MANUAL RESCUE AND OPERATION RESCUE AND COMPREHENSIVE MAINTENANCE OF OTIS AND ECE MAKE LIFTS AT DAD RESIDENTIAL COMPLEX POWAI AND NAVAL HOSPITAL POWAI UNDER GE (NW) BHANDUP

Amount

Manning & Operation of 06 Nos of lifts from 06:00 hrs to 22:00 hrs in two shifts operated by one operator in each block per shift on all days including holidays and during all type of weather/climatic conditions, providing rescue to the trapped person, maintaining the lift and connected equipments and accessories including lift room in clean and tidy condition during the operation period and also Manning & Operation of Lift in case of failure of commercial supply by running of DG Set installed within the vicinity meant for lift supply.Location : (Block No-I (A& B, 2 lifts) ,Block No II (C, 1 lift), Block No III (D&E, 02 lifts) and Block No IV (F,01 lift ) at DAD Staff Qtrs Powai comprising of Ground + 6 upper floors, (Total 06 lifts, out of which 05 Lifts 13 Passengers OTIS make & 01 lift 8 passenger ECE make), complete all specified and directed. Note: Quoted Rate shall be deemed to include to provide one alternative employee (reliever) to provide the services, so that the other employee can avail the facility of weekly leave etc.

Comprehencive maintenance (Routine , preventive , breakdown) (Daily, weekly, fortnightly, monthly, qtrly, half yearly, yearly maintenance) , and repairs including replacement of minor defective parts of 05 Nos of capacity 13 Passengers Lift and 01 Nos of capacity 08 Passengers Lift in DAD Qtrsl suitable to serve G+6 upper floors during all type of weather/climatic condition for the any make, maintaining the lift and connected equipments and all standard accessories, simplex collective automatic & manual dual controlled operation with/without attendant ,automatic center opening doors with VVVF door drive (electric motor driven mechanism), sliding stainless steel doors, Emergency rescue device (ERD) system, 3D infra red sensor in full height of door & built in announcing system with/Without hand set (03 Nos, one each in car, near Ground floor landing door and one with hand set in Machine room) all as specified and directed.etc in serviceable condition round the clock (on all days including holidays), also maintaining the necessary documents all as specified and directed. NOTE : Cost of all the maintenance,repairs and including replacement of components and parts that too for the specific lifts as indicated therein to keep the lifts in perfect serviceable condition shall be deemed to be included in the quoted rate of the contractor. The contractor shall be responsible for handing over the lifts in serviceable condition at the time of completion of works. The payment for replacement of parts/components expenditure upto Rs 1500/ is deemed to be included in the quoted rate.

Taking out existing unserviceable main hoist steel wire rope after disconnecting from counter weight pulley and car cabin and supply and fix new steel wire rope 13mm dia, ungalvanised, 8/19 construction, conforming to IS-14665 including making necessary connection with weight, pully and car cabin with clamps, nuts, bolts, washers etc, Make : Usha Martine or equivalent as approved by the GE, complete all as specified and directed.

Taking out unserviceable Governor steel wire rope after disconnection from car cabin and in lieu supplying and fixing new steel wire rope, 8mm dia, ungalvanised, 8/19 construction including making necessary proper connection with machine room and shaft pit with clamps, nuts, bolts, washers complete all as specified and directed. Make : USHA MARTIN or equivalent as approved by the GE.

Taking out old unservicable travelling cable from hoist way and supply and fixing new travelling cable PVC insulated, 12 core, flat type with stranded copper conductor, 1100 volts grade of size 0.75 sqmm, conforming to relavant IS with and including crimping with lugs of appropriate thimbles, suspended type, freely moveable with car cabin up & down between ground & upper floors including necessary proper connection etc with mid way junction and other connections required in circuit, complete all as specifed and directed Make : Finolex / Polycab/Incab.

Taking out old unservicable travelling cable from hoist way and supply and fixing new travelling cable PVC insulated, 4 core, flat type with stranded copper conductor, 1100 volts grade of size 0.75 sqmm, conforming to relavant IS with and including crimping with lugs of appropriate thimbles, suspended type, freely moveable with car cabin up & down between ground & upper floors including necessary proper connection etc with mid way junction and other connections required in circuit, complete all as specifed and directed Make : Finolex /Polycab/Incab.

Taking out unserviceable main traction pulley from gear box, supply & fixing new main traction pulley of CI of existing size, groove and dia suitable for 08/13 passengers capacity, ECE / OTIS Make lift, complete all as specified and directed, Location : DAD staff Qtrs.

Taking down existing unserviceable LOP assembley, supply and fix new landing operating panel (LOP) assembley with and including digital car position indicator, direction signal with 2mm thick stainless steel face plate of size and shape to match with existing, also reconnecting with control /electric system and testing etc suitable for ECE/OTIS make lifts, 08/13 passengers capacity, installed at DAD Qtrs, Powai (G+6 Floors), complete all as specified and directed.

Taking down existing unserviceable COP assembly, supply and fix new car operating panel (COP) assembly with and including illumnated push button for floor position, alarm, nonstop, door stop, door close, cabin fan, cabin light stop, attendant out key etc, direction indicator of 7 segment display with SPI card and 2mm thick stainless steel face plate duly controlled and electric connection etc suitable for 13 passenger Otis make lift installed DAD Qtrs at Powai complete all as specified and directed . Make : Formator or equivalent make as approved by GE.

