Construction of protection wall and new outer Two-Lane Ring road in Thillaiamman Odai, Chidambaram Taluk Cuddalore District.

Amount

Earth Work Excavation for foundation in all soils and sub soils and to full depth as may be directed by the Departmental Officers except hard rock requiring blasting including shoring, strutting and baling out water wherever necessary and refilling the sides of foundation with excavated soil in layers not exceeding 15 cm thick, well rammed and consolidated and depositing including all initial leads and initial lifts, etc., complete complying with standard specifications and as directed by the departmental officers. (Open excavation)

Supplying and spreading sand gravel mix ratio of 1:1 in layers not exceeding 10 cm thick below the retaining wall as required at site of work including watering and consolidation using power roller, etc, complete complying with standard specifications and as directed by the departmental officers

Supplying and spreading of gravel including stacking the same for premeasurements and watering consolidation by power roller, ramming etc., complete complying with standard specifications and as directed by the departmental officers

Providing and placing in position of plain cement concrete M 10 grade using M. Sand graded hard blue granite broken stone jelly of 40 mm size mixing with mixer machine including the cost of bailing/pumping wherever necessary laying the concrete in layers of not exceeding 15 cm thick, compacting, consolidation finishing, watering, curing etc. complete complying with standard specifications and as directed by the departmental officers.

Supplying and laying of ready mix for M 25 grade of concrete having charaterstic strength not less than specified in the IS 456 - 2000 using Ordinary portland cement with minimum cement content of 300 Kg / cum confirming to IS 8112. Coarse aggregates having a specific gravity of 2.60 using 20 mm down graded hard blue granite broken stone jelly and fine aggregate without flyash as per IS 383 - 1970 ( 2007 ) with suitable water cement ratio not less than 0.45 and not exceeding 0.50 of water quality confirming to IS 456 - 2000 including use of plasticizer of approved make & dosage of required grade at all locations and levels with specified high workability as per IS 1199 - 1959 ( 2004 ). The initial & final setting time confirming IS 12269 - 1987 ( 2004 ) with maximum temperature of concrete at the time of placing should not exceed 32 0 C. The admixtures affecting the quality and strength of the concrete should not be used and should confirm IS 9103 - 1979 [ usual admixture - Air entraining & water reducing ]. ges as per IS 456 - 2000, 4031 - ( Part 3 & 6 ) / 1988 ( 2005 ) & ( Part 2 ) / 1999 ( 2004 ) and 516 / 1959 ( 2004 ), 4926 - 1976 ( 1990 ), mix design details to be got approved before commencement of the work adopting pour card system and other OK cards. Excluding the cost of form works, centering and shuttering placed in position etc, complete complying with standard specifications and as directed by the departmental officers. (RCC work)

Supplying and erecting centering for vertical plain / RCC concrete walls of supply channel, retaining wall etc for following height height with necessary supports, all cross bracing with mild steel size of 90 cm x 60 cm and gauge BG 10 stiffened with welded mild steel sheet angles of size 25 mm x 25 mm x 3 mm for bearing laid silver Oak / Country wood joist of size 7.50 cm x 5.0 cm spaced @ about 90 cm C / C and supported by Casurina props of 10 cm to 13 cm spaced @ 75 cm C / C, etc., complete complying with standard specifications and as directed by the departmental officers

Upto 0.90 M Height

Upto 2.70/3.00 M Height

3.00 to 4.00 M Height

4.00 to 5.00 M Height

Supplying and fixing of PVC pipe 110 mm dia (4Kg/cm2) for weep holes provide in the wing walls of either side etc.,complete as directed by the departmental officer.

Supplying and fixing 300mm wide PVC EXPANSION JOINT in the 20mm expansion gap provided in between decks over piers and in between deck and dirt wall over abutment as shown in the drawing including cost and conveyance of expansion joints including shalimar pad and joint sealant etc., complete

Supplying, fabricating and placing in position of Mild Steel or Ribbed Tor Steel for all RCC works as per design & drawing given including cost of steel, binding wire and labour charges for cutting, bending, laying in position and tying with binding wire, etc. complete complying with standard specifications and as directed by the departmental officers

De-watering of using diesel pump set having capacity 7.50HP including cost of hire charges, diesel, labour etc complete complying with standard specifications and as directed by the departmental oficers

Sand and Silt Under Water (SS20B) Earth work excavating and depositing on bank with initial lead of 10 m & initial lift of 2m in Slush and silt under water upto 0.75m depth requiring the aid of basket and vessels (SS20B) including conveyaning the excavated earth to the low lying area with lead of 5Km including levelling as directed by the feld engineers etc., complete complying with standard specification and as directed by the departmental officers

Earthwork in all Soils except Hard Rock requiring blasting and conveying for formation of bund with a lead of 10 KM deploying earth moving machineries and tipper including benching formation of bunds breaking clods sectioning with extra watering and consolidation by power roller and including hire charge etc., complete complying with standard specification and as directed by the departmental officers. (10 KMMR).

GST 18% IN FIGURES

M/s. Giant Construction Company