PROVISION OF COVERED BUS SHELTER AND CERTAIN B/R WORKS AT ICGS KARAIKAL UNDER GE (I) (CG) CHENNAI

Amount

Excavating in post holes (or similar holes) each n exc 0.5 cu. m, getting out, returning, filling in and ramming earth or broken rubble mixed with earth around, in layers not exceeding 25 cm,in soft/loose soil complete all as specified and as directed.

Plain Cement Concrete Type C2 1:3:6 using 40 mm graded stone aggregate in foundations, filling and mass concrete complete all as specified and as directed.

S & F MS steel work in tubular trusses and tubular posts including special shaped washers etc., complete using ERW or induction butt welded tubes conforming to I.S.I 1161-1998 Grade St-240 with one shop coat of zinc chromate primer paint complete all as specified and as directed.

S & F Rolled Mild Steel Plates (plain or Chequered) channels, square cut or notched, forming holes, without any attachment confirming to Fe-410-W(Gde- E-250) quality- B complete all as specified and as directed.

S&F Mild steel screw bolts(machine made) with hexagonal or square heads at one end andscrewed the other, orscrewed both ends, eachscrewed end to be fitted with washers and one hexagonal or square nut,but length of bolt exc 10cm and n exc 15cm long dia of shank 11to 15mm complete all as specified and as directed.

S & F pre-painted galvalume aluminium zinc coating GI based corrugated steel sheet 0.50mm thick of an colour having tensile strength of 550 Mpa as in roof covering/ cladding to wall, fixed with self tapping screws complete all as specified and as directed.

S & F Pre-painted galvalume aluminum zinc coating GI based Plain steel sheet 0.50mm thick of any colour having tensile strength of 550 Mpa as in roof covering/cladding to wall, fixed with self tapping screws complete all as specified and as directed.

S& F Hand rails, half round or other steel section or core for wooden hand-rail straight portion, drilled and countersunk for balusters running bars, for doors, balusters, nosing to steps including embeding in concrete and screwing etc. wind ties for roof including securing bolts complete all as specified and as directed.

M&L for preparing surfaces of steel and iron work of new surface of any description over 10 cm width or grith not otherwise described applying two coats of synthetic enamel paint all complete all as specified and as directed.

S&F posts and struts in fencing including cutting tops to shape as directed, in Angle drilling holes, notching for wire, etc.; flat iron fillets (for securing wire mesh etc.) including all necessary drilling, bolting or riveting, etc.,and similar work conforming to Fe-290 Gde E-165 complete all as specified and as directed.

M&L Mild steel in flat, round or squae bars, in available lenth Fe-410-W (Gde-E-250) quality A complete all as specified and as directed.

S&F mild steel screw bolt (machine made )with hexagonal ar square head at one end and screwed the other or screwed both end , each screwed end to be fitted with washers and one hexagonal or square ut length of bolt n.exc 5 cm long and dia 5 to 10mm complete all as specified and as directed.

Supply only PVC coated Chain link fencing with steel wire chain link fencing any size or type complete all as specified and as directed.

Fixing only PVC Coated chain link fencing including line wires any mesh size and type of standerds, rails, straining bolts, etc. including provission of binding wire complete all as specified and as directed.

M&L for Mild steel Round bars 10 mm dia., and over cut to length, for securing chain link fencing complete all as specified and as directed.

Excavating in trenches, n.exc 1.5 m wide and n.exc 1.5 m in depth, for foundation, etc or for shafts, wells, cesspits, manholes, pier holes, etc n.exc 10 sqm on plan and n.exc 1.5 m in depth and getting out in soft soil complete all as specified and as directed.

M&L for PCC (1:4:8) type D-2 (using 40mm graded stone aggregate) as in foundation filling and mass concrete complete all as specified and as directed.

M&L Brickwork with fly ash bricks, straight or curved on plan exc 6m mean radius, built in in cement mortar 1:6 complete all as specified and as directed.

Returning, filling in foundation/trenches including spreading, levelling, watering and well ramming in layers not exceeding 25cm thick in soft loose soil complete all as specified and as directed.

