Providing & Erecting Streetlights at Waghai - Ahwa Road, Dist. Dang (For 1.7 km)

Name of work : Providing & Erecting Streetlights at Waghai - Ahwa Road, Dist. Dang (For 1.7 km)

Qnty. Unit Ite Item Description Rate in Rate in Words Per Amount

40 Mtr 1 providing and erecting Mains with ISI marked, 1.5KV grade 56.56 Rupees Fifty Six And Paise Fifty Six Mtr

electrolyte multi stranded, annealed copper conductor with heat Only

resistant PVC insulated conforms to IS 694, IEC - 227 erected

in existing pipe of following size (Specifically for control panel,

relays, power switchgears, motor starters & control wiring) with

required size of copper lugs, nuts and bolts if required. (e) One

wire 6.00 sq. mm

10 Mtr 2 providing and erecting Mains with ISI marked, 1.5KV grade 91.91 Rupees Ninety One And Paise Ninety Mtr

electrolyte multi stranded, annealed copper conductor with heat One Only

resistant PVC insulated conforms to IS 694, IEC - 227 erected

in existing pipe of following size (Specifically for control panel,

relays, power switchgears, motor starters & control wiring) with

required size of copper lugs, nuts and bolts if required. (f) One

wire 10.00 sq. mm

1352 Mtr 3 Supplying and erecting Flexible PVC insulated multi strand 46.46 Rupees Forty Six And Paise Forty Six Mtr

multi core 1.1 kv grade ISI marked copper wires of following Only

size to be erected as directed. (e) 1.50 Sq.mm 3 core round

288 Mtr 4 Supplying and erecting Flexible PVC insulated multi strand 77.77 Rupees Seventy Seven And Paise Mtr

multi core 1.1 kv grade ISI marked copper wires of following Seventy Seven Only

size to be erected as directed. (h) 2.50 Sq.mm 3 core round

169 Nos 5 Supplying and erecting LED street light / Flood light fittings 5976.17 Rupees Five Thousand Nine Hundred Nos

with High power White LEDs wattage of 3 Watt and above Seventy Six And Paise Seventeen

assembled on single MCPCB, efficiency more than 130 lm/w Only

and corrosion free High pressure die cast aluminum housing

with smooth finish powder coated and heat sink extruded

aluminium with diffuser and Polycarbonate optics/ lenses, with

toughened glass with company mark/name engraved or

embossed 160 to 270 V,Power Factor more than 0.95, THD <

10 %, CCT 3000 K to 5700K,Uniformity ratio >0.45,

Luminaire efficacy> 100 lumens/watt . LED driver efficiency >

85 %.( fittings required LM-79 & LM-80 certificates)(NOTE:

Below description have shown ranges of Wattage capacity of

LED fittings.The Engineer incharge may select any wattage

capacity between the ranges shown.) (A) Street Light (IP-65),

Surge protection -4KV integral and ,Light must have 440VAC

line supply with over-voltage protection. (iii) 90 watts Cat-lll

24 Nos 6 Supplying and erecting LED street light / Flood light fittings 9647.52 Rupees Nine Thousand Six Hundred Nos

with High power White LEDs wattage of 3 Watt and above Forty Seven And Paise Fifty Two

assembled on single MCPCB, efficiency more than 130 lm/w Only

and corrosion free High pressure die cast aluminum housing

with smooth finish powder coated and heat sink extruded

aluminium with diffuser and Polycarbonate optics/ lenses, with

toughened glass with company mark/name engraved or

embossed 160 to 270 V,Power Factor more than 0.95, THD <

10 %, CCT 3000 K to 5700K,Uniformity ratio >0.45,

Luminaire efficacy> 100 lumens/watt . LED driver efficiency >

85 %.( fittings required LM-79 & LM-80 certificates)(NOTE:

Below description have shown ranges of Wattage capacity of

LED fittings.The Engineer incharge may select any wattage

capacity between the ranges shown.) (B) Flood Light (IP-65),

Surge protection -4KV integral and ,Light must have 440VAC

line supply with over-voltage protection. (vi) 200 watts Cat-lll

4 Nos 7 Providing and erecting Approved make Four pole moulded case 8055.76 Rupees Eight Thousand Fifty Five Nos

circuit breaker having breaking capacity ICU of 35 KA. at 415 And Paise Seventy Six Only

