Provision of RTU for visibility of generation to SLDC for real time monitoring as per requirement of SLDC for grid connectivity of 5 MW solar power project at CME

Amount

Supply, Installation,testing and commissioning of Remote Terminal Unit RTU/RTUs along with all parafenia for visibility of generation and transfer of data points from 5 MW solar power plant to SLDC airoli for real time monitoring as per requirements of Chief Engineer (SLDC), Airoli, Navi Mubai for grid connectivity of 05 MW solar power project at CME. The job includes the following:

The Remote Terminal Unit RTU/RTUs under the proposed scheme shall be capable of communication with LD centres in IEC-104 protocol.

Communication media such as BSNL/MTNL leased circuit, MPLS, TATA Communication, Reliance Communication, VSAT etc. with latency less than 800 ms may be used for data transmission. The typical bandwidth requirement for real-time data communication is 64 Kbps and depends upon data volume and this includes leased lines from 5 MW solar site to SLDC Airoli with 5 years recurring fee.

SLDC already issued list of data points to be transmitted from 5 MW solar power project site in real time mode and the same is attached as Appx 'A'. Contractor is responsible for transmission/ visualization of these 21 data points from 5 MW solar side to SLDC Airoli/Kalwa or ALDC Ambazari as per requirements of SLDC.

Contractor shall submit complete proposal along with schematic diagram for RTU installation and data communication with LD Centres with the above confirmations/clarifications for approval of Chief Engineer (SLDC), Airoli, Navi Mubai.

This includes Integration of 5 MW solar data into the SCADA systems at SLDC Kalwa & ALDC Ambazari on IEC 104 protocol.

This includes Integration of Real time data from RTU of any make in IEC-104 Protocol is to be done in SLDC SCADA system.

Contractor shall submit RTU-DC installation, work completion report & commissioning report to this office as well as SLDC.

Contractor shall submit approved copy of single line diagram and layout from the Chief Engineer (SLDC), Airoli, Navi Mubai

All necessary documentation & liason for obtaining permissions for integration of Real time data from RTU in SLDC SCADA system shall be the resposibility of contractor. Any equipment & accessories not covered in the said job if required for integration, the cost of the same is deemed included in this quoted rate. No extra payment shall be made to the contractor on this account.

Contractor shall submit certificate from the Chief Engineer (SLDC), Airoli, Navi Mumbai towards visibility of generation of 5 MW solar power project to SLDC for real time monitoring.

Completion of all above is under the scope and responsibility of the contractor.

Note : In order to carry out integration work, MSLDC has approved the rates of integration to be paid by third party vendor to M/s Siemens. The rate for integration of RTU in SLDC-SCADA system is Rs. 3.00 Lakhs/ RTU ( Rs. Three Lakhs Only) plus GST at the rate 18 percent. The SLDC Fee for integration of real time data through RTU i.e. Rs. 3,00,000 + 18% GST shall be paid by GE (CME) Kirkee.

Kokban Automation Pvt Ltd

Innovative Engineers

SBS Enterprises