Supply, installation and commissioning of various special analysers for measuring (BOD, COD, TSS and PH) and Online monitoring software for Sewage Treatment Plants with data connectivity at Dubrayapet, and Lawspet, Puducherry

Part-1: Supply, installation and commissioning of various special analysers for measuring BOD, COD, TSS & PH for Sewage Treatment Plants located various areas of Puducherry (i) MIQ/TC 2020 3G-C6 Multi-parameter measuring converter, for connecting up to 20 IQ sensors. Scope of supply: MIQ/TC 2020 3G Terminal/Controller, MIQ/C6 with 6 analog outputs (0/4-20 Ma), MIQ/PS wide-range power supply. IQ SensorNet 2020 3G (Controller) Powerful yet simple, the WTW IQ SensorNet 2020 3G is a modular water quality system for complete process control designed for wastewater. The 2020 3G network can accept additional sensors easily at any time and grow as your facility grows. Benefits include better network visibility and management, early detection of network failures, improved compliance with regulatory targets, and cost savings (energy, pump/blower maintenance, and labor). • User-replaceable cables and sensors. Many sensors provide ultrasonic cleaning. • Centralized power supply along entire network; 2-wire cable provides power and communications • Lightning protection along network • 2020 3G provides tactile buttons; easily use while wearing gloves • Modular expansion from 1 to 20 sensors; ability to extend network with additional modules • Modular expansion from 1 to 20 sensors; ability to extend network with additional modules

• The system start automatically after the power is reset to the system (in case of power failure). • The controller consumes low power with consumption of less than 5W. • Sensors connected to the system is automatically detected and initialized. • No extra system configuration should be needed for substitute/replacement sensors. • The system have Service mode for cleaning/calibration/maintenance activities. • It is possible to download the data via the USB interface an extremely fast data exchange to USB memory stick. • System is fully programmable with multiple levels of access control with help of Electronic-Key for data security and protection against non-authorized access to avoid any tampering or changes to the system configuration by unauthorized access. • The controller stores the sensor configurations and calibrations • The controller is having Logbook to record the data • We provide the software / firmware update free of cost when they are available. • The system has a status LED that gives reliable and fast information regarding function and status of system. And the Controller shows a LED for diagnostic purposes on the front. This LED show normal and malfunctions of the system at a glance. • Data Output to Control System: The System have the capability to transmit the required 4-20 mA Analog Outputs as a minimum.

• In addition to above, the system has provision to output Profibus, Modbus/RS 485, RS 232, LAN, GPRS, GSM compatible signals in future with addition of respective module as and when required. • The system is able to operate both on AC Power (100-240 AC) or 12/24V DC. • Ambient Conditions Operating temperature: -4 °C ... +55 °C • Storage temperature: -10 °C ... +65 °C • Housing Material - Non corrosive e.g. Acrylonitrile-Styrene-Acryloesterpolymer or better • Protection Rating IP 66/equivalent to NEMA 4X • Electromagnetic Compatibility: EN 61326, Class B; FCC Class A, EMC for indispensable operation • Integrated Lightning Protection: According to EN 61326 enhanced overvoltage protection for the entire system, implemented in each component. (ii) CarboVis® 705 IQ TS (BOD, COD,TSS) Optical BOD and TSS probe (60 mm) with spectral processing wastewater treatment plants with integrated ultrasonic cleaning. Supplied with multifunctional slide and Shock-Absorption-Rings BOD/COD/TOC/ TSS Sensor for higher range. Spectral Online Sensors The CarboVis sensor measure the total spectrum range from ultraviolet to long wave visible light (200-720 nm; UV-VIS sensors) or in the ultraviolet range (200-390 nm; UV sensors). The measured values are determined from the high information content of the spectral data.