Removing excavated soils n. exc. 50m and depositing where directed at a level n. exc. 1.5m above the starting point complete all as specified and as directed.

M&L for 15mm thick rendering in CM (1:6) on fair surfaces of brick work or concrete surfaces to be finished even and smooth without using extra cement, complete all as specified and as directed.

Preparation of new plastered wall surfaces and applying Two or more coats of 100% Premium acrylic emulsion paint having VOC less than 50 gm/litre and UV resistance as per IS 15489:2004, Alkali & fungal resistance, dirt resistance exterior paint of required shad (Company Depot Tinted) with silicon additives @ 1.43 litre/ 10 sqm over and including priming coat of exterior primer applied @ 0.90 litre/ 10 sqm complete all as specified and as directed.

M&L for Sand filling under floors or in foundations including watering and consolidation complete all as specified and as directed.

Excavating over areas, n exc 1.5 m deep and getting out in soft soil/loose complete all as specified and as directed.

M&L for broken stone or boulders of Hardcore of guage n.exc 63 mm, depositted, spread and levelled in layers n.exc 15 cm thick, watered and rammed to a true surfaces complete all as specified and as directed.

M and L for 100 mm thick Cement concrete type B- 2, 1:2:4 (40mm graded aggregate as in sub base of flooring/ hard standing complete all as specified and as directed.

M&L 300 mm x 300 mm x 22-25 mm thick chequered cement concrete tile with rubber moulded, set, jointed and pointed in neat cement slurry with gray cement and pigment in floors incl, complete all as specified and as directed.

Providing and laying 80mm thick factory made chamfered edge cement concrete paver block of M-30 grade with approved colour, design & pattern as in footpath, parks, lawns, drive ways or light traffic parking etc., of required strength, thickness & size/ shape, made by table vibratory method using PU mould, laid in required colour & pattern over and including 50mm thick compacted bed of coarse sand, compacting and proper embedding/ laying of inter locking paver blocks into the sand bedding layer through vibratory compaction by using plate vibrator, filling the joints with fine sand and cutting of paver block as per required size and pattern, finishing and sweeping extra sand complete all as specified and as directed.

Plain Cement Concrete Type C1 1:3:6 (using 20 mm graded stone aggregate) cast in situ in lintels up to 1.5 M span, cills and other similar bands, plinth courses, parapets, copings, bed plates, water troughs and the like including weathering, slightly rounded or chamfered angles and throating as directed including use and waste of form work complete all as specified and as directed.

S & F Multiplay Junior with Single Tower,1 LLDPE Roof,1 LLDPE Double Slide,1 Staircase Steps,1 Entry Gate,Attached Double Swing & Loop Ring Climber etc including necessary fixing arrangements on ground with MS bolts and nuts and concrete foundations and manufactures instructions leveling ground all as shown on drawing and as specified and as directed.

S & F Animal Arch Swing with 60mm Pipes ,7ft Height, 10ft Width, Stainless Steel Chain & LLDPE Animal Seats etc including necessary fixing arrangements on ground with MS bolts and nuts and concrete foundations and manufactures instructions leveling ground all as shown on drawing and all as specified and as directed.

S & F Circle Swing Deluxe 75*75mm Pipe Frame ,6ft Height, 6ft Width, Circle Made Of 25mm Pipes With Aluminium Seats etc including necessary fixing arrangements on ground with MS bolts and nuts and concrete foundations and manufactures instructions leveling ground all as shown on drawing and all as specified and as directed.

S&F Double Seesaw Chair Seats 7ft Long Seesaw With Chair Seats With 6ft*2ft Stand 60mm,25mm Pipes etc including necessary fixing arrangements on ground with MS bolts and nuts and concrete foundations and manufactures instructions leveling ground all as shown on drawing and all as specified and as directed.

S&F Animal Merry Go Round, 60mm Center pipe with double bearings, 42mm support pipe 5ft Dia, 3ft Height 4 LLDPE Animal Seats etc including necessary fixing arrangements on ground with MS bolts and nuts and concrete foundations and manufactures instructions leveling ground all as shown on drawing and all as specified and as directed.

