Renovation to Compound Light AT Govt. Vehicle Pool At Sector-30, Gandhinagar.

Name of Work Renovation to Compound Light AT Govt. Vehicle Pool At Sector-30, Gandhinagar.

Fund Head : 2059 PW M & R SR

Sr. No. Item No. Particulars. Qty. Rate Amount

Signature of Contractor Deputy executive Engineer

C.P Electrical R & B Sub Dn

Name Of Work :- Renovation to Compound Light AT Govt. Vehicle Pool At Sector-30, Gandhinagar.

Item Estimated Rate in Rs.

Item Description Unit Amount in Rs.

No. Quantity in Figure In Word

Replacing old and u/s by Supplying and erecting Flexible

PVC insulated multi strand multi core 1.1 kv grade ISI Rupees Forty

1 100 mtrs marked copper wires of following size to be erected as 46.46 Six And Paise mtr

directed. Forty Six Only

(e) 1.50 Sq.mm 3 core round PVC sheathed

Replacing old and u/s by providing and erecting Mains

with ISI marked, 1.5KV grade electrolyte multi stranded,

annealed copper conductor with heat resistant PVC

insulated conforms to IS 694, IEC - 227 erected in existing

2 pipe of following size (Specifically for control panel,

relays, power switchgears, motor starters & control wiring)

with required size of copper lugs, nuts and bolts if

(e) One wire 6.00 sq. Mm Rupees Fifty

15 mtrs 56.56 Six And Paise mtr

Replacing old and u/s by Supplying and erecting LED

street light / Flood light fittings with High power White

LEDs wattage of 3 Watt and above assembled on single

MCPCB, efficiency more than 130 lm/w and corrosion free

High pressure die cast aluminum housing with smooth

finish powder coated and heat sink extruded aluminium

with diffuser and Polycarbonate optics/ lenses, with Rupees Three

toughened glass with company mark/name engraved or

embossed 160 to 270 V,Power Factor more than 0.95, Thousand

THD < 10 %, CCT 3000 K to 5700K,Uniformity ratio Three Hundred

3 20 nos 3345.12 Each

>0.45, Luminaire efficacy> 100 lumens/watt . LED driver Forty Five And

efficiency > 85 %.( fittings required LM-79 & LM-80

certificates)(NOTE: Below description have shown ranges

of Wattage capacity of LED fittings.The Engineer incharge Only

may select any wattage capacity between the ranges

shown.) (A) Street Light (IP-65), Surge protection -4KV

integral and ,Light must have 440VAC line supply with

over-voltage protection. (i) above 36 to 48 watts Cat-lll

Supplying and erecting LED street light / Flood light fittings

with High power White LEDs wattage of 3 Watt and above

assembled on single MCPCB, efficiency more than

lm/w and corrosion free High pressure die cast aluminum

housing with smooth finish powder coated and heat sink

extruded aluminium with diffuser and Polycarbonate

optics/ lenses, with toughened glass with company Rupees Six

mark/name engraved or embossed 160 to 270 V,Power

Factor more than 0.95, THD < 10 %, CCT 3000 K to Thousand

5700K,Uniformity ratio >0.45, Luminaire efficacy> 100 Eighty Eight

4 4 nos 6088.28 Each

lumens/watt . LED driver efficiency > 85 %.( fittings And Paise

required LM-79 & LM-80 certificates)(NOTE: Below

description have shown ranges of Wattage capacity of

LED fittings.The Engineer incharge may select any Only

wattage capacity between the ranges shown.) (B) Flood

Light (IP-65), Surge protection -4KV integral and ,Light

must have 440VAC line supply with over-voltage

protection. (iii) Above 60 to 90 watts Cat-lll

Replacing old and u/s by Providing and erecting Approved

make Four pole moulded case circuit breaker having

breaking capacity ICU of 25 KA. at 415 V,having normal Rupees Six

current rating up to 25 A to 100A. with Fixed thermal &

magnetic release suitable to work on A.C. supply 50 c/s.

with all internal connections, spreader tinned copper & Seven Hundred

5 1 nos 6790.43 Each

complete erected in existing 16 G.M.S. housing. Ninety And

ICS=100% of ICU only Cat III Note:-1 Add Rs.