Taking out existing old defective sensor and in lieu providing new sensor with INFRA RED safety edge with power unit on car door to safeguard passenger entering and leaving the lift suitable for 08/13 passenger ECE/OTIS make lifts installed at DAD Staff Qtrs, Powai (G+6 Floors) complete all as specified and directed, Make : Weco or equivalent make as approved by GE.

Dismantling of electric traction motor of capacity 15 HP(for power supply), also including dismantling from pully and taking to workshop with necessary transportation and opening the complete motor and rewinding with super enameled copper wire as per the existing gauge with necessary insulation, sticks and varnishing, including replacement of 02 Nos shaft bearings and motor terminals plate complete including painting, taking back the rewinded motor to site and reinstalling in the original location for 08/13 passenger ECE / OTIS make lifts installed at DAD Staff Qtrs, Powai (G + 6 Floors), complete all as specified and directed.

Material and Labour for complete removal of the existing paint from steel surface of lift car & landing doors including preparation of surfaces using oil putty and applying two coats of synthetic enamel paint by spray application of approved shade over one coat of red oxide primer, complete all as specified and directed, Location : DAD Staff Qtrs, Powai.

Taking out existing unserviceable cabin fan and in lieu providing new cabin fan, non-oscilating type, axial flow, single speed, 300mm sweep, 240 volt, with grill, (Make : EMCO/VBM/CINI), complete all as specified and directed.

Dismantling & taking out unserviceable car door, header and door drive unit from car cabin and supplying & fixing new car door comprise with stainless steel panel of 18 SWG with hair line finish flush type of power operated auto telescopic opening by Horizontal sliding complete with header, hanger door drive unit with full beam infra red sensor upto full length of car door aluminum sill VVVF connection etc

Taking down existing unserviceable ARD with 6 Nos 12 Volts, 18 AH batteries from machine room and S&F new Automatic Rescue Device (ARD) including relays, PCB cards/dioders card and 6 Nos maintenance free sealed batteries of 12 volt, 18 AH (Make Exide/Amron) etc suitable for 08/13 passenger OTIS make lift installed at DAD Staff Qtrs (G+6 Floors), Powai, complete all as specified and directed, Make of ARD : Unique Enterprises or equivalent make as approved by GE.

Dismantling existing unserviceable VVVF drive and supply, fix, test and commission variable voltage variable frequency (VVVF) drive with multiple micro program chip based link each other in network, thermal over load protection etc of make Yashkawa -Japan, suitable for Otis/ECE make lift all as specified and directed by the Engineer-in-Charge.

Taking out existing light fittings and in lieu S and F new LED light fittings, 12/16 watt complete with and including LED fitting with all accessories, fixtures of make CROMPTON GREVE/ BAJAJ/PHILIPS all as specified and directed by the Engineer-in-Charge.

Supply and fix in repairs rechargeable, maintenance free lead acid batteries of 12 Volts, 18 AH for ARD system all as specified and directed by the Engineer-in-Charge.

Supply and fix in repairs ARD Mospek /power supply card for ARD system all as specified and directed by the Engineer-in-Charge.

Manning & Operation of 01 Nos of lifts of capacity 13 Passanger from 06:00 hrs to 14:00 hrs in one shifts operated by one operator per shift on all days including holidays and during all type of weather/climatic conditions, providing rescue to the trapped person, maintaining the lift and connected equipments and accessories including lift room in clean and tidy condition during the operation period and also Manning & Operation of Lift in case of failure of commercial supply by running of DG Set installed within the vicinity meant for lift supply Location Naval Hospital Powai. Note: Quoted Rate shall be deemed to include to provide one alternative employee (reliever) to provide the services, so that the other employee can avail the facility of weekly leave etc.

Comprehencive maintenance (Routine , preventive , breakdown) (Daily, weekly, fortnightly, monthly, qtrly, half yearly, yearly maintenance) , and repairs including replacement of minor defective parts of 01 (Two) Nos of capacity 13 Passengers Lift in Naval Hospital suitable to serve G+01 upper floors during all type of weather/climatic condition for the any make, maintaining the lift and connected equipments and all standard accessories, simplex collective automatic & manual dual controlled operation with/without attendant ,automatic center opening doors with VVVF door drive (electric motor driven mechanism), sliding stainless steel doors, Emergency rescue device (ERD) system, 3D infra red sensor in full height of door & built in announcing system with/Without hand set (03 Nos, one each in car, near Ground floor landing door and one with hand set in Machine room) all as specified and directed.etc in serviceable condition round the clock (on all days including holidays), also maintaining the necessary documents all as specified and directed. NOTE : Cost of all the maintenance,repairs and including replacement of components and parts that too for the specific lifts as indicated therein to keep the lifts in perfect serviceable condition shall be deemed to be included in the quoted rate of the contractor. The contractor shall be responsible for handing over the lifts in serviceable condition at the time of completion of works. The payment for replacement of parts/components expenditure upto Rs 1500/ is deemed to be included in the quoted rate.

Shree Elevator Engineering Co.

Monarch Enterprises

Escon Elevators Pvt Ltd

Veer High Tech Solution