GENERAL MIPTA Annual Maintanance 202 425 of Thumpamon LI Station Mechanical Civil Works under MI Section Adoor General Civil Work

Amount

APPENDIX-A -MECHANICAL WORK

OD20514/2024-2025:Overhauling existing 25 hp motor, separate the starter and motor, remove the dust, cleaning with petrol, varnishing the winding with best quality varnish, heating, greasing the bearing, assembling and refitting the same and conducting test run etc complete as per directions of departmental officers at site.

OD16521/2024-2025:Charges for lifting the pump,motor and all related accessories stored in the upper floor safely with the help of chain block, wire sling coir rope ,etc.complete as per the direction of departmental officers at site

OD1103/2024-2025:Re erection of of pump and motor , fixing to bed and alignment setting of motor and pump erection of pipe line suction and delivery etc complete

OD1106/2024-2025:Supplying iron nut and bolt (specified dia)

OD1107/2024-2025:Supplying bearing grease good quality

OD1109/2024-2025:Supplying rubber bush

OD1457/2024-2025:Supplying good quality pump oil including all cost and conveyance

OD1458/2024-2025:Supplying good quality transformer oil including all cost and conveyance etc complete

OD1459/2024-2025:Supplying good quality red primer

OD1460/2024-2025:Supplying Cotton waste

OD16804/2024-2025:Charges for supplying 20 mm graphite Gland packing rope & 20 mm color etc complete

OD16886/2024-2025:Supplying and fixing Fuse unit 100 Amps (3 set)

OD16889/2024-2025:Charges for supplying star space bush of coupling etc complete

12.50:Providing and fixing precoated galvanised iron profile sheets (size, shape and pitch of corrugation as approved by Engineer-in-charge) 0.50 mm (+0.05%), total coated thickness with zinc coating 120 grams per sqm as per IS: 277, in 240 mpa steel grade, 5-7 microns epoxy primer on both side of the sheet and polyester top coat 15-18 microns. Sheet should have protective guard film of 25 microns minimum to avoid scratches during transportation and should be supplied in single length upto 12 metre or as desired by Engineer-in-charge. The sheet shall be fixed using self drilling/self tapping screws of size (5.5x55mm) with EPDM seal, complete upto any pitch in horizontal/ vertical or curved surfaces, excluding the cost of purlins, rafters and trusses and including cutting to size and shape wherever required.

OD18489/2024-2025:Supplying and fixing 200 mm M.S pipe (6 mm thick)including fixing at correct alignment including all cost convayance and all other incidental charges etc complete

OD18510/2024-2025:Supplying and fixing Suction Strainer of SS 304 mesh (1/2) and SS 304 connecting plate of thickness 5 mm used to remove debris and waste .

OD20507/2024-2025:Supplying and fixing 100 Amp 3 phase main switch

OD20628/2024-2025:Charges for lower the pump,motor and all related accessories stored in the upper floor safely with the help of chain block, wire sling coir rope ,etc.complete as per the direction of departmental officers at site

APPENDIX-B-CIVIL WORK

2.6.1:Earth work in excavation by mechanical means (Hydraulic excavator)/manual means over areas (exceeding 30 cm in depth, 1.5 m in width as well as 10 sqm on plan) including disposal of excavated earth, lead up to 50 m and lift up to 1.5 m, disposed earth to be levelled and neatly dressed.All kinds of soil

OD18482/2024-2025:Checkered rubber floor mat of size 120x60 cm ,10 -20mm thick for sefety purpose of the worker

OD18483/2024-2025:Electrical insulated rubber gloves as per OSHA(29 CFR 1910.137(C))2(VIII)and reference table 1-5

OD18484/2024-2025:Thermoplastic poly propylene back chair with arm for indoor use

13.61.1:Painting with synthetic enamel paint of approved brand and manufacture to give an even shade:Two or more coats on new work

13.81.1:Dis tempering with Ist quality acrylic distemper, having VOC (Volatile Organic Compound) content less than 50 grams /litre, of approved brand and manufacture, including applying additional coats wherever required, to achieve even shade and colour.One coat

4.10:Providing and laying damp-proof course 40 mm thick with cement concrete 1:2:4 (1 cement : 2 coarse sand (zone III) : 4 graded stone aggregate 12.5 mm nominal size).

OD18507/2024-2025:Engaging Man coolie for roof cleaning

13.7.2:12 mm cement plaster finished with a floating coat of neat cement of mix:1:4 ( 1 cement : 4 fine sand)

OD18511/2024-2025:Net for window 1.00x0.60 cm size

14.44:Distempering with dry distemper of approved brand and manufacture ( one or more coats ) and of required shade on old work to give an even shade.

OD18644/2024-2025:Fire extinguishers class c type co2 -2 kg

SUMA T P

MURALEEDHARAN M R

Bidder Name

MURALEEDHARAN M R

RONAK S

SUMA T P