V. having normal current rating 125A. with Fixed thermal &

magnetic release suitable to work on A.C.supply 50 c/s. with all

internal connections, spreader tinned copper & complete erected

in existing 16 G.M.S. housing. ICS=100% of ICU only.Cat III

Qnty. Unit Ite Item Description Rate in Rate in Words Per Amount

4 Nos 8 Providing and erecting Approved make Earth fault Relay 4983.34 Rupees Four Thousand Nine Hundred Nos

suitable to mount with inter connection suitable to following Eighty Three And Paise Thirty Four

size of moulded case circuit breaker having CT ratio & MCCB Only

rating as following along with shunt trip 220V AC. with all

internal connections & complete erected in existing

M.S.housing.. (2) 125 A -200 A , CT Ratio 1/200

1.6 Nos 9 Supplying and erecting triple pole & neutral 440V / 500V panel 1961.42 Rupees One Thousand Nine Hundred Nos

mounting Copper Busbars with four equal Nos. of electrolyte Sixty One And Paise Forty Two Only

bus having current density not more than 1.6 Amp. / sq.mm

(Rated current / cross section area) duly wrapped with colour

insulating tape for phase sequence of following current carrying

capacity, erected with necessary bus bar supports /insulators,

main cable socket to each bar, erected in existing cubical panel

with necessary connections. (A) Suitable for 100 Amp.

169 Nos 10 providing and erecting Miniature circuit breaker single pole 270.68 Rupees Two Hundred Seventy And Nos

0.5A to 2A system and having breaking capacity 10 KA to be Paise Sixty Eight Only

erected in existing box. confirming to IS 8828/1996 with ISI

12 Nos 11 Providing & erecting 415V MCB Four Pole Switch for Lighting 638.32 Rupees Six Hundred Thirty Eight And Nos

Load (B curve) having 10KA breaking capacity & confirms to Paise Thirty Two Only

IS :8828 in existing box having following capacity (b)40 Amp.

157 Kg 12 Providing and erecting HOT deep Galvanised iron strip wire 8 77.77 Rupees Seventy Seven And Paise Kg

to 16 SWG. Seventy Seven Only

31 Nos 13 Providing and erecting Pipe type earthing having 150 cms.long 368.65 Rupees Three Hundred Sixty Eight Nos

and 2.5 cms. dia. galvanised iron pipe with coupling and buch And Paise Sixty Five Only

buried in specially prepared earth pit complete with necessary

SWG earth wire.

31 Nos 14 For using salt and charcoal / coke as required for pipe type 171.70 Rupees One Hundred Seventy One Nos

earthing. And Paise Seventy Only

6 Nos 15 Supplying & erecting earth pit of minimum bore dia.150mm size 4591.46 Rupees Four Thousand Five Hundred Nos

approved make Earthing Electrode consisting Pipe-in-Pipe Ninety One And Paise Forty Six Only

Technology as per IS 3043-1987 made of corrosion free hot

dipped G.I.Pipes having Outer pipe dia of 50mm having 80-

200 Micron galvanising, Inner pipe dia of 25 mm having 200-

250 Micron galvanising, connection terminal dia of 12mm with

constant ohmic value surrounded by highly conductive

compound with high charge dissipation suitable for following

type of applications with chamber and heavy duty cover.

(A)(approved make OEM has to submit test certificate

including value of earth resistance of installation duly stamped

and signed by agency and officer Incharge has to ensure the

value of earthing resistane mentioned in test Certificate) &

having back filling compound of (B) Inner chemical (CCM

Compound)- Resistivity:- 0.2 ohm / meter testing as per IEC

62561-2017, Voltage drop:- < 1 volt at no load & dry form,

Sulphar content:- <2%(C) Back fill Compound :- Earthing

compound should be capable to retain moisture for long time

Necessary test report must be submitted by Agency. (a) For

Electrical Installation up to 440V in normal soil Length of pipe -

1 Mtr Back filling compound - 1 Nos Bag of 15 Kg.

40 Kg. 16 Providing , erecting , fabricating the M.S. structure as per 77.77 Rupees Seventy Seven And Paise Kg.

requirement on site incorporating proper size of M.S. Seventy Seven Only

angles,square,round, flats, bars, channels, sections complete

with cutting, welding, grinding & finishing duly painted with

one coat of red oxide with erection on site as per direction of

engineer in charge with necessary grouting, cementing,

plastering & finishing complete.

