1100 Volt grade laid in tranches passing through pipes/ducts including tenstion complete of following cross sectional area and size complete all as specified and directed . Note - Rate is inclusive of cable gland & cable lugs.

4 Sqmm x 3 Core

10 Sqmm x 2 Core

16 Sqmm x 4 Core

25 Sqmm x 4 Core

35 Sqmm x 3.5 Core

50 Sqmm x 3.5 Core

70 Sqmm x 3.5 Core

95 Sqmm x 3.5 Core

Supply, install and testing Digital time switch (2 output 16 A - 250VA- 50/60Hz, 2x28 programmes 2 Channel) including 3 phase power contractor 40 Amps in existing LT panel boxes with wire connection with nut bolts, washers etc complete all as specified and directed.

M&L for sub main wiring alongwith earth wire and including with approved colour as per IS with two single core PVC insulated FRLS cable with stranded copper conductor of size 2.50 Sqmm nominal area and drawing into suitable size of PVC non metalic rigid heavy duty PVC conduit of white/ivory colour and its accessories ISI mark heavy duty of suitable size including one run of PVC insulated with 2.50 Sqmm (nominal area) stranded copper conductor FRLS cable as earth wire complete all as specified and directed. Note - Two runs (with Red/Yellow/Blue colour for Phase + Black colour for neutral) of 2.50 Sqmm cable, one run (with Green colour for Earth) of 2.50 Sqmm cable and one run of PVC conduit shall be measured as one unit.

S&F junction box CRCA sheet as required at site with necessry clamps nuts, bolts and washers with 200 Amps rated aluminium bus bar with MCB single pole 20 to 32 Amps complete with necessary fitting arrangements on steel tubular poles complete all as specified and directed.

S&F LED street/security light fitting 60 watt 230 volt, AC outdoor type with high pressure die cast aluminum housing and heat resistant complete with driver, lamp bracket with impact and corrosion resistant including thermal management in multiple optics complete with IP65/66 protection complete including taking down old unserviceable light fitting any type comlete all as specified and directed.

Supply laying jointing, threading 20 mm bore GI tubing medium grade laid in trenches with socket joint together with and including all fittings (such as bend, elbow, tees, short pices connector, caps, plug and union etc) by cutting welding etc complete all as specified and directed.

Supply laying jointing, threading 25 mm bore GI tubing medium grade laid in trenches with socket joint together with and including all fittings (such as bend, elbow, tees, short pices connector, caps, plug and union etc) by cutting welding etc complete all as specified and directed.

M&L for cutting existing steel tubing of 25/32 mm pipe for alterations or additions(each cut measured) complete all as specified ad dirtected.

M&L for cutting existing steel tubing of 40/50 mm pipe for alterations or additions(each cut measured) complete all as specified ad dirtected.

M&L for gun metal globe or gate valve 20 mm bore with iron wheel head screwed both ends for pipe line and fixing complete all as specified and directed.

M&L for gun metal globe or gate valve 25 mm bore with iron wheel head screwed both ends for pipe line and fixing complete all as specified all as specified and directed.

Supply, fabricating and elrecting/fixing/installation of outdoor LT panel with projeted globe roof for rain water protection (feeder pillar box), CPRI approved outdoor type (approximate size 900 x 1200 x 600 mm), weather and verming proof suitably ventilated for 440 Volts, 3 phase 4 wire system, AC supply, factory made fully compartmentalized made out of 3.15 mm thick CRCA steel sheet for load bearing and 2 mm thick CRCA steel sheet for non load bearing, degree of protection IP 54 as per IS-2147 of 1962 with pretreatment and powder coated of approved colour, double door with both side opening alongiwht locking arrangement, bus bar chamber to accommodate epoxy painted high conductivity aluminium bus bars of 400 Amps fixed with colour coated porcelain insulator (01 set) sleeves including phase indication neon lamps set, danger notice plate, necessary cable connections with suitable size of cable lugs and glands, internal wiring with suitbale size copper conductor cable, panel shall be fixed/mounted on approx 75 cm above ground level on and including suitable size base channel/angle iron or any other section (zinc metal coated) frame work/support as per site requirement but not less than of angle iron frame of section 50 x 50 x 6 mm including all necessary bolts, nuts and washers etc over and including PCC platform of size not less than 1.20 x 80 x 0.75M height (outer dimensions), 0.60M above ground level and 0.15M below ground level in PCC1:2:4 type B-2 using 40 mm graded crushed stone aggregate, foundation 150 mm thick and 150 mm extending on both sides of PCC platform in PCC 1:4:8 type D-2 using 40 mm graded crushed stone aggregate including necessary excavation and earth work and plaster/rendering 15 mm thick in CM 1:4 on all sides of PCC platform upto 15 cm below from ground level and two coats of white was on plastered surfaces including prepration of surfaces etc including testing and commissioning with and including following fixtures/fittings complete all as specified and directed :-

