SPECIAL REPAIR AND REPLACEMENT OF EXISTING LIGHTS IN 08 X SQUASH COURTS AT SPORTS COMPLEX AND GARDEN LIGHTS AT SALARIA SQUARE AND CERTAIN MINOR WORK AT NDA KHADAKWASLA

Amount

Dismantling and taking down unserviceable light fitting any type like HPSV/FTL complete with acessories and depositing to E/M store yard againist credit schedule as directed by Engineer-in-charge.

Supply and Fix of 200 watt integral SMD LED Highbay luminaire with aluminium reflector light fitting incl with inbuilt electronic drivers ,necessary hanging arrangements as per site requirement all as specified and directed by Engr-in - Charge Make Luker cat No LOHY200 or equivalent in Polycab/Jaquar/Havells. Note: 1. Ladders /Cranes shall be used and will be provided by contractor for dismantling /fixing of light fittings at roof of Squash court and cost for the same is deemed to be included.

Taking down carefully sub main wiring of any type and size and making good disturbed surfaces complete as specified.

M&L for sub main wiring with two single core PVC insulated FRLS cables with stranded copper conductors 2.5 Sqmm , 1100 Volts grade in and including concelaed PVC conduit medium grade not less than 19mm complete with accessories including GI clamps for fixing with angle iron and copper cable 2.5 sqmm continuous earth wire complete all as specified and directed (Two runs of 2.5 Sqmm cable with 01 run of 2.5 Sqmm earth wire along with PVC conduit shall be measured as one RM)

M&L point wiring with 1.5 sq mm copper conductor FRLS (multistrand) PVC insulated ISI marked unsheathed cable and including surface, Non metalic rigid PVC casing capping double lock type ISI marked not less than 19 mm with all fitting & other accessories and also including PVC insulated ISI marked unseathed FRLS cable size 1.5 sq mm copper conductor as earth wire to common earth dolly including modular PVC box with cover plate suitable for modular switches, sockets, fan regulator etc for following :- One light/Fan point controlled by one way switch 6 Amps 240 volts.

Ditto all as per item No. 5 above but One 3 pin socket outlet, 5 Amps, independent board

Ditto all as per item No. 5 above but One 3 pin socket outlet , 16 amps on independent board with cable 4 Sqmm and 4 sqmm as earth wire

S&F modular switch one way 6 Amp, 1 module

M&L modular Socket, 6A - 2/3 pin combined 2 module

M&L modular socket 16 A, 6 pin, 2 module

S&F ceiling rose surface shall comply with IS :371-1979 Bakelite 60x 25 mm two to three terminals plates and of outside diameter not less than 63.5mm

S&F 1x20W, 230V surface and wall mounted LED batten Extruded aluminum housing provided for heat dessipation with polycarbonate diffuser and integrated driver and including connecting up with twin core twisted flexible copper condctor cable from ceiling rose all as specified

M&L for sub main wiring with two single core PVC insulated FRLS cables with stranded copper conductors 6 Sqmm , 450/1100 Volts grade in and including PVC casing and caping ISI marked of size not less than 19 mm complete with conduit accessories and copper cable 6 sqmm continuous earth wire complete all as specified and directed (Two runs of 06 Sqmm cable with 01 run of 06 Sqmm earth wire along with PVC casing capping shall be measured as one

S & F MCB DB single phase 08 Way double door type,(IP:43 Protection) made out of high quality CRCA sheet.Fixing th DB on surface/concelaed.DB should be with insulated busbar and DB should comes alongwith wire sets,neutral bar,earth bar & wire ties

S&F MCB SP 6 to 32 Amps 240V,10 KA breaking capacity , C curve ISI marked as per IS/IEC 60898-1 2002 with IP 20 protected terminals all as specified includin complete connection with copper /aluminium cable lugs with suitable size for incoming and outgoing

S&F MCB DP 6-40 Amps 240V,10 KA breaking capacity , C curve as per IS/IEC 60898-1 2002 with IP 20 protected terminals all as specified including complete connection with copper /aluminium cable lugs with suitable size for incoming and outgoing

M&L for concealed point wiring with 2.5 sq mm copper conductor FRLS (multistrand) PVC insulated ISI marked unsheathed cable and including PVC conduit ISI marked not less than 19 mm with all fitting & other accessories and also including PVC insulated ISI marked unseathed FRLS cable size 2.5 sq mm copper conductor as earth wire to common earth dolly including following :- One 3 pin socket outlet 5 Amp on the same board

M&L for concealed point wiring with 2.5 sq mm copper conductor FRLS (multistrand) PVC insulated ISI marked unsheathed cable and including PVC conduit ISI marked not less than 19 mm with all fitting & other accessories and also including PVC insulated ISI marked unseathed FRLS cable size 2.5 sq mm copper conductor as earth wire to common earth dolly including PVC box suitable for Amps socket outlet power point insependent circuit.

