09/EWC(B)/2024-25

Amount

Supply of following materials

M.S angle 65x65x6mm, 2700mm

M.S angle 65x65x6mm, 4300mm

Top channel 125x65x6mm 3200mm

Gaurding angle 65x65x2950

Loading, unloading and safe carriage of the following materials from any Electy. Store Center of Electricity store division of Bareilly zone to site of work

9.0 M long PCC pole

ST pole 11 Mtr. Long

33 KV cross arm

33 KV pin insulator

M.S. Earthing rod

ACSR Dog conductor

33 KV disc insulator B&S type 70 KN

Disc fitting Dog/Racoon 70 KN

Complete Stay set complete

G.I wire 8 Swg

Erection of the following supports including cutting, making holes, fixing of all types of accessories digging of pits complete in all respect, as per RESSPO drawing.All types of steel, clamps, stone pad, nut, bolt washers would be provided by the contractor.

Single support of PCC pole 9 mtr long.

Single support of ST Pole 11mtr long.

Section double pole structure on PCC Pole 09 Metre for 33KV line

Double pole structure on STP Pole 11 mtr long complete with bracing.

Erection/fixing for stay set with stay wire and clamp as per RESSPO drawing including binding, clamping, tightening, and nozzeling etc. complete in all respect including its grouting in ratio 1:4:8 before back filling of the pits as per RESSPO schedule. All clamps, nuts, bolts, cement. brick, ballast, sand etc would be provided by the contractor.

Replacement of following damage material of above 33 KV Line.(Material provided by Department.)

Pin Insulators wih Pins

Disc Insulator with fittings

X-arms

33 KV F Clamp with holding clamp (provided by firm)

Concreting of all type of supports in 1:4:8 ratio from bottom of pole to ground level and plinthing of supports upto 300mm above ground level by using cement ,brick ballast and sand in ratio 1:4:8 as per RESSPO drawing with watering/curing properly upto proper setting of plinthing.All matrial would be provided by the contractor.

Laying and sagging of 3 phase ACSR Dog conductor of 33 KV Line Allahganj Shahjahanpur including jumpering, hoisting, fixing of all type of insulators, binding, jointing and its clamping etc. in all respect.

Earthing of each PCC Poles of the line is to be done by inserting the MS earth rod (1800x20mm) into soil by hammering and properly fastning with GI wire to each support by nut & bolt. Earthing rod must be 0.15Mtr.above from the plinth of the support. All type nut & bolt would be given by the contractor.

Earthing of each S.T Poles of the line is to be done by inserting the MS earth rod (1800x20mm) into soil by hammering and properly fastning with GI wire to each support by nut & bolt. Earthing rod must be 0.15Mtr.above from the plinth of the support. All type nut & bolt would be given by the contractor.

Painting of following supports with one coat of red oxide primer and two coats of aluminum white paint of ISI mark and top danger portion of each support must be painted by providing two coat of Post Office Red Paint (1.5mtr upper portion of support.) Paint and material would be given by contractor to complete the job.

Single Pole of S.T Pole .

Double Pole of S.T Pole .

Clearing of the line route by cutting of tree branches during erection of line and also upto the time of energisation completely as per direction of Incharge.

Fixing of danger board and number plate and G.I barbed wire on each pole including proper clamping. All material would be provided by firm.

Safe dismentling of old & rotten ACSR Rabbit conductor of existing 33 KV Allahganj Line without damage of any insulator, cross arm, clamp etc. of existing 33 KV line.

Fabrication and fixing of guarding angle on Single/double poles, Stringing and sagging of three nos. Earth/GI wire with cardle guarding of above 33 KV line as per RESSPO Norms including provision of all necessary clamps and hooks. Shifting of existing line conductor of 11 KV/LT line to maintain proper clearance in between both lines (all required material will be provided by the contractor except earth/GI wire).

Loading. unloading and safe carrige of old & rotten Scrap material from site to Store center, SPN

M/S TIWARI TRADING COMPANY (BID ID -5101267)