Construction of 30000 litres OHTand Pump Room and New Borewell Edaiyathi south Adhidhiravidar Street and PDS Poovalur Adhidhiravidar Street and Drainage Poovalur Adhidhiravidar Street

Amount

Part 1 CONSTRUCTION OF 30000 LITRES OHT,PUMP ROOM AND NEW BOREWELL TO EDAIYATHI SOUTH ADHIDHIRAVIDAR THERU IN EDAIYATHI PANCHAYAT

Earthwork excavation for foundation in all soils and sub soil to full depth as may be directed except in hard rock requiring blasting but inclusive of shoring and requiring the sides of foundation. First depth upto 2m

Earthwork excavation for foundation in all soils and sub soil to full depth as may be directed except in hard rock requiring blasting but inclusive of shoring and requiring the sides of foundation.Second depth below 2m

Supplying and filling in foundations and basement with filling M- sand in layers not exceeding 15 cm.thick,well watered,rammed and consolidated etc. complete complying with standard specifications.

Plain Cement Concrete 1 : 4 :8 ( one part of cement, four parts of sand and eight parts of hard broken stone ) using 40 mm gauge hand broken hard broken granite stone jelly complying with standard specifications in foundations and basement.

RCC M30 GRADE using graded aggregate of HBGs excluding cost reinforcement, centering, shuttering, but including cost of concrete, placing, vibrating etc complete

a) For raft below GL(1.50 - 4.50) below GL

b) For coloum and brace upto GL(0-1.50)below GL

c) For coloum and Middle brace upto (0-3.58) above GL

d) For coloum beam floor slab and side wall from GL (3.58-6.58) above GL

e) For side wall and roof slab 7.35-8.35 above GL

Supplying and erecting Centering and Shuttering for soffits including necessary supports and strutting up to 3 M height for plane surfaces as detailed below in all floors with all cross bracings using Mild Steel sheets of size 90 x 60 cm and 10 BG stiffened with welded Mild Steel angle of size 25mm x 25mm x 3 mm for boarding laid over silver oak joists of size 10cm x 6.50 cm spaced at about 90 cm centre to centre and supported by casurina props of 10cm to 13 cm dia spaced at not more than 75 cm centre to centre etc. complete complying with the standard specification.(Payment for centering shall be given after the concrete is laid).

Plane surface - below GL

Raft side

For GL brace and middle brace B1

For GL brace and middle brace B2

For Floor beam and bottom of floor slab

Curved surface 6.00 to 8.45m

for side wall& roof slab sides hanch

Square coloum

For coloum below GL

ForGL to 3.30m

For coloum 3.30m to 4.30m

For coloum 4.30m to 5.30m

For coloum 5.30m to 6.30m

For coloum 6.30m to 6.85m

Exterior Emulsion two coatgs for approved colour including cost and conveyance and all labour charges etc complete

supplying and fabricating and placing in position MS steel or ribbed for steel for all reinforced cement concrete works as per the design given including cost of steel and binding wire in all floors etc, complete complying with standard specification

Fabrication, supply, delivery and fixing of outside MS ladder of 45cm wide 50x50x6mm MS angle for side stepsin 16mm MS plain rods fixed at 30mm c/c welded, joinded etc.

Providing and fixing of RCC access ladder in RCC 1:1.5:3 mix using 20mm HBG metel including cost and conveyance and all labour charges etc complete

Providing PVC ventilating arrangments, mosquito proof nylon net with 110mm PVC pipes and cowl etc complete

Providing manhole cover of size 0.60x0.60m in RCC 1:1.5:3 mix with suitable reinforcement and 50x50x6mm MS along edges etc complete

Painting manhole cover of size 0.60x0.60m in RCC 1:1.5:3 mix with suitable reinforcement and 50x50x6mm MS along edges etc complete

Refilling with excavated earth other than sand complying with standard specification for filling in trenches

65mm dia GI pipes for tank connection

65mm dia GM gate valve

65mm dia non return valve

65mm dia GI coupling

65mm dia GI Elbow

65mm dia GI Bend

65mm dia GI Flange set

65mm dia GI union

Provision for GI pipe line work including cutting, threading & fixing charges

Earth work excavation of and depositing on bank with intial lead of 10mtr. Initial lift of 2mtr in hard stiff clay stiff black cotton soils, stiff earth , shales murrams, gravel stoney earathand darth mixed with 50% fair sized boulders and hard gravelly soils

Supply & Devlivery of PVC rigid pipes for potable water supply as per IS 4935/1988 and amended from time with ISI marking of other following sizes with necessary couplers or bel ended pipes as specified in ISI and the required quantity of solvent cement having the required working pressure and for delivery at site of works

63mm PVC Rigid pipes

Refilling with excavated earth other than sand complying with standard specification for filling in trenches