M & L sub main wiring with PVC insulated FRLS grade cable LT 1100 volts grade PVC insulated unsheathed, multistranded with stranded copper conductor drawn through & including suitable type PVC casing & caping including drawn on wall/ceiling/through stair case/wooden surface with all accessories and including cutting of existing surfaces of any type and making good to match with the existing surfaces acrylic sheet work after completion alongwith one contineous earth wire and connected to common earth complete all as specified for following sizes of cable. ( 2x4 Sqmm with one continous earth wire of size 4.0 Sqmm. Note: 2 runs of 4 Sqmm cable and one run of 4.0 Sqm earth wire and PVC casing/capping will be measured as one meter.

M & L for modular switch piano type 16 Amps one way, 1 module

S & F 12 module PVC surface box suitable for modular switches, sockets, fan regulator etc

S & F modular white cover plate with support frame 12 module

S & F 6 module PVC surface box suitable for modular switches, sockets, fan regulator etc

S & F modular white cover plate with support frame 06 module

S & F in replacement modular step type fan regulator 120w, 2 module. Make: Vinay/Anchor/Roma.

S&F in replacement 1x20W, 230V surface and wall mounted batten suitable for installing LED tube including connecting up with twin connected fflexible copper conductor cable from ceiling rose all as specified . Make: Havellscat part Regal batten T8UPTO1x22WSSBSWH or equivalent in /Wipro/Luker

S & F LED tube light single side connected with diffused opact ultra bright LED tube light 20 watt with light efficiency, integrated aluminum heat sink T8 tube light complete all as specified and directed. Makke: Havells cat part TITANINEO1213T8SSTL20WLED865SPC or equivalent in Wipro/Luker

S & F in replacement sheet metal enclosure single pole MCB 20 Amps with a two pin and earth plug and socket complete with all accessaries etc all as directed by Engineer-in-charge. Make: Legrand cat part 5078 10 or equivalent in C&S/L&T

S & F in replacement of MCB single pole 6-40 Amps working on 240 volts 50 HZ AC 10 KA 'C' curve all as specified and directed. Make: Legrand/Indo Asian/L&T

S & F in replacement of MCB SPN 6-40 Amps working on 240 volts 50 HZ AC 10 KA 'C' curve all as specified and directed. Make: Legrand/Indo Asian/L&T

M & L for earthing complete with galvanised steel earth plate electrode 600 x 600 x 6.3 mm thick burried directly in ground (earth pit plate less than 2.25 mtrs deep below ground level) with top edge of the plate not less than 1.5 mtrs deep below normal ground level, connected to galvanised earth wire 4mm dia of aminimum 15m length by means of bolts, nuts check nuts and washers of galvanised iron or steel all as shown in electrical plate No 3 in SSR part-I connected to earthing lest point all as specified or indicated including provision of earthing lead protection pipe, PCC earth pit with cover excavation & earth work testing on completion etc all as specified and directed by Engineer-in-charge.

S&F ceiling fan of sweep 1200mm,240volts, 5 star BEE rating milk white coloured connecting up with three core 1.5 Sqmm cable from ceiling rose including required length of down rod and hook accessories all as specified.

Supply and fix MCB DB single phase 04 Way double door type,(IP:43 Protection) made out of high quality CRCA sheet.Fixing th DB on surface/concelaed.DB should be with insulated busbar and DB should comes alongwith wire sets,neutral bar,earth bar & wire ties.

M&L for laying XLPE underground cable 35 sqmm 3.5 core armoured sheathed with PVC cable stranded aluminium conductor 1100 volts grade

M&L for laying XLPE underground cable 16 sqmm 4 core armoured sheathed with PVC cable stranded aluminium conductor 1100 volts grade

M&L for laying XLPE underground cable 10 sqmm 4 core armoured sheathed with PVC cable stranded aluminium conductor 1100 volts grade

S & F PVC insulated copper conductor 3 core 2.5 sqmm for from busbar to fitting ,multistranded complete all as specified and directed. Make Polycab/Havells/Standard

M & L heavy grade PVC conduit of external dia 25 mm (junction/terminal) inclusive of all tees, bends, elbows and fixing accessories such as saddles, pipe hooks etc for drawing PVC cable from under the foot path and necessary excavation complete all as specified.

Excavation in trenches in soft/loose soil n exc 1.5m wide and n.exc 1.5m in depth and getting out complete all as specified and directed.

Returning filling in including spreading leveling watering and well ramming in layers n.exc 25 cm complete all as specified and directed.