Qnty. Unit Ite Item Description Rate in Rate in Words Per Amount

2 Sq.Mtr 17 Providing & erecting weather proof, dust & vermin proof, floor 16323.62 Rupees Sixteen Thousand Three Sq.Mtr

mounted front operated outdoor type double door cubical panel Hundred Twenty Three And Paise

board necessary IP-54 and above protection as per approval Sixty Two Only

from engineer incharge made from 14 SWG thick CRC M.S.

sheet for outer body & doors, 16 SWG thick CRC M.S.sheet

for internal partitions with necessary accesories , supporting

angles/ flats channel including cutting, bending, drilling,

welding, riveting with internal partitions & cable alley as per

requirements & instruction of engineer-in-charge with erection

of supplied switch gears, BUSBARS, suitable size of inter

connecting PVC copper wire / copper-aluminium strips, rubber

grommets, rib, bakelite control fuses/MCB for measuring

instruments, earth bus & earth bolts, foundation flange - bolts-

base Plates, sufficient nos. of hinged doors, handles with

locking arrangement and rubber gasket,heavy duty end terminal

connection,danger notice board,necessary ventilation,earthing

strip complete. The Panel shall be painted with epoxy powder

coating. (The rates excludes the cost of switchgears, bus bars,

inter connecting mains & Copper Aluminium strips, meters,

Fuses etc. The dimension shall be measured excluding base

beams) The panel shall be supplied with following approved

100 Mtr 18 Providing and erecting XLPE(IS:7098)(I)-88 ISI armoured 378.75 Rupees Three Hundred Seventy Eight Mtr

cable multistrand Aluminium conductor for 1.1 KV. to be laid And Paise Seventy Five Only

on wall with necessary clamps or in existing trench / pipe of

following size of cables (D) 3 1/2 core 70 Sq. mm ( 35 Sq. mm

2236 Mtr 19 Providing and erecting XLPE (IS:7098)(I)-88 ISI armoured 140.39 Rupees One Hundred Forty And Mtr

cable multistrand / Solid Aluminium conductor for 1.1 KV. to Paise Thirty Nine Only

be laid on wall with necessary clamps or in existing trench /

pipe of following size of cables (C) 4 core 10 Sq. mm

1700 Mtr 20 Providing and erecting XLPE (IS:7098)(I)-88 ISI armoured 153.52 Rupees One Hundred Fifty Three And Mtr

cable multistrand Aluminium conductor for 1.1 KV. to be laid Paise Fifty Two Only

on wall with necessary clamps or in existing trench / pipe of

following size of cables (A) 4 core 16 Sq. mm

1780 Mtr 21 Making trench in soft soil of suitable width of 90 cm deep for 55.55 Rupees Fifty Five And Paise Fifty Mtr

laying cable or locating the fault all over the run and back Five Only

filling the same and making the surface as normal ground.

126 Mtr 22 Making trench in Hard Murrum / Tar Road of suitable width of 357.54 Rupees Three Hundred Fifty Seven Mtr

90 cm or required depth for laying any size of cable or locating And Paise Fifty Four Only

the fault all over the run and back filling the same and making

the surface as normal ground. (B) If additional machinery like

hammer driller or JCB use [Add]

2077 Mtr 23 Providing & laying approved make Double walled corrugated 62.62 Rupees Sixty Two And Paise Sixty Mtr

pipes (DWC) of polyethylene(conforming to IS 14930 II )with Two Only

necessary connecting accessories of same material at required

depth in existing trench for laying of cable. below ground /

road surface for enclosing cable (A)50 mm outer dia

190 Nos 24 Providing and, fixing heavy duty flange type brass cable gland 38.38 Rupees Thirty Eight And Paise Thirty Nos

with rubber ring for PVC insulated armoured cable complete Eight Only

with out going tails, insulating tape etc for following size of

cables.(C) 2 to 4 core 10 Sq. Mm

8 Nos 25 Providing and, fixing heavy duty flange type brass cable gland 47.47 Rupees Forty Seven And Paise Forty Nos

with rubber ring for PVC insulated armoured cable complete Seven Only

with out going tails, insulating tape etc for following size of

cables.(D) 2 to 4 core 16 Sq. mm

8 Nos 26 Providing and, fixing heavy duty flange type brass double 103.02 Rupees One Hundred Three And Nos

compression type cable gland with rubber ring for PVC Paise Two Only

insulated armoured cable complete with out going tails,

insulating tape etc for following size of cables. (C) 3 & 1/2

760 Nos 27 Solder less crimping type Aluminium lugs conforming to IS 13.13 Rupees Thirteen And Paise Thirteen Nos

suitable for cable of following size evenly crimped with high Only

pressure tool & connected to switchgear terminals with

brass/cadmium plated nut bolts in an approved manner. (B)

32 Nos 28 Solder less crimping type Aluminium lugs conforming to IS 15.15 Rupees Fifteen And Paise Fifteen