Construction of Under Ground Cabling at New VIP Road, Old VIP Road, Kotwali Road, Ghat Road and Vindyvashni Mandir Parisar Vindhychal Mirzapur under deposit Scheme EED-II Mirzapur

Amount

Supply of following materials as per Cost data Book/Market rate/ PuVVNL norms at the work site.

Transformer 400 kva (Copper Wound Transformers)

Transformer 250 kva (Copper Wound Transformers)

VCB PANNEL1600 A,11KV,3 P, 50 Hz ,1 MVA Copper Busbar and all Accessories

MAIN L.T PANNEL 1000Amp /415 Volt ACB -1 No., Busbar 1000 Amp /415 Volt AL -1 No and as per Estimate

FEEDER PILLAR -1 as per Estimate

11 KV 3X185 mm 2 XLPE CABLE

11 KV Cable jointing Kit Outdoor 3x185mm2 sq. mm XLPE Cable

11 KV Cable jointing Kit Indoor 3x185mm2 sq. mm XLPE Cable

LT Aluminium Conductor PVC insulated armoured served sheathed cable 1100 volts Cable size 4 sq mm x 4 core

LTAluminium Conductor PVC insulated armoured served sheathed cable 1100 volts Cable size 6 sq mm x 4 core

LTAluminium Conductor PVC insulated armoured served sheathed cable 1100 volts Cable size 10 sq mm x 4 core

LT Aluminium Conductor PVC insulated armoured served sheathed cable 1100 volts Cable size 16 sq mm x 4 core

LT Aluminium Conductor PVC insulated armoured served sheathed cable 1100 volts Cable size 120 sq mm x 3-1/2core

HDPE 200 mm dia (OD-200 mm & ID-175 mm nominal)

Danger Board

G.I. Barbed Wire

LED Street light

G.I. wire

TMT BARS OF MINIMUM GRADE FE500

Erection of 400 KVA/250 KVA 11/0.433 K.V. Copper Wound Transformers with O.L.T.C. & R.T.C.C. Panel at Site as per BEE Latest Specifications Star Rating (Star-1), effective from 1st July 2017, which is same as B.I.S.-1180 (Part-1)-2014, Level-2. and as per latest specification of UP Power Corporations, make prefered Crompton,Schneider or any Equivalent make Including construction of Plinth and earthing etc. with all material as per Technical Requirment with 05 years warranty

Erection and Installation, testing & commissioning of indoor type 11 kV VCB panel, totally enclosed fully interlocked, metal clad floor mounting, horizontal draw out type with metering arrangement, and 1 Incoming & 2 Outgoing HT Switchgear of Vacuum Circuit Breaker (VCB) including Surge Protection Device (SPD) on incomer & Earth Switch on outgoings, made out of 2 mm thick sheet steel for load bearing member and 1.6mm thick for non-load bearing member with all necessary protections, multi function meters & complete .

Erection of Chemical Earthing burring of Safe Earthing Electrode T-19, (Hot Dip Galvanized), Length up to 3000mm, outer Dia 50 mm inner Dia 25 mm, terminal Dia 12mm, outer GI pipe of 16 swg and inner GI pipe of 12 swg with Hot Dip Galvanization up to 100 micron filled with rystalline conductive mixture (CCM) having anti corrosive & onductive property with 50 kgs activated soil (BFC) capable of reducing the soil resistivity with good mixture of retaining capacity and one earthing lead of 25mm x 3mm G.I. strip, upto switch board (from apron to witch board, the cost of G.I. strip will be extra) along with 30 cm square C.I. frame with hinged cover & masonry housing. Make.

Erection and Laying of 25mmx3mm G.I. Strip from earth electrode in ground as required complete in all respects.

Erection and fixing of one number 8 SWG G.I. wire in 15mm dia G.I. pipe for earthing, laid in ground or in wall duly concealed including the cost of cement, sand, labour, T & P other material required for proper completion of the work as directed at site.

Erection of 11 KV 3X185 mm 2 XLPE CABLE layingof 3 core standered aluminium conductor XLPE (Cross linked polyethylene) insulated PVC bedded, Galvanised flat steel strip armoured cables confirming to I.S. 7098 (Part-II with latest amendments) II KV grade at a depth of 900 mm below ground level over a cushion of 100 mm thick fine river sand all around and protected with well burnt bricks on sides and on top put across. The armouring of cable shall be properly connected with earth conductor by clamps etc.

Erection and making indoor cable end termination with heat shrinkable jointing kit complete with all accessories including lugs suitable for following size of 3 core, XLPE aluminium conductor cable of 11 KV grade as required :

Erection and laying aluminium conductor PVC insulated armoured served sheathed cable 1100 volts grade at the depth of 750 mm bellow ground level over a cushion of 75 mm thick sand all around and protected with burnt bricks on side and on top .On surface the cable run shall be fixed on MS clamps etc.of suitable size or as directed by the Engineer-Incharge ,complete in all respect.The armouring of the cable shall be properly connected with the earth conductor by clamps etc.Following size

size 4 sq mm x 4 core

size 6 sq mm x 4 core

size 10 sq mm x 4 core

size 16 sq mm x 4 core

size 120 sq mm x 3-1/2core

Erection and fixing of brass nickle plated compression gland for pvc insulated & armoured served sheaththed ,underground cable including rubber ring etc. complete in all respect. Thearmouring of the cable shall be properly connected with the earth as per direction of engineer -incharge.for cable

size 4 sq mm x 4 core

size 6 sq mm x 4 core

size 10 sq mm x 4 core

size 16 sq mm x 4 core

size 120 sq mm x 3-1/2core

Erection and fixing of plain or pin type copper tin plated cable socket (lug) to cable leads for pvc insulated & armoured cable insulating with tape and making connection. Completed .

size 4 sq mm

size 6 sq mm

size 10 sq mm

size 16 sq mm

size 120 sq mm

Erection and Fixing of Danger Board fabricated from 10 gauge M.S. Sheet as per I.E. Rules

Erection and fixing of LED Street light Fitting having die cast aluminium body and diffuser with driver set suitable for 45 watt to 50 Watt. Confirming to IP 66 protection complete in all respect.

Erection , EXCAVATION in foundation in ordinary Soil ( Loam clay or sand ) including lift upto 1.5m lead upto 30.0 m & including filling watering and ramming of excavated earth into the space between the building & sides of foundation trenches or into the plinth and removal & disposal surplus earth as directed by the engineer I/C within a lead of 30 m.from foundation trenches.

Erection , Providing and laying Cement concrete 1:4:8 (1cement :4 coarse sand :8 graded stone ballast 20 mm. nominal size) including supply of all materials, labour and T&P etc. required for proper completion of the work and curing complete, also including cost of formwork in foundation.

Erection , Providing and laying in position machine batched and machine mixed design mix M-25 grade cement concrete for reinforced cement concrete work, using cement content as per approved design mix, including pumping of concrete to site of laying but excluding the cost of centering, shuttering, finishing and reinforcement, including admixtures in recommended proportions as per IS: 9103 to accelerate, retard setting of concrete, improve workability without impairing strength. (Note :- Cement content considered in this item is @ 330 kg/cum. Excess/less cement used as per design mix is payable/recoverable separately).

EAGLE CONSTRUCTION