Removing excavated surplus soil to a distance n exc 50 m and depositing where directed at a level n exc 1.5 mtr above starting point complete all as specified and directed.

M&L for laying of half round reinforced concrete pipe, of dia 100 mm, half round for bottom and half round for top. and before laying excaved area shall be leveled. complete all as specified and directed. Make : As per sample approved by the Engineer-In-Charge Note : 01 Half round top and 01 half round bottom together will be considered as one running meter.

S & F GI tubing medium grade 40 mm dia ISI marked with all fittings laid in trenches or fixed pole by flat iron clamps,ut,bolt,washers suitable size all as specified and directed at size.

S & F fix busbar panel factory made , made out of 3.15 mm thick CRCA sheet, powder coated with hinges and door with locking arrangements of size 40cm x 25 cm x 50 cm housing in and including 25 x 4 mm bus bar of 04 nos suitable length fixed on porcelain insulator with proper size of screw and one No of MCB TPN 32 Amps, 240 Volts , in/out cable gland of suitable size of cables. The panel shall be provided with 04 Nos 35mmx35mmx5mm thick angle iron supports of not less than each .9 mtr height duly painted with anti corrosive black paint incl suitable Excavation and PCC foundation complete all as specifed and directed. Note :- Quoted rate shall be deemed incl of Earth work and PCC

S & F busbar panel factory made , made out of 3.15 mm thick CRCA sheet, powder coated with hinges and door with locking arrangements of size 50cm x 30cm x65 cm housing in and including 25x 4 mm bus bar of 04 nos suitable length fixed on porcelain insulator with proper size of screw and one No of MCCB 50 Amps, 240 Volts , in/out cable gland of suitable size of cables. The panel shall be provided with 04 Nos 40mmx40mmx5mm thick angle iron supports of not less than each .9 mtr height duly painted with anti corrosive black paint incl suitable Excavation and PCC foundation complete all as specifed and directed. Note :- Quoted rate shall be deemed incl of Earth work and PCC

S & F in 3.5 mtr aesthetically designed decorative hot dipped galvanised mild steel step pole with grey powder finish incl suitable base plate and suitable nut, bolt and washers and PCC foundation as per OEM complete all as specified and directed by Engr-In - charge Make Havells Cat No 7308 or Bajaj Note :- Quoted rate shall be deemed incl of Earth work and PCC as per OEM specifications, base plate,nut bolt and washers.

S & F of 70 W WW LED Out door post top light ,Correlated colour temperature 3000 K, post top with diecast aluminium body confirm to IP-65 , complete directed by Engr-in-Charge Make - Havells Cat No TYCOONPT70WLED730PSYMTOPC /HPL/Luker

S & F of 60 W WW LED Out door post top light ,Correlated colour temperature 3000 K, post top with diecast aluminium body confirm to IP-65 , incl suitable arrangements for 3.5 mtr decorative pole complete directed by Engr-in-Charge Make - Havells/HPL/Luker

M&L for PCC (1:3:6) type C-1 (40 mm graded stone aggregate) Cement concrete in foundations, filling and mass concrete

M&L for PCC (1:4:8) (40 mm graded stone aggregate) Cement concrete in foundations, filling and mass concrete

Supply and Fixing 1x18 watt WW (3000K) LED outdoor garden light with polycarbonate diffuser and IP 65 protection incl demolition of existing PCC and make suitable PCC for garden light as per site requirement all as directed by Engineer- In - Charge Make Luker Cat No LOBRD60 or eqv in Philips/Havells

M&L for road /hardstanding /Foot path cutting of n.exc 20 cm wide and n.exc 45 cm depth surface wherever required and making good to match with existing surface as per site requirement.

S&F 200 watt warm white (3000K) LED flood light luminaire die cast housing and heat sink in aluminium extrusion and IP 65 , on existing pole using by suitable MS channel/mounting structure complete all as specified and directed by Engineer-in-Charge Make Luker cat No LFL200 or equivalent in Havells/HPL/Jaquar

S&F distribution box 4 Module 230V, 5 HZ, IP-65 & IK-09 Class-II, weatherproof cabinets, door and cabinet fully reversible, removable chassis and faceplates, including weatherproof glands, rails qty-1 Nos, coppper fork type 100 A busbars as short link including end caps, qty-1 nos, MCB SPN 16 Amp 230V, 50 HZ, C curve qty 01 No , MCB SP 6 AMP ,230V,50 HZ, C curve Qty -01 No and blanking plates complete all as specified and directed Make: Legrand/L&T/Schinder

SONU ENTERPRISES

Sneha Aircool

Sparkh Electricals & Works

Mechelecs Engineers

M/S BHAREKAR CONSTRUCTION