COMPREHENSIVE MAINTENANCE FOR PASSENGER LIFT AT SAILORS MD ACCN AND EMERGENCY REPAIRS AND OVERHAULING SERVICING MAINTENENACE OF MES B VEHICLES UNDER GE M ARAKKONAM

Amount

Note: (i) The spares/electrical items as listed below as SUPPLY ONLY will be used whenever required only and it shall measured and paid separately under respective items. (ii) The rate is inclusive of all items as required at site except those items as SUPPLY ONLY below to keep the lift operational round the clock including cleaning and greasing all moving parts on monthly basis complete all as specified and as directed by Engr-in-Charge. (iii) If spare parts of original make is not available in market necessary suitable spare equivalent to existing lift part as approved by Engr-in-charge shall be used in the work so that to run the lift with smooth functioning. (iv) The contractor should attend any complaint / breakdown immidietly on call basis. (v) Contractor should submit the inspection / maintenance report of every visit inspite of no of visits during breakdown calls including mentioning the status of lift and spares any replaced. (vi) The old unserviceable spares replaced under comprehensive maintenace i.e in S.No 02 to 05 of this BOQ is the property of contractor for which credit shall be deducted under respective items in schedule of credit. (vii) Cost of renewal of lift license and lift insurance is deemed to be included in the quoted rate . (viii) Quoted rate incl the load testing of all the lifts by licensed Lift Inspector of tamil nadu once in contract period for saftey.Certificate issued by the licensed lift inspector shall be submitted to Eng-in-charge.

Note Continue: (ix) In case of lift is not working for more than 24 hours but less than 10 days, Recovery will be affected at the rate of Rs 2,000/- per lift per day and Rs 3,000/- per lift per day after 10 days. (x) The above lifts shall be repaired through OEM (Original manufacturer) or through their nearest authorised/accredited agency service personnel only.The lowest bidder shall submit MoU from the OEM of lift or their authorised/accredited agency. (xi) Fortnightly, monthly, quarterly maintanence registers shall be maintained and signed by site engineer and contractor.

Supply only Main Contactor 25A 230V AC

Supply only ARD Battery 12V 7AH

Supply only Full height Infrared door sensor

Supply only Door VVVF drive

M & L for oil service and general service by draining out the engine oil from the engine and refilling with new engine oil of specified grade as per manufacturer incl replacing engine oil filter,fuel filter, air filter elements and carry out complete checkup in lubricating system, cooling systems, air intake systems, fuel systems, exhaust systems, DC electrical systems, tightening bolts and nuts in engine and alternator related systems etc of following vehicles all as directed by Engineer-in-Charge.

(a) TATA Mobile (LCV)

(b) Eicher (LDV)

(c) Maruti Swift Dezire (LMV)

(d) Motor Cycle Hero Honda

(e) Motor Cycle Royal Enfield

M & L for repair and maintenance to radiator assembly of TATA mobile and Maruti Swift Dezire vehicle by dismantling, disconnecting inlet and outlet connections overhauling / servicing the radiator, clearing/removing blockages arresting leakages, assembling back including necessery welding/bracing as required, refixing, reconnecting and testing for proper functioning all as specified and directed.

All as per item No 08 above but for Eicher (LDV)

Repairs to 12 V Self starter motor assembly of TATA Mobile / Eicher / Maruti Swift Dezire by removing from engine, taking it to workshop, dismantling , opening up ,removing burnt out windings , insulation materials , bushes, bearings , rewinding with same guage and type of insulation winding wires and insulation materials , replacement of bushes, bearings including necessary machining works as required assembling, fixing back to engine , connecting and testing for statisfactory function all as specified and directed by Engr in charge..

Repairs to 12 V battery charging alternator assembly of TATA Mobile / Eicher / Maruti Swift Dezire by removing from engine, taking it to workshop, dismantling, openingup, removing and replacing the wornout/unserviceable slep rings carbon brushes, bearings, rectifier, diodes and carry out cleaning /serviceing to rotor starter, assembling & refixing to the engine and testing for satisfactory charging of battery all as directed. Note : Rewinding of stator will be measured and paid seperatly under relevant item.

