8976 PROVISION OF AUTOMATIC FIRE ALARM SYSTEM AT INS TRATA AND PROVISION OF FIRE ALARM AND FIRE MAIN SYSTEM AT CG COMPLEX NO P92 G6 AT NAVAL DOCKYARD MUMBAI

Amount

Supplying installation, Testing & Commissioning of Microprocessor based 4 loop capacity , Networkable analogue addressable type fire alarm control panel with capacity of minimum 99 detectors and 99 analog addressable devices in one loop. Four access levels, capable of taking Flash Scan devices, flash EPROM sufficient numbers of programmable relay controls for controlling AHUs, pressurization fans, ventilation fans at fire pump room, monitoring of fire sprinkler and fire hydrant pump, 240 volts AC power supply, automatic battery charger, 24 volts sealed lead acid batteries sufficient for 24 hours normal working and then be capable of operating the system for 2 hours during an emergency conditions as required. and panels shall have provision of integraton with BMS System.(UL/EN Approved) complete all as specified and directed. Make : Honeywell/Siemens/Bosch/Morley

LANDLINE/GSM FIRE ALARM AUTO DIALER WITH sms and Memory Available To Store 10 Phone Numbers dialling facility to reach the fire brigade to get the intimation about the location of the area Builtin Emergency Speech Dialer with 8 Numbers & 1/ 2 Messages,NO/NC contacts for both fire and fault, Automatic changeover arrangement to standby supply with battery charger with low battery indication,Fault/ failure indication such as MAINS FAIL, short, open, Battery FAIL etc,Micro-Controller Based System,Both Dialling Modes Can Be Used (Pulse/Tone),Recorded Message Playback Speaker Provision Available complete all as specified and as directed. Make : Agni/vighnaharta

Supply, Installation, testing and commissioning addressable Manual call point(Pull down/Break Glass Type). The device shall have an LED which shall blink in normal state and get steady on activation to monitor the health status of the device and shall be underwritters laboratories listed, semi flush type complete all as specified and directed. Make : Honeywell/Siemens/Bosch/Morley

Supplying installation, Testing & Commissioning of Addressable monitor modules for Sprinkler Flow Switch and Door Holders complete all as specified and as directed. Make : Honeywell/Bosch/Morley/Siemens

Supply fix and commissioning and test of addressable electronic hooter with built in amplifier unit with two tone generator of 100 meter range complete all as specified and directed. Make : Honeywell/Siemens/Bosch/Morley

Supplying installation, Testing & Commissioning of Analog addressable Multi Criteria (Optical +thermal) detector with mounting based LED for AFC(Above Ceiling & below ceiling.) as complete all as specified and as directed. Make : Honeywell/Bosch/Morley/Siemens

Supplying installation, Testing & Commissioning of Addressable control modules for AHU, Access control Integration & stairs Pressurization Fan Hooters / Sounders / Strobes etc complete all as specified and as directed. Make : Honeywell/Siemens/Morley/Siemens/Eqvlt

Supply and fix fault isolator module with automatic resetting arrangement complete all as specified and directed. Make : Honeywell/Edward/Bosch/Morley/Siemens/Eqvlt

Supply & laying PVC FRLS armoured cable 1.5sq mm solid copper conductor 2 core, XLPE Insulated, Extruded PVC sheathed, galvanized steel strip, electric power cables (heavy duty) 1100 Volts grade, laid in duct / along pole/wall etc including making connection complete and making good the distrubed surface matching with existing surface complete all as specified and as directed. Note : 1. The cost of Al thimbles/lugs and cable gland etc is incl in quoted rate and no extra payment will be made for it. Make : Polycab/RR cable/ Finolex

Supplying installation, Testing & Commissioning of Response indicator for Above ceiling detectors & Cabin Detectors complete all as specified and as directed. Make : Honeywell/Bosch/Morley/Siemens

Supplying installation, Testing & Commissioning of The GUI based main network software must be capable of graphically representing each facility being monitored with floor plans and icons depicting the actual locations of the various systems; and / or sensors’locations. The GUI software shall be located in control room in one of the blocks and shall monitor all the blocks panel connected with each other. Along with workstation complete all as specified and as directed. Make : Honeywell/Edward/Bosch/Morley/Siemens/Eqvlt

Supply, erection, testing & commsioning of A.G. pipe line for court yard ,G.I. Pipe 'C' class as per IS : 1239 spefn with ISI mark including necessary fittings like bends/flanges/ Nut bolts/ packing sheets etc. with 1 coat of red oxide primer and 2 coats of Apcolite paint. ( Above Ground ) and upto 15 meter HUME PIPE with Antocorrosive pypkote 4mm Thickness wrapping Coating with up to 1 ft digging work (Below Ground) complete all as specified and directed. Make : Jindal/TATA/Maharashra pipe/ (a) 150 mm dia pipe

(b) All as per item No. 12 above but for 100 mm dia complete all as specified and directed.