S&F Jungle Gym 42mm Side pipe 25mm Main pipes, 6ft Height, 5*5ft etc including necessary fixing arrangements on ground with MS bolts and nuts and concrete foundations and manufactures instructions leveling ground all as shown on drawing and all as specified and as directed.

S &F Monkey Bar 60mm main pipe with 42mm ladder pipes 8ft Height, 8ft Length etc including necessary fixing arrangements on ground with MS bolts and nuts and concrete foundations and manufactures instructions leveling ground all as shown on drawing and all as specified and as directed.

S & F Horse Spring Rideon including necessary fixing arrangements on ground with MS bolts and nuts and concrete foundations and manufactures instructions leveling ground all as shown on drawing and all as specified and as directed.

S&F Duck Spring Rideon including necessary fixing arrangements on ground with MS bolts and nuts and concrete foundations and manufactures instructions leveling ground all as shown on drawing and all as specified and as directed.

S&F Tiger Rideon including necessary fixing arrangements on ground with MS bolts and nuts and concrete foundations and manufactures instructions leveling ground all as shown on drawing and all as specified and as directed.

M&L point wiring complete with 1.5 Sqmm single core multi- stranded copper conductor PVC insulated and sheathed fire retardant cable 1100 volts grade, IS-694 (ISI marked) drawn through and including PVC conduit medium grade 20 mm dia including wooden gutties clamps etc fixed on walls/ceiling etc including shunk type pressed steel terminal boxes with 3.00 mm thick insulated laminated sheet/hylem top covers on walls/box including 1.5 Sqmm PVC insulated sheathed fire retardant cable 1100 volts grade with multi stranded copper conductors earth continuity conductor to common earth and connected to earth dolly for the following :-

(a) One light point/fan point/ exhaust fan point/bell point controlled by one, one way switch of 5/6 Amps complete all as specified and as directed.

(b) All as per item No. 4(b) but on the same board with other switches/socket.

S & F Switch piano, flush type, white / ivory finish, 5/6 amps, single pole, one way complete all as specified and as directed.

M&L switch socket combination, 2 in 1, 3 pin, 5 Amp flush type universal complete all as specified and as directed.

S&F ceiling rose, surface bakelite, AC, 220/240 volts, 3 terminals, complete all as specified and as directed.

Supply and fixing LED lights fitting 1x 20W, 220V, AC decorative box type with driver, holder including LED tube light connecting up with three core flexible copper conductor cable of suitable size from ceiling rose complete all as specified and as directed.

S&F MCB DB sheet metal enclosure for DB, SPN, 8 way having protection IP-43, with 200 amps rated bus bar, 240 volts, double door type, suitable for housing MCB's and isolators, complete all as specified and as directed.Make-Legrand Cat No. 607711 or equivalent of MDS/ABB/Scnieder

S&F MCB DB sheet metal enclosure for DB, SPN, 4 way having protection IP-43, with 200 amps rated bus bar, 240 volts, double door type, suitable for housing MCB's and isolators, complete all as specified and as directed.Make-Legrand Cat No. 607711 or equivalent of MDS/ABB/Scnieder

S&F MCB SPN, 240 volts, 30 to 60 amps, 10KA ‘B’ series complete all as specified and directed.

S&F MCB SP, 240 volts, 6 to 30 amp, 10 KA ‘B’ series complete all as specified and as directed.

S&F Sub main wiring with two single run of 6 Sqmm (Normal cross sectional area) of single core unsheathed PVC insulated cable, 1100 volts grade multi stranded copper conductor drawn through with & including concealed conduit of 25 mm dia or higher dia with and including necessary conduit accessories, surface type including 6 Sqmm stranded copper conductor PVC insulated cable as earth wire connected to common earth dolly, complete all as specified and as directed.

power links (BID ID -3500408)

Sri Lakshmi and Company (BID ID -3502742)

RK ENTERPRISES (BID ID -3495718)

kvs constructions (BID ID -3497611)

MONISH CONSTRUCTIONS (BID ID -3495786)

G.JANAKIRAMAN CO (BID ID -3501293)