Rewinding the stator of 12 V battery charging alternator of TATA Mobile / Eicher / Maruti Swift Dezire by taking down the old burnt copper wire and rewounding with new copper wire of same guage and type of insulations and insulation sheets , applying insulating varnish over the complete winding , drying up by heating complete all as specified and directed.

M & L for replacing diesel hose of size suitable for TATA Mobile complete all as specified and directed.

M & L for replacing diesel hose of size suitable for Eicher complete all as specified and directed.

M & L for Recharging of Battery 12 Volts , up to 120 AH any make / type by replacing electrolyte including replacement of unserviceable terminal posts , to the required standard complete all as specified and as directed

All as per item No 15 above but of 12 V upto 8 AH

M & L for changing old gear oil by draining out from gear box / transmission system as per manufacturer grade and specification for TATA Mobile / Eicher / Maruti Shift Dezire complete all as specified and as directed

M & L for topping up Engine oil suitable for TATA Mobile / Eicher / Maruti Shift Dezire of specified and grade as per manufacturer complete all as specified and as directed

Repairs to steering sysytem by removing the defective tie rod end (2 Nos) from front side wheel replacing with new suitable for TATA Mobile including all nuts and nolts complete all as per manufacturers specification complete all as specified and as directed

Repairs to brake system of TATA mobile by dismantling the wheel, drum from the TATA mobile vehicle, taking drum to workshop, remetteling, bracing, machining for smooth surface, bringing back, refixing to wheel including replacement of worn out brake shoe, wheel cyclinder kit, refilling / topping up brake fluid of suitable grade, testing for satisfactory operation complete all as specified and as directed

M & L for hub greasing to wheel of TATA Mobile vehicle by dismantling, cleaning the wheel bearing, applying new grease and replacing oil seal, refixing back the wheel complete all as specified and as directed

Repairs to clutch assy of TATA mobile be dismantling the clutch from vehicle, removing and replaceing the defective / worn out clutch plate, clutch pressure plate assy, pressure release bearing etc. reassembling and refixing to the vehicle and checking for smooth operation complete all as specified and as directed

Repairs to rear suspension LH or RH side of TATA Mobile vehicle, by dismantling complete leaf spring plates, taking to machine shop, bending the leaf plate or replacing the damaged leaf plate, assembling, replacing center in, brackets bushes / sleeve and refing back to vehicle , checking for propoer functioning complete all as specified and as directed

Repair / serviceing fuel injection pump and injectors by removing, taking to workshop, dismantling completely, carring out servicing, replacing defective parts such plunger washers, shafts, sleeves, injector nozzel, assembling, bringing back and refixing back to vehicle, checking for satisfactory function complete all as specified and as directed

Repair to hand brake system of TATA mobile by checking, replacing defective GI wire, brackets, lever or other spares required and making effective functioning complete all as specified and as directed

Repair to water pump of TATA mobile vehicle after removing the radiator assy with all assessories, replacing with new water pump, refing the radiator and connected accessories complete all as specified and as directed

M & L for removing and replacing of following defective / worn out parts of TATA mobile all as specified and directed:-

Brake master cylinder kit

Side mirror

Middile mirror inside cabin

Wiper blade

Head ligh bulb

Indicator assy

Indicator bulb

Brake light assy with bulb

Brake light bulb

Belt suitable for water pump / alternator

Radiator hose supply / return with clip

Air cleaner hose set with clip

Battery terminal suitable for positive and negative post

All as per item No 19 but steering of Eicher Vehicle

All as per tiem No 20 but brake system of Eicher Vehicle

All as per tiem No 21 but wheel hub greasing of Eicher Vehicle

All as per tiem No 22 but Clutch assy of Eicher Vehicle

All as per tiem No 23 but rear leaf sping suspension assy of Eicher Vehicle

All as per item No 24 above but for fuel injection pump of Eicher vehicle.