Conveyance of PVC rigid pipes and lowering into the trenchlaying to proper gradian and aligment, jointing PVC coplers with solvent cement and testing to required pressure including conveyance of wate into one Km lead for filling in the pipes excluding cost of materials which will be supplied

63mm PVC rigid pipes

63mm PVC bend

63mm PVC Tee

63mm PVC End cap

Supply of water meter dirt box and eretion (water meter 50mm)

Supply of Cholrinator

Provision for Pumb Room

Earthwork excavation for foundation in all soils and sub soil to full depth as may be directed except in hard rock requiring blasting but inclusive of shoring and requiring the sides of foundation. First depth upto 2m

Plain Cement Concrete 1 : 4 :8 ( one part of cement, four parts of sand and eight parts of hard broken stone ) using 40 mm gauge hand broken hard broken granite stone jelly complying with standard specifications in foundations and basement.

Earth filling in basement & sides of foundation with excabated earth including ramming and consolidation etc., complete

Supplying and filling in foundations and basement with filling M- sand in layers not exceeding 15 cm.thick,well watered,rammed and consolidated etc. complete complying with standard specifications.

Brick work in CM 1:5 using country bricks of size 8.75"x4.25"x2.00" including cost of all materials, labour charges , curing etc, complete and as directed by TWAD Board officers

For foundation and basement

For Super structure

Reinforced cement concrete 1:1.5:3 using 20mm size hard broken stone jelly for the following members. The rate to excludethe cost of steel for

Steel Centering for soffits of RCC members including shuttering , strutting to the cnetring and providing supports etc complete for the following members using MS sheets of size 90cmx60cm and BG 10 Gaugessiffened with welded MS angles of size 25x25x3mm laid over silver

Plastering with CM 1:5 With 12mm thick over brickwork portion including labour charges for mixing finishing and curing etc., complete and as directed by TWAD Board officers.

Special ceiling plastering for RCC slab with CM 1:3 ,10cm thick over RCC surface including labour charges for mixing finishing and curing etc,complete and as directed by TWAD board

Flooring in CC 1:4:8, 10cm thick using 40mm HBS metal and top finished with cement mortar 1:3,12mm thick including labour charges for mixing, finishing and curing etc,complete and as directed by TWAD Board

Supply and fixing of MS Door of sizes 1.00x2.00m in MS angle 50x50x4mm and MS flat 35x6mm with MS sheet of 18gauge including ventilating arrngements using 20mm square MS rods with locing arrangements including two coats of approved enamel painting over one coat of primer

Supply , fabricating and fixing in position of RTS rods including cost of steel and binding wire etc, complete

Supply and fixing of RCC Box type jolly of size 0.6x0.45m

Painting two coats with approved cement paint over one priming coat of white cement over cement palstered wall surface and ceiling inlcuding cleaning preparing the surface and curing etc., complete

White washing two coats using fine screened shell lime for the new plastere surface for inner and outer side of the room including the cost of materials labour charges etc complete

weathering coarse over RCC roof including fixing one coarse of pressed tiles etc complete

Electrification charges

Light point / Fan point SD 21

Plug point SD 38

16Amp DPIC SD 142

Meter Board SD 125

GI service SD 67 connection to main

Service pipe SD 62

4x40W tube SD 87

BH Fitting SD 80

Earth connection SD 77

Providing Borewell

Conducting Geophysical survey Fixing the location

Drilling of bore wells any where in thanjavur district including transpotation from one place to another place within the above district in alluvial soil (or) sedimentary state of clay and sand stone shales, pebbles, boulders etc, by first taking

Drilling 150mm pilot bore

Up to 60m depth ending below ground level

From 60m and up to 90m depth ending below ground level

From 90m and up to 120m depth ending below ground level

From 120m and up to 150m depth ending below ground level

Reaming from 150mm dia pilot of bore to 300mm dia bore as directed by the department officers

Up to 60m depth ending below ground level

From 60m and up to 90m depth ending below ground level

From 90m and up to 120m depth ending below ground level

From 120m and up to 150m depth ending below ground level

Labour charges for inserting PVC Casing pipes assembly in the drilled hole including jointing the pipes with Pvc Couplers with cement pases etc, complete

Charges for developing the borewells with air compressor of 600cm capacity including transportation labour and fule charges for compressor as directed by departmental officers etc

Supplying and delivery of the following materials as per ISI Specification

165mm PVC plain casing

165mm PVC Screen casing pipes

165mm PVC End plug

Supply and delivery of single phase 7.5Hp pumpset with mortar as per ISI 200 Lpm x100m hed suitable accessories for the above pumpset

Supply and delivery of 7.5Hp panel board and all its accessories suitable for submersible pumpset star detail