(c) All as per item No. 12 above but for 80 mm dia complete all as specified and directed.

(d) All as per item No. 12 above but for 25 mm dia complete all as specified and directed. Note:- Above rates include Supply, erection, testing & commsioning of Civil Concret block(Min 200 mm inside and and 200mm outside to reach the height of the pipe min 550mm with of Pedestal Support for external GI pipe line for Outer Area Ringline , including necessary fittings like Pipe Clamp with Anchor Fastener, 12 mm U clamp, C channel 75 x 6 mm thick with Hole Fastner etc. with 1 coat of red oxide primer and 2 coats of Apcolite paint. ( Above Ground ) Make : Standard

Supply , Erection Testing & Commissioning of C.I. Butterfly valve - PN 16 with necessary flanges / nut bolts etc.of following dia complete all as specified and directed. Make : DRP/nanak /Donfess/intervalve/normex/lehry/ISI Standard/Equ (a) 150mm dia

(b) All as per item No. 13 above but for 100 mm dia complete all as specified and directed.

(c) All as per item No. 13 above but for 80 mm dia complete all as specified and directed.

(d) All as per item No. 13 above but for 25 mm dia complete all as specified and directed.

Supply , Erection Testing & Commissioning of C.I.Non Return valve of 80mm dia with necessary flanges / nut bolts etc. complete all as specified and directed. Make : DRP/nanak /Donfess/intervalve/normex/lehry/ISI Standard/Equ

Supply , Erection Testing & Commissioning of(sluice Valve) Gate valve of 80mm dia with necessary flanges / nut bolts etc.complete all as specified and directed. Make : DRP/nanak /Donfess/intervalve/normex/lehry/ISI Standard/Equ

Supply , Erection Testing & Commissioning of "Y" Strainer of 80mm dia with necessary flanges / nut bolts etc. complete all as specified and directed. Make : DRP/nanak /Donfess/intervalve/normex/lehry/ISI Standard/Equ

Supply , Erection Testing & Commissioning fire fighting Pressure Gauge upte 0 to 21 Bar with necessary mounting arrangements and accessories complete all as specified and directed. Make : DRP/nanak/indfos /Donfess/intervalve/normex/lehry/ISI Standard/Equ

Supply , Erection Testing & Commissioning of Booster pumps for 440 V, 3 Phase, 50 Hz Confirming to IS- 12469 :1988 With CI Casing bronze impeller and stainless steel shaft mounted on heavy duty bearingssuitable for 440 volts, 3 phase, 50 Hz Suitable cement concrete foundation with plaster, (design and drawing to be provided by the Contractor while the foundation will be done. complete with Antivibration arrangement of cushy foot mounting. (At Terrace level)) complete all as specified and directed. Make :Kirlosker/Crompton/PEW

Supply, installation, testing & commissioning of diaphragm type adjustable pressure switch for starting and shutting down the Hydrant, Sprinkler,water curtain and Booster pumps automatically. The pressure switch is dictated by line pressure with stainless steel (316) movement, pressure element and sockets etc.complete all as specified and directed. Make : Donfess/Indfos/ISI standard

Supply, installation, testing & commissioning ofFire Fighting Electrical Panel Suitable for Booster Pump 4 core wire supply with 3 phase outgoing The compartmentshall containCT operated digital or analog electronic ammeter of suitable and indicating lamps with Automatic pressure maintan option on MCBs for`ON'/OFF`TRIP' status of pump motors complete all as specified and directed. Make: ASES/AGNI/NEEL/ISI STD

S &F XLPE insulated, armoured heavy duty electric cable with aluminium conductor, 1100 volts grade, cross-sectional area 35 sqmm 3.5 core complete all as specified and directed. Make: polycab/finolex/RR Cable/kei cable/havells