Spectrometry Sensor for Detection of BOD/COD/TSS etc. • Measurement Principle: Measurement of full wave lengths spectra • (UV-VIS Spectrometry) from 200-720 nm, • Multi parameter probe ideal for monitoring of BOD/COD/TSS in Waste water • Direct in-situ measurement in inlet/outlet of waste water treatment plant • The sensor with efficient integrated ultrasonic cleaning facility. If the ultrasonic cleaning can't be provided then the bidder should include the air-pressure cleaning system to ensure long maintenance intervals for this sensor. • The Material of construction is Titanium or equivalent. • The sensor is completely reagent free for operation. Measurement Principle: Uv Vis Spectrometry (200-720 nm) Light Source: Xenon Flash Lamp Accuracy in Standard Solutions: +_3% of the measured value or +_2.5 mg/l Ambient Conditions: Operating temperature: 0 deg * C to 45 deg * C Storage temperature: - 10 deg * Cto + 50 deg * C Carbon parameters To measure the organic load of water, the parameters COD or BOD are used. The differences in these parameters (marginal column) show that these measurements are not identical and that the measured values therefore cannot be equal. In-situ measurement Continuous measurement => fast response time, suitable for control strategies CarboVis® 705 IQ TS

• Parameter: Carbon: COD/BOD/TSS/PH • Measuring Principle : Spectral Measurement in the UV/VIS range (200-720 nm) • Applications: Municipal wastewater: inlet, effluent • Measuring Ranges in Standard Solution: COD: 0.1... 800.0 mg/l BOD: 0.... 500 mg/l • Accuracy in standard solution: +3% of the measured value ±2.5 mg/l • Measuring Ranges TSS (Option): TSS: Effluent: 0.0... 900.0 mg/l TS • Materials: Housing: Titanium 3.7035, PEEK Window: Sapphire glass • Pressure Resistance: ≤1 bar • Ambient Conditions Operating temperature: 0ºC… +45ºC; Storage temperature: - 10 degº C… +50 • Flow velocity: ≤3 m/s • pH range: pH 0... pH 14 • Dimensions : 802 x 59.9 mm (length x diameter) • Weight: Approx. 4 kg (iii) SensoLyt® 700 IQ/SET Robust digital Ph/ORP sensor (SensoLyt® 700 IQ) including Ph electrode (SensoLytⓇSEA) PH Sensor SensoLyt® 700 IQ • Integrated temperature measurement and compensation is provided in the pH sensor

• Sensor check function to detect broken glass of the pH electrode. • The pH sensor should have galvanically separated input. • Calibration history is stored automatically in the sensor. • Sensor calibration can be done in the laboratory or field. • The pH combination electrodes is required very little maintenance and there should be no electrolyte replacement • The sensor is preferably with efficient integrated ultrasonic cleaning facility. If the ultrasonic cleaning can't be provided then the bidder should include the air-pressure cleaning system to ensure long maintenance intervals for this sensor. Technical Specifications: • Measuring Range:pH-0.00-14.00 • Signal Output-Digital • Sensor Check function is available in the pH sensor • Power Consumption: less than 0.5 Watt • Temperature Sensor is integrated in the pH sensor • Temp Compensation: -5 to +50 Deg C • Max Pressure for Sensor: 10 Bar • Max Pressure for Sensor Cable: 10 Bar • Transient Voltage Protection is integrated in the sensor • Sensor body: Titanium or equivalent • Protection type: IP 68 for both Sensor and Cable (iv) SACIQ-7,0 SW Sensor adapter cable for all IQ sensors, in seawater design, with IP 68 waterproof connection to the IQ SUVWXY NUZ system. Cable length: 7 m with screwable SACIQ-Plug. The cost shall includes GST and all other taxes alongwith Defect Liability Period (DLP) for 2 years.

PPCB Data connectivity with Hardware & Software. The cost shall includes GST and all other taxes alongwith Defect Liability Period (DLP) for 2 years.

Part-2: Comprehensive Maintenance Contract with periodical maintenance at site, calibration and replacement of worn-out / damaged spares for maintaining the instrument in full running condition. 3rd year

4th year

5th year

6th year

7th year

8th year

9th year

10th year

Please Enable Macros to View BoQ information