Supplying and delivery of the following GI pipes and special

50mm GI Bend

50mm UPVC pipe

50mm GI pipe

50mm GI flange washer with bolt nut

50mm GI Adaptor

50mmMS Clamp set

50mm GI Elbow

4sqm flat copper submersible cable

56/0.3(4sqmm) copper wire for service connection(finolex)

16mm Nylon rope

7/20 GI wire 14Swg Tc wire

Main switch(16AMP - 230V)

fuse carrier (16 AMP)

Borecover using MS flat of size 1cm *3mm and MS sheet on top with bolting arrangements for curing cap in position

Labour charges for Erection of pumpset, in the borewell including connection of submersible cable etc

Provision for Name board charges

Part 2 CONSTRUCTION OF PUBLIC DISTRIBUTION SHOP AT ADHIRAVIDAR STREET IN POOVALUR PANCHAYAT

Earthwork excavation for foundation in all soils and sub soil to full depth as may be directed except in hard rock requiring blasting but inclusive of shoring strutting and requiring the sides of foundation

Supplying and filling in foundations and basement with filling sand in layers not more than 15cm. Thick well ramed, watered and compacted complete

Plain Cement Concrete 1 : 4 :8 ( one part of cement, four parts of sand and eight parts of hard broken stone ) using 40 mm gauge hand broken hard broken granite stone jelly complying with standard specifications in foundations and basement.

Brick work in cement mortar 1:56 mix using country bricks 83/4"41/4"x21/4" including cost and conveyance of all materials to site and all labour charges etc complete

Below Basement

Above Basement

Supplying & Erecting centering for sides & soffits including necessary supports & strutting upto 3.29m height for plane surfaces in all floors with all cross bracings using mild steel sheets of size 90x60cm&10gauge stiffened, welded with steel angle of size 25x25x3 mm for boarding laid over silver oak joists of size 10x6.5cm spaced @ about 90cm and supported by casurina props of 10-13cm dia sapced @75cm etc., complete complying with standard specifications and as directed by the departmental officers. Rate for 10m2 for the following items.

Below Basement

For column

For roof slab, lintel,beam

For Sunshade

Supplying and fabricating and palcing in position MS steel or ribbed for steel for steel for all reinfornced cement concrete works as per the desubg given including cost of steel and binding wire in all floors etc complete complying with standard specification

Plain cement concrete 1:1.5:3 mix using 20mm ISS HBG metal for all RCC item of works excluding cost of rein forcement adn fabricating charges, centering and shuttering but including curing and providing fixtureslike fan clamps in the RCC floor or roof slabs

Plain cement concrete 1:2:4 mix using 20mm ISS HBG size metal including cost and conveyance of all materials to site and all labour charges etc complete

Brick jelly lime concrete using 20mm brick jelly with slacked lime in the ratio of 32:12:5 including cost and conveyance of all materials to site and all labour charges for mixing, laying and finishing etc complete for 10cum

Finishing the top of roof with pressed tiles including cost and conveyance of all materials to site and all labour charges etc complete

Providing granolithic flooring with CC 1:2:4 mix 25mm thick including cost and conveyance of all materials to site and all labour charges etc complete

Paving the floor with ceramic tiles 305x305x6mm thick including cost and conveyance of all materials to site and all labour charges etc complete

Dadooing with glazed tiles of size 15x15x6mm including cost and conveyance of all materials to site and all labour charges etc complet

Plastering with CM 1:3,10mm thick including cost and conveyance of all materials to site and all labour charges etc complete

Plastering with CM 1:5,12mm thick including cost and conveyance of all materials to site and all labour charges etc complete

White washing two coats using shell lime inlcuding cost and conveyance of all materials to site and all labour charge etc complete

Exterior emulsion two coats over priming coat including cost and conveyance of all materials to site and all labour charges etc complete

Supplying and Erecting pull and push type rolling shutter with ISI Make of approved size and section using 18GI sheet.The shutter shall be painted with one coat of red oxide primer and the rate is inclusive of hood covers,transportation charges etc

Supply and fixing of mild steel doors as per standard departmental specifications including cost and conveyance of all etc., complete

Supply and fixing of mild steel windows as per standard departmental specifications including cost and conveyance of all etc., complete

Supply and fixing of mild steel See through as per standard departmental specifications including cost and conveyance of all etc., complete

Supply and fixing of mild steel Ventilator as per standard departmental specifications including cost and conveyance of all etc., complete

Painting two coats over new iron works using ready mixed enamel paint including cost and conveyance of materials and all labour charges etc complete