Supply , Erection Testing & Commissioning Air realese valve complete all as specified and directed. Make : DRP/nanak /Donfess/intervalve/normex/lehry/ISI Standard/Equ

Supply , Erection Testing & Commissioning fire fighting swivelling type Hose Reel Drum complete with 3/4" dia x 30 mtrs length thermoplastic ISI mark hose & metal nozzle with necessary mounting arrangements and accessories complete all as specified and directed. Make : Vintex fire/safety plus/newage/ isi std

Supply , Erection Testing & Commissioning of SS branch pipe nozzle as per IS 903 with ISI mark complete all as specified and directed.Make : Vintex fire/safety plus/newage/ isi std

Supply , Erection Testing & Commissioning of hose pipe 15 meter as per IS:636 type I with ISI mark duly SS wire binded with SS male & female coupling as per IS 903 with ISI mark complete all as specified and directed. Make : Vintex fire/safety plus/newage/ isi std

Supply , Erection Testing & Commissioning MS Hose Box duly painted red from outside & white paint inside to accommodate 2 length of hose & 1 nozzle complete with glass , allen key lock etc.,size 800 x 600 x 250 mm including fitting on the ground with metal sheet and standard arrangement complete all as specified and directed. Make : Vintex fire/safety plus/newage/ isi std

Supply , Erection Testing & Commissioning of SS fire hydrant valve oblique type 63 mm dia single outlet for court yard & wet riser as per IS : 5290 with ISI mark with required accessories like GI nut bolts / Flanges etc complete all as specified and directed. Make : Vintex fire/safety plus/newage/ isi std

Supply & fixing fire alarm control panel complying with BE EN 54-5 loop with 99detectors & 99 Modulas & upto 200 dectors ad modules (per each loop) complete all as specified and directed.

Supply & fixing Detectors complying with and type certified to EN -45 Addrssable type multi senser detector photoelectric/Optical with base self built intellgence as per IS:11360 complete all as specified and directed.

Supply& Fixing addressable manual call point resettable type complete all as specified and directed.

supply & fixing addressable electronic sounder cum srobe complete all as specified and directed.

supply & fixing remote response indicators complete all as specified and directed.

supply & laying PVC arrnoured cable 1.5sq mm copper conductor 2 core complete all as specified and directed.

supply & fixing Addressable control module complete all as specified and directed.

supply & fixing Addressable monitor module complete all as specified and directed.

Supply and fix ECO fore Automatic Modular ABC Powder type fire extinguiser complete all as specified and directed.

Dismantling of wall and ceiling boards (fibre,pulp,insulation etc) or insulation boards/slabs/blankets any thickness includinf cover fillets complete all as specified and directed.

M&L for false ceiling made out of 600X600X4 to 6 mm thick ceiling board/tiles deep panel suspenso system made out of powder coated GI sheet main Tee of size 23.50 X40X0.63 mm and cross Tee of size 23.50x23.50x0.63mm and angle sheet 19X19X0.63mm including 3mm GI wire for suspending holts necessary washers nut/cleats/pin hook etc for securing frame work to ceiling to the snap grid including provision of necessary holes/cutting for providing light/far as required including making necessary recesses/projected pattern complete all as specified and as directed.

Taking down cement plaster on brick surfaces built in cement mortar including raking out joints ,hacking for key scrubbing down with water upto (G+5) floor building including scaffolding etc complete all as specified and as directed.

M&L for rendering 15mm thick in CM 1:4 on fair faces of brick work or concrete surfaces finishing the surfaces finishing the surfaces even and smooth ( without using extra cement) mixed with waterproofing compound complete all as specified and as directed. Note: Waterproofing compound shall be measured and paid seperately

M&L for rendering 10mm thick in CM 1:3 on fair faces of brick work or concrete surfaces finishing the surafces even and smooth complete all as specified and as directed.

M&L for preparation of new plastered surfaces and applying two coats of oil emulsion distemper over a coat of chalk whiting on ceiling complete all as specified and as directed.

M&L for preparation of new plastered surfaces and applying two coats of oil emulsion distemper over a coat of chalk whiting on wall complete all as specified and as directed.

M&L for applying 3mm thick wall care putty on wall (JK Birla wall care putty) on old/new plaster surafce complete all as specified and as directed.

Supply only integral water proofing compound complete all as specified and directed.

shubham construction

ASHOK ENTERPRISES

GANGAJAL