Repair to departmental tanker No. JK02BV-2152 on its annual fitness / passing

Repair to departmental tanker No. JK02BV-2152 on its annual fitness / passing by way of change of Engine oil, Gear oil (from Gear box and Differential System) after flushing out old used oil. Providing and fitting of new oil filter, air filter and diesel filter set, air cleaner rubber etc. and then Filling of fresh engine oil (provided by the deptt.) and Gear oil in Gear box and Differential System (provided by the Department). Job includes checking of all the four wheels after dismantling of wheels. Segregation of components, washing properly all the component in diesel. Providing and fitting of front wheel bearing inner 01 no., front wheel outer – 1 No., brake lining front 1 set complete, rear wheel bearing outer 01 no., rear wheel bearing inner - 02 Nos., brake lining rear 1 set complete. All oil seals, brake oil- ½ ltr., P&F of 04 kg grease, greasing of all the wheels, making adjustment of brakes and bleeding thereof. Job includes dismantling of radiator assy from the vehicle with providing /fitting of new parts in place of old/worn out parts i.e. Water body-01 no, water body pulley-01 no., radiator mounting -04 nos., hose pipe set -01 set., complete Job includes repairs to fins, tubes and then joining the craked corners by binding solution to prevent leakage and fitting of the same to the vehicle after cleanings and testing, job includes filling of coolant-03ltr. Job includes providing and fitting of 1 No. counter shaft, 1 No. 3rd and 4th speed gears, sleeve set 1 set, synchronizing ring set complete , 1 No. main shaft bearing, 1 No. counter shaft bearing, 1 No. gear box bearings, 1 No. roller bearing,1 No of needle bearing assembling of all the gears by hydraulic pressure fitting. Providing and fitting of 1 set gear box oil seal, 1 set gear box joint set, 1 No. RTV silicon tube, gasket. Job also includes replacement of 02 No. gear shifting cable by way of providing and fitting of new one. Assembling, refitting checking and testing the gear box unit and back fitting with the vehicle. Job also Includes repair of self by dismantling of Self starter and then P/F of new parts in place of defective parts i.e. Self carbon brush set-01 set, Field coil -01 set, bendix drive-01 no., petrol for cleaning of parts, self solenoid switch-01 no., and voltage regulator-01 no. and complete checking & fitting after repair. Job includes denting of the damaged driver cabin of the vehicle by way of cutting and dismantling damaged portion of the cabin front and its sides viz. sheets and girder. Providing and fixing of new MS sheet for worn out portion in the floor and sides of the cabin inner and outer side, fabrication and fitting of new MS sheet for the floor by cutting and gas welding. The job includes cost of material viz. sheets, handles, locks, gas welding etc. Job includes repair of tank of tanker by way of welding of tank. Job includes Repair of both the rear mud guards of vehicle out of MS Angle and heavy gauge MS Sheet. Fitting of mud guard on the vehicle with the help of MS stiffeners and high quality welding. Complete washing of the vehicle. Making of surface of dented components after application of body solder and rubbing thereof. Spraying of one coat of red – oxide. Metal Primer inside and outside the tank and chassis of vehicle. The spraying of two coats of deco paint on the tank and on the vehicle. Complete letter writing on the vehicle including the tank and number plates. The Job also includes repairs to Electrical system of the vehicle by way of replacement of old /defective /burnt out parts of the vehicle, this also includes repair to the fuse box of the vehicle and replacement of burnt fuse and P/F of new head light- 02 no’s, Lever Combination Switch-01 no, Horn-01 no, Insulation tape roll-01no, Rear light assy.-02 no’s. LT wire 06 mtr. Job also includes P/F of new wiper blade-01 set, and testing the complete circuit system on load so as to ensure proper functioning of the auto-electric circuit of the vehicle. Job includes fitting of Retro-Reflective Tape on the vehicle so that vehicle is visible in case of night and low light. Job also includes deposit of token fees and fitness fees to regional transport office Jammu of the water tanker. Job also includes recalibration of governor. Complete job includes the cost of material and labour charges and taxes as applicable.