Providing and fixing of PVC rain water down fall pipe 110mm dia with necessary TW clamps, plug, shoes, bend, screws, nails, etc complete

wiring with 2x1.5sq.mm(22/0.3) PVC insulated SC unsheathed copper conductor of 1100V grade insuitable PVC rigid pipe on wall and ceiling with PVC accessories and with TW switch box and 5A FT switch with painting of suitable colour for open PVC light point/fan point (SD 18)

wiring with 2x1.5sq.mm(22/0.3) PVC insulated SC unsheathed copper conductor of 1100V grade insuitable PVC rigid pipe concealed in wall and ceiling with PVC accessories in flush with wall 150mmx100mmx113mm TW Switch box with 3mm thick hylem sheet cover for 5A 3pin non interlocking wall socket with 5A flush type switch with continuous earth wire connection of 14 SWG TC wire and making good of the concealed portion with suitable connection mains(SD38)

Supply and run of 2 of 6sq.mm(84/0.3) PVC insulated SC unsheathed copper conductor of 1100V in 7/20GI bearer wire for service connection mains(SD 66)

Supply and run of 2x1.5sq.mm (22/0.3) PVC insulated SC unsheathed copper conductor of 1100V grade in 25mm dia GI pipe suitably bebt at both ends with necessary angle iron upright and end supports for mains(SD69)

Supply and fixing of WT bulk head fitting with guard suitable for suitable for 11W CFL lamp with CFL (SD 83)

Supply and fixing of 16Amps DPIC switch of 500V with fuse and neutral on suitable TW box PWD Earthing (SD 142)

Supply and fixing of 1200mm (48") AC ceiling fan complete with stepped electronic 300W regulator with 300mm down rod on the existing clamp(SD 110)

Supply and fixing of CFL bulb

Provision for Name board charges

Part 3 CONSTRUCTION OF CEMENT CONCRETE DRAINAGE WITH FILTER AT POOVALUR ADHIRAVIDAR STREET IN POOVALUR PANCHAYAT

Earthwork excavation for foundation in all soils and sub soil to full depth as may be directed except in hard rock requiring blasting but inclusive of shoring strutting and requiring the sides of foundation

Supplying and filling in foundations and basement with filling sand in layers not more than 15cm. Thick well ramed, watered and compacted complete

Plain Cement Concrete 1 : 4 :8 ( one part of cement, four parts of sand and eight parts of hard broken stone ) using 40 mm gauge hand broken hard broken granite stone jelly complying with standard specifications in foundations and basement.

Supplying and erecting centering shuttering including necessary supports for plane surface in foundation and basement and in all floors for RCC column footing column plinth beam, beams, roof slabs, staircase steps, bed blocks, critical pier etc supported by casurina props props of 10cm to 13cm dia spaced at 75cm centre to centrecomplete complying with standard specifications

Plain Cement Concrete 1 : 3 :6 ( one part of cement, four parts of sand and eight parts of hard broken stone ) using 40 mm gauge hand broken hard broken granite stone jelly complying with standard specifications in foundations and basement.

Plastering with cement mortar 1:4 mix to 20 mm thick including cost and conveyance of all materials to site and all labour charges etc complete for 10 sqm

Filter

Drilling of borewells anywhere in tamilnadu including transportation from one place to another with in tamilnadu in alluvial soil sedimentary strata of clay and sand stone shale pebbles boulders etc. By first taking a pilot bore of 140mm/150mm dia and then enlarging to reaquired dia direct olr reverse rotary mud circulation method using rotary rigs, fuel, labour and drilling bentonite and water required for drilling at site including construction of mud pit.

Cost and supply of special Blue slotted PVC pipes for borewell

Cost and supply of PVC end cap

Earthwork excavation for foundation in all soils and sub soil to full depth as may be directed except in hard rock requiring blasting but inclusive of shoring strutting and requiring the sides of foundation

Supplying and filling in foundations and basement with filling sand in layers not more than 15cm. Thick well ramed, watered and compacted complete

Plain Cement Concrete 1 : 4 :8 ( one part of cement, four parts of sand and eight parts of hard broken stone ) using 40 mm gauge hand broken hard broken granite stone jelly complying with standard specifications in foundations and basement.

Plain Cement Concrete 1 : 3 :6 ( one part of cement, four parts of sand and eight parts of hard broken stone ) using 40 mm gauge hand broken hard broken granite stone jelly complying with standard specifications in foundations and basement.

Supplying and erecting centering for sides cetnerng for soffits of RCC slabs of plane surface of RCC Slabs of plane surface like lintels, beams, etc., below basement

Filling the Soak pit with 40mm metal as per specification

Filling the Soak pit with 20mm metal as per specification

Provision for Name board charges

GST Amount for providing Service to Government Contract Works for the above Construction Works. {GST Amount is the Total GST Amount for total overall quoted amount above this row in column "BB" for all works in this package}

R C RAVICHANDRAN