Supply, installation, commissioning and testing CPRI approved factory fabricated, floor mounted outdoor type LT feeder pillar box of suitable size fabricated out of 3.15 mm thick CRCA sheet and angle iron 50 x 50 x 6 mm frame and 750 mm above the normal ground level complete factory made totally enclosed dust and vermin proof double door both side hinge opening arrangement on front and back with locking arrangement cable entry and exist from botton with cable glands and gaskets, aluminium bus bar 250 Amps rating (01 Set) fixed on procelain insulator with internal wiring with suitable size of aluminium strips to be used for incoming and outgoing connection of all switches/MCCB's and Bus bar. Bus bar shall be insulated with colour code sleeves/tapes and to be connected with copper lugs, including two coats of synthetic enameled paint on the surface ecternally and internally over a coat of red oxide primer paint including necessary PCC 1:3:6 type C-2 as in foundation complete all as specified and directed comprising of the following :

S&F MCB Triple pole 415 Volts, 20 Amps 25 KA complete all as specified ad dirtected.

M&L for earthing complete with galvanized steel earth plate electrode 60cm x 60 cm x 6mm thick buried directly in ground vertically (earth pit not less than 2.25m deep below ground level) with top edge of the plate not less than 1.50 mtr deep below normal ground level connecting to and including GI steel strip 32 x 6 mm by means of bolts, nuts, check nuts, and washers of galvanized iron or steel including 40 mm dia medium grade pipe for protection of GI wire to the extent of 7.5 mtrs as earthing lead including charcoal dust and salt packed all around the earth plate in the earth pit all as per Electrical plate No 3 of SSR Part-I (2009) including PCC foundation/chamber in mix 1:2:4 type B-1 with angle iron frame CI frame, CI cover with provision of locking arrangement and 20 mm dia light grade GI pipe from top edge of the earth plate upto MS funnel with wire mesh provided inside the concrete earth pit for watering arrangement complete including excavation and earthwork in any type of strata and testing complete including fill up the earth pit with soil for best result and removal (for LT panels). Note - Earth protection pipe and earthing strip upto and including 7.5 m length is deemed included in unit rate quoted by the contractor.

M&L for earthing complete with galvanized steel earth plate electrode 60cm x 60 cm x 6mm thick buried directly in ground vertically (earth pit not less than 2.25m deep below ground level) with top edge of the plate not less than 1.50 mtr deep below normal ground level connecting to and including GI earth wire of size 4.0 mm by means of bolts, nuts, check nuts, and washers of galvanized iron or steel including 15 mm dia medium grade pipe for protection of GI wire to the extent of 7.5 mtrs as earthing lead including charcoal dust and salt packed all around the earth plate in the earth pit all as per Electrical plate No 3 of SSR Part-I (2009) including PCC foundation/chamber in mix 1:2:4 type B-1 with angle iron frame CI frame, CI cover with provision of locking arrangement and 20 mm dia light grade GI pipe from top edge of the earth plate upto MS funnel with wire mesh provided inside the concrete earth pit for watering arrangement complete including excavation and earthwork in any type of strata and testing complete including fill up the earth pit with soil for best result and removal. Note - Earth protection pipe & earthing strip upto and including 7.5 m length is deemed included in unit rate quoted by the contractor.

M&L for earth continuity conductor or main earthing lead fixed to wall on batten or recess or chases or burried in ground and laid down through 20 mm PVC medium grade conduit complete with fixed to poles or any other indicated situation for loop earthing etc as required 4 mm dia galvanised iron or steel wire etc complete all as specified and directed.

M&L fully Automatic Star Delta Motor starter 1 HP in sheet-steel enclosure type MK-1 feature (Motor Rating AC-3 Duty, 415V, 50Hz, three -Ph) and Relay Range 11-18 complete all as specified and directed.

M&L for brick masonry valve pit of size 60 x 60 x 60 cm (internal dimension) including all excavation PCC work, earth work and disposal of soil to a distance not exc 50 mtr and depositing where directed by Engr-in-Charge including plastering internally and pointing to wall externally as work proceeds including m.s sheet cover 3.15mm thick and angle iron frame suitable size handle locking arrangement and painting to steel surface complete all as specified and directed.

M&L for brick masonry valve pit of size 45 x 45 x 45 cm (internal dimension) including all excavation PCC work, earth work and disposal of soil to a distance not exc 50 mtr and depositing where directed by Engr-in-Charge including plastering internally and pointing to wall externally as work proceeds including m.s sheet cover 3.15 mm thick and angle iron frame suitable size handle locking arrangement and painting to steel surface complete all as specified and directed.

M&L Mono block Pump motor MB series MBK22 capacity of pump 1 HP, 5 KW, 415 Volts, 3 phase , pump size 50 x 40 mm with head range of 105 to 18 mtr height with discharge capacity of 350 to 200 LPM with provision of rain proof covering with locking arrangement and PCC foundation of appropriate size complete all as specified and directed.

Schedule of credit amount of Rs 43732.50 to be deducted during AOC.

Please Enable Macros to View BoQ information