All as per item No 26 but water pump assy of Eicher Vehicle

M & L for removing and replacing of following defective / worn out parts of Eicher all as specified and directed:-

Brake master cylinder kit

Side mirror

Battery terminal suitable for positive and negative post

Wiper blade

Head ligh bulb

Indicator assy

Indicator bulb

Brake light assy with bulb

Brake light bulb

Beit suitable for water pump / alternator

Radiator hose supply / return with clip

Air cleaner hose set with clip

M & L for removing and replacing of following defective / worn out parts of Maruti Shift Dezire all as specified and directed:-

Engine mounting RHS

Engine mounting LHS

Engine mounting centre

Rear Shock absorber

V Belt

Pulley Belt tension

Wiper blade

Head light bulb

Indicator bulb / brake light bulb

Radiator hose supply / return with clip

Spark plug

Battery charging rectifier

All as per item No 19 but steering of Maruti shift Dezire Vehicle

All as per tiem No 20 but brake system of Maruti shift Dezire Vehicle

All as per tiem No 22 but Clutch assy of Maruti shift Dezire Vehicle

Wheel balancing of Maruti shift Dezire vehicle in computarised machine, correction of toe in and toe out, adding counter wheight to whell for balacing complete all as specified and directed

Carry out tyre rotation incl stepney of any LCV / LDC veh complete all as specified and directed

Repair to tyre by removing taking to valcunizing shop, removing tube, making tyre puncture in vulcanising machine and refixing back to vehcile complete all as specified and directed

Repair to clutch assy of motor cycle Hero Honda / Royal Enfield by draining out oil, dismantling and replacing worn out clutch plate release bearing, 'O' ring etc assembling and refixing, refilling engine oil complete all as specified and directed

M & L for serviceing carburator assy of motor cycle Hero Honda / Royal Enfield by removing, dismantling, cleaning with petrol, replacing defective jet, spring etc assembling, refixing, checking for satisfactory and smooth functioning complete all as specified and directed

Repairs to brake assembly front / rear of motor cycle Hero Honda / Royal Enfield by removing wheel, removing and replacing the worn out brake shoe with spring, assembling and refixing to motor cycle complete all as specified and directed

M & L for removing and replacing of following defective / worn out parts of of motor cycle Hero Honda / Royal Enfield all as specified and directed:-

Head light bulb

Brake light bulb

Side Indicator assy with bulb

Clutch cable

Clutch lever / Brake lever

Accelarator cable

Coil set

Chain sprocket

Timing chain

Side mirror

Speedometer cable

Repairs, Maintenance and Serviceing to grass cutting machine by checking serviceabiility of spark plug, clutch assembly, accelerator lever set and other spares including, serviceing of carburator by removing and refixing complete all as specified and directed by Engr in Charge. Make Honda/Zenovo Note: Each machine shall be inspected and serviced in every three months and replacing the spares as required. The spares shall be measured and paid seperatly under relevenat item.

Supply only spares for incorporated in item No 47 above:-

(a) GX-35 Carburator

(b) Clucth

(c) Accelerator lever Set

(d) Aluminium Tap N Go assembly

(e) Bevel Key

(f) Tap N rope 3/3.2 mm dia plastic

(g) Inner shaft with pipe from Engine to Bevel Key

M & L for Overhauling engine assembly of grass cutting machine by dismantling completley inspecting and replcaing the unserviceable bore assembly, piston, shaft, bush kit, bearings, packing kit etc reassembling, testing for statisfactory function all as psecified and directed by Engr in Charge

Repairs, Maintenance and Serviceing to car wash machine held at MT Section of AGE E/M by checking its servceability and replacing the unserviceable spares as required complete all as specified and directed by Engr in Charge. Car wash Make is ELGI model LL 03. Note: Car wash machine shall be inspected and serviced in every three months. The spares shall be measured paid seperatly under relevenat item.

Supply only spares for incorporated in item No 49 above:-

Plunger

Packing ring lipped

Spring Plate

Ring plate

Locking piece

Valve suction M/C

Spring valve suction M/C

Valve delivery M/C

Spring delivery valve

Belt V A58

Saftey valve assy

Man Elevators Company Pvt Ltd (BID ID -3257737)