10% extra for housing/Encloser of MCCB for Item No 3-4-

1 to 3-4-12 (The Enclosures should be used of same Three Only

company of MCCBs to be used)

Providing and erecting Approved make Earth fault Relay

suitable to mount with inter connection suitable to

following size of moulded case circuit breaker having CT Thousand Six

ratio & MCCB rating as following along with shunt trip Hundred Eighty

6 1 nos 220V AC. with all internal connections & complete erected 4687.41 Each

in existing M.S.housing.. (1) 15 A -100 A , CT Ratio 1/100

Supplying and erecting triple pole & neutral 440V / 500V

panel mounting Copper Busbars with four equal Nos. of

electrolyte bus having current density not more than 1.6 Rupees One

Amp. / sq.mm (Rated current / cross section area) duly Thousand Nine

wrapped with colour insulating tape for phase sequence of

7 0.4 Rn. Mtr. 1961.42 Hundred Sixty Rn. Mtr.

following current carrying capacity, erected with necessary

bus bar supports /insulators, main cable socket to each One And Paise

bar, erected in existing cubical panel with necessary Forty Two Only

connections. (A) Suitable for 100 Amp. Capacity

Replacing old and u/s by providing and erecting Miniature Rupees One

circuit breaker single pole 6A to 25A suitable to operate Hundred

on 240 V A.C. system and having breaking capacity

8 37 nos 112.11 Twelve And Each

KA to be erected in existing box. confirming to IS

8828/1996 with ISI Mark Cat.III Paise Eleven

Providing and erecting Approved make RCCBs Rupees Two

conforming to IS: 12640 and having sensitivity of 30 mA

and Short Circuit withstand capacity of 10 KA and suitable

for operation on 3 phase and neutral 415V,50Hz. having Hundred Thirty

9 3 nos 2637.11 Each

characteristic of quick action & tripping with all advance Seven And

feature & do not incorporate any electronic component for

following Max. rating erected as directed. (ii) 40Amps.

FP Cat.III Only

Providing and erecting Pipe type earthing having

cms.long and 2.5 cms. dia. galvanised iron pipe with

coupling and buch buried in specially prepared earth pit Hundred Sixty

10 15 nos complete with necessary 8 SWG earth wire. 368.65 Eight And Each

For using salt and charcoal / coke as required for pipe Rupees One

type earthing. Hundred

11 15 nos 171.70 Seventy One Each

Providing and erecting HOT deep Galvanised iron strip

wire 8 to 16 SWG.

12 2 kg 77.77 And Paise kg

Supplying & erecting earth pit of minimum bore

dia.150mm size approved make Earthing Electrode

consisting Pipe-in-Pipe Technology as per IS 3043-1987

made of corrosion free hot dipped G.I.Pipes having Outer

pipe dia of 50mm having 80-200 Micron galvanising,

Inner pipe dia of 25 mm having 200-250 Micron

galvanising, connection terminal dia of 12mm with

constant ohmic value surrounded by highly conductive

compound with high charge dissipation suitable for

following type of applications with chamber and heavy

duty cover. (A)(approved make OEM has to submit test

certificate including value of earth resistance of installation Thousand Five

13 1 nos duly stamped and signed by agency and officer Incharge 4591.46 Hundred Ninety Each

has to ensure the value of earthing resistane mentioned in One And Paise

test Certificate) & having back filling compound of (B)

Inner chemical (CCM Compound)- Resistivity:- 0.2 ohm / Forty Six Only

meter testing as per IEC 62561-2017, Voltage drop:- <

volt at no load & dry form, Sulphar content:- <2%(C) Back

fill Compound :- Earthing compound should be capable to

retain moisture for long time Necessary test report must

be submitted by Agency. (a) For Electrical Installation up

to 440V in normal soil

Length of pipe - 1 Mtr

Back filling compound - 1 Nos Bag of 15 Kg.

Replacing old and u/s by Providing and erecting

XLPE(IS:7098)(I)-88 ISI armoured cable multistrand

Aluminium conductor for 1.1 KV. to be laid on wall with Hundred

14 70 mtrs necessary clamps or in existing trench / pipe of following 220.18 Twenty And mtr

size of cables (B) 3 1/2 core 35 Sq. mm ( 16 Sq. mm 1/2 Paise Eighteen

core) ( 35 Sq. mm 1/2 core) Old-5 New-65

Replacing old and u/s by Providing and erecting XLPE Rupees One

(IS:7098)(I)-88 ISI armoured cable multistrand / Solid Hundred Forty

Aluminium conductor for 1.1 KV. to be laid on wall with

15 700 mtrs 140.39 And Paise mtr

necessary clamps or in existing trench / pipe of following

size of cables (C) 4 core 10 Sq. mm Old-65 New-635 Thirty Nine

Providing and erecting XLPE(IS:7098)(I)-88 ISI armoured

cable multistrand / Solid Copper conductor for 1.1 KV. to

be laid on wall with necessary clamps or in existing Hundred

16 10 mtrs trench / pipe at road crossing or floor of following size of 271.69 Seventy One mtr

cables.(A) 4 core 2.5 Sq. mm

And Paise Sixty

Making trench in soft soil of suitable width of 90 cm deep

for laying cable or locating the fault all over the run and Rupees Fifty

17 600 mtrs back filling the same and making the surface as normal 55.55 Five And Paise mtr

ground. Fifty Five Only

Making trench in Hard Murrum / Tar Road of suitable

width of 90 cm or required depth for laying any size of

cable or locating the fault all over the run and back filling Hundred Thirty

18 70 mtrs the same and making the surface as normal ground. 432.28 Two And Paise mtr

Drilling the road without breaking the road surface

(Asphalt) for laying of cable for feeding power supply by

making up to following size of holes at both ends Hundred Ninety

19 25 mtrs complete. (A) Up to 100 mm bore dia 492.88 Two And Paise mtr

Providing & laying approved make Double walled

corrugated pipes (DWC) of polyethylene(conforming to IS Rupees Sixty

14930 II )with necessary connecting accessories of same

20 695 mtrs 62.62 Two And Paise mtr

material at required depth in existing trench for laying of

cable. below ground / road surface for enclosing cable Sixty Two Only

(A)50 mm outer dia

Replacing old and u/s by Providing and, fixing heavy duty Rupees Thirty

flange type brass cable gland with rubber ring for PVC Eight And

21 33 nos insulated armoured cable complete with out going tails, 38.38 Each

insulating tape etc for following size of cables. (C) 2 to 4 Paise Thirty

core 10 Sq. Mm Eight Only

Replacing old and u/s by Providing and, fixing heavy duty Rupees

flange type brass double compression type cable gland Seventy Five

with rubber ring for PVC insulated armoured cable

22 2 nos 75.75 And Paise Each

complete with out going tails, insulating tape etc for

following size of cables. (B) 3 & 1/2 core 35/50 Sq. mm Seventy Five

Replacing old and u/s by Solder less crimping type

Aluminium lugs conforming to IS suitable for cable of

following size evenly crimped with high pressure tool & Thirteen And

23 132 nos 13.13 Each

connected to switchgear terminals with brass/cadmium Paise Thirteen

plated nut bolts in an approved manner. (B) 10 Sq.mm

2 nos 15.15 And Paise Each

6 nos 20.20 And Paise Each

Replacing Old u/s by new Supplying & erecting Rupees Four

Galvanized M.S pipe post “B” class 88.9 mm O.D 6 mtr. Thousand Four

Long duly painted with two coats of aluminium paint

24 7 nos complete with metallic base- plate of 300 mm x 300 mm x 4440.97 Each

4mm thick for using as a compound light pole with And Paise

approx. weight 47 Kg. Ninety Seven

Providing 1:2:4 cement concrete foundation & 70 % PCC

from bottom including excavation for the pole of size 45 x Rupees Eight

45 x 100 cm. Deep in below ground level with plinth of 45 Hundred Nine

25 7 nos cm x 45 cm (or 45 cm dia x 45 cm) high upper ground 809.01 Each

level with necessary curing and finishing in approved And Paise One

( for 4 & 6 mtr pole)

Replacing Old u/s by new Supplying & erecting approved

make SMC press moulded composite FRP. loop-in, loop-

out approx. 2mm thick box complete with Bakelite Rupees Eight

connector strip 5way(3P+N+E),DIN rail for mounting mob Hundred Ninety

& hinged doors as per requirement having locking

26 17 nos 898.90 Eight And Each

arrangements with mounting clamp with nuts, bolts &

washers suitable for erection on pole with cable clamps& Paise Ninety

earth bolt of following size of box. Only

(A) 300mm x 200mm x 100mm [deep]

Replacing Old u/s by Providing and erecting street light

pole bracket comprising main B Class GI pipe of

cm/require outside dia. complete with suitable B Class G.I

sleeve tubing of approx. 45cms.length and suitable for Rupees Six

76.5 mm / 80mm. / require size pole top having sufficient Hundred

fasteners for fixing the brackets and having spread of

27 15 nos 614.08 Fourteen And Each

mtr. length with suitable rise as per site condition &

suitable welded stiffener reducer and nipple with check nut Paise Eight

complete painted with one coat of Red oxide / PU base Only

primer and two coats of Aluminium / PU paint. paint with

following nos of arms. [A] Single Arm bracket 1 Mtr

Replacing Old u/s by new Supplying & erecting IP

grade following size section pillar fabricated from joint less

M.S. Sheet with angle iron legs made from jointless M.S.

Angle with cable clamps to be buried in ground to have

appropriate erection to work uniform until erected with

cement concrete foundation and 45 cm high bricks work

finishing with plaster etc. hinged double door internally

supported on both side,

with internal and outside looking arrangement with look Thousand Five

28 1 nos and keys in duplicate 35 x 35 x 5 mm M.S. Angle of Two 3595.60 Hundred Ninety Each

Nos. one is welded and other with nut and bolt for erecting Five And Paise

Bakelite sheet. Painting the Section Pillar inside and out

side with three tank powder coated paint. section pillar Sixty Only

roof should be without joint with water leakage proof &

tested as per IP 55 test & followed by IS 2147 of 1962 (B)

75 X 60 X 45 cm section pillar fabricated from 16 Gauge

MS Sheet with angle iron legs 45 cm long made from 35 X

35 X 5 mm thick MS angle.

Supplying and erecting HYLAM sheet on existing angle

iron frame.for following thickness (E) 10mm

29 0.5 Sq. Mtr. 1927.08 Sq. Mtr.

Replacing Old u/s by new Supplying & erecting approved

make Digital time switch having lithium cell 6 years

operative and operate battery backup 1 channel day clock Rupees Three

with 14 memory programme, suitable to operate on 240V Thousand One

+ 5%, 16A with, floating contacts Minimum switching

30 1 nos setup time 1 minimum & LCD display. Also comprised 3168.37 Each

permanent ON/OFF switching. Programming switches & Eight And

housed in fire proof thermoplastic enclosure & transparent Paise Thirty

cover erected as required with necessary connection Seven Only

erected as directed.

Replacing Old u/s by new Supplying & erecting power

contactor ,AC3 duty for time switch complete erected as

per direction Cat III (D) 4 pole 440V 40 Amp. Thousand

31 1 nos 2782.55 Each

Paise Fifty Five

RUPEES IN WORDS Rupees Four Lakh(s) Forty Four Thousand Eight Hundred Fourteen And Paise Ten Only

I/We am/are willing to carry out the work at(No above rates allowed) ____________% below ___________________________________

__________________percent (Should be written in figures and words) below the tendered rates mentioned above.

Amount of my/our tender works out as under :

Estimated amount put to tender Estimated amount put to tender

Deduct……………………….. % Below Deduct……………………….. % Above

In words In words

1 I/We hereby declare that I/We have visited the site, fully exquisite myself/ourselves with the local situation regarding materials and

2 I/we hereby declare that I/We carefully studied the conditions of specifications and other tender documents of this work and agree to

3 A tender with any overwriting in percentage (should both in word and figures) rejected out right.

4 Insertions and/or corrections in the percentage quoted ( both in word and figures) resulting into increase in the value of the work

5 Dismentaling the existing material taken by contractor as mention rates.

Signature of Contractor Deputy executive Engineer

C.P Electrical R & B Sub Dn

Less for the D.M

Renovation to Compound Light AT Govt. Vehicle Pool At Sector-30, Gandhinagar.

Sr.no Item Qty. Per DM rate Total

1 Cost Of Old & u/s 3X1.5 Round Wire 100 Mtr. 3.96

2 Cost Of Old & u/s 6.00 Sq.mm Wire 15 Mtr. 4.77

3 Cost Of Old & u/s 36W St.light Fitting 20 Nos. 127.36

4 Cost Of Old & u/s 60W Floodlight Fitting 4 Nos. 234.32

5 Cost Of Old & u/s 63A MCCB 1 Nos. 299.20

6 Cost Of Old & u/s MCB SP 37 Nos. 4.90

7 Cost Of Old & u/s 3.5Cx35 Sq.mm Al. Cable 5 Mtr. 12.87

8 Cost Of Old & u/s 4x10 Sq.mm Al. Cable 65 Mtr. 8.13

9 Cost Of Old & u/s Gland & Lugs 1 Lot. 100.00

10 Cost Of Old & u/s 6 Mtr. G.I. Pole 7 Nos. 275.21

11 Cost Of Old & u/s Bracket 15 Nos. 36.73

12 Cost Of Old & u/s SMC Box 17 Nos. 54.54

13 Cost Of Old & u/s Section Pillar 1 Nos. 220.35

14 Cost Of Old & u/s Timer 1 Nos. 123.76

15 Cost Of Old & u/s Contactor 1 Nos. 109.16

Dy.Executive Engineer Exe.Engineer

Sign of Contractor Cap.Proj. Elect.sub.Div-21 C.P.Electrical Division

Gandhinagar Gandhinagar