GENERAL MIPTA Annual Maintanance 2024 25 of Manjanakulam L I Station Mechanical amp Civil works under M I Section Adoor General Civil Work

Amount

1 APPENDIX- A- MECHANICAL

OD20646/2024-2025:Charges for lower the pump,motor and all related accessories stored in the upper floor safely with the help of chain block, wire sling coir rope ,etc.complete as per the direction of departmental officers at site

OD20544/2024-2025:Overhauling existing 40hp motor, separate the starter and motor, remove the dust, cleaning with petrol, varnishing the winding with best quality varnish, heating, greasing the bearing, assembling and refitting the same and conducting test run etc complete as per directions of departmental officers at site.

OD1872/2024-2025:Re erection of of pump and motor , fixing to bed and alignment setting of motor and pump erection of pipe line suction and delivery etc complete

OD1857/2024-2025:Charges for supplying good quality leather flap including all cost and conveyance

OD1858/2024-2025:Charges for supplying oil seal for 40 hp motor.

OD1860/2024-2025:Supplying good quality pump oil including all cost and conveyance

OD1861/2024-2025:Supplying good quality transformer oil including all cost and conveyance etc complete

OD1863/2024-2025:Supplying good quality red primer

OD1864/2024-2025:Supplying iron nut and bolt (specified dia)

OD1865/2024-2025:Supplying Cotton waste

OD1866/2024-2025:Supplying bearing grease good quality

OD1867/2024-2025:Supplying 2" good quality brush

OD18582/2024-2025:Supplying and fixing Suction Strainer of SS 304 mesh (1/2) and SS 304 connecting plate of thickness 5 mm used to remove debris and waste .

OD20545/2024-2025:Supplying and fixing 100 Amp 3 phase main switch

OD20543/2024-2025:Charges for lifting the pump,motor and all related accessories stored in the upper floor safely with the help of chain block, wire sling coir rope ,etc.complete as per the direction of departmental officers at site

1 APPENDIX- B- CIVIL WORK

2.6.1:Earth work in excavation by mechanical means (Hydraulic excavator)/manual means over areas (exceeding 30 cm in depth, 1.5 m in width as well as 10 sqm on plan) including disposal of excavated earth, lead up to 50 m and lift up to 1.5 m, disposed earth to be levelled and neatly dressed.All kinds of soil

50.6.2.2:Solid masonry using pre cast solid blocks (factory made) of size 30x20x15cm or nearest available size confirming to IS 2185 part I of 1979 for super structure up to floor two level with thickness 15cm in : CM 1:6 ( 1 cement : 6 coarse sand) etc complete

13.7.2:12 mm cement plaster finished with a floating coat of neat cement of mix:1:4 ( 1 cement : 4 fine sand)

14.54.1:Painting with synthetic enamel paint of approved brand and manufacture of required colour to an give even shade:One or more coats on old work

OD18564/2024-2025:Net for window 1.00x1.50 cm size

OD18565/2024-2025:Thermoplastic poly propylene back chair with arm for indoor use

OD18566/2024-2025:Checkered rubber floor mat of size 120x60 cm ,10 -20mm thick for sefety purpose of the worker

OD18567/2024-2025:Electrical insulated rubber gloves as per OSHA(29 CFR 1910.137(C))2(VIII)and reference table 1-5

50.9.3.1:Providing and fixing paneled or paneled and glazed shutters for doors, windows and clerestory windows, 30 mm thick shutters including ISI marked M.S. pressed butt hinges bright finished of required size with necessary screws, excluding paneling which will be paid for separately, all complete as per direction 0f Engineer in- charge. using Anjili/ Jack wood

15.7.1:Demolishing brick work manually / by mechanical means including stacking of serviceable material and disposal of unserviceable material within 50 metres lead as per direction of Engineer-in-Charge.In mud mortar

9.1.1:Providing wood work in frames of doors, windows, clerestory windows and other frames, wrought framed and fixed in position with hold fast lugs or with dash fasteners of required dia & length (hold fast lugs or dash fastener shall be paid for separately).Second class teak wood

13.50.1:Applying priming coat:With ready mixed pink or Grey primer of approved brand and manufacture on wood work (hard and soft wood)

13.56.1:Painting (two or more coats) on rain water, soil, waste and vent pipes and fittings with synthetic enamel paint of approved brand and manufacture and required colour over a priming coat of approved steel primer on new work.100 mm diameter pipes

50.9.15.4:Providing and fixing iron hooks and eyes: 150 mm

22.6:Providing and laying water proofing treatment on roofs of slabs by applying cement slurry mixed with water proofing cement compound consisting of applying : a) after surface preparation, first layer of slurry of cement @ 0.488 kg/ sqm mixed with water proofing cement compound @ 0.253 kg/ sqm. laying second layer of fibre glass cloth when the first layer is still green. Overlaps of joints of fibre cloth should not be less than 10 cm. c) third layer of 1.5 mm thickness consisting of slurry of cement @ 1.289 kg/ sqm mixed with water proofing cement compound @ 0.670 kg/sqm and coarse sand @ 1.289 kg/sqm. This will be allowed to air cure for 4 hours followed by water curing for 48 hours. The entire treatment will be taken upto 30 cm on parapet wall and tucked into groove in parapet all around. d) fourth and final layer of brick tilling with cement mortar (which will be paid for separately. For the purpose of measurement the entire treated surface will be measured)

OD18591/2024-2025:Fire extinguishers class c type co2 -2 kg

SUMA T P

MURALEEDHARAN M R

Bidder Name

MURALEEDHARAN M R

RONAK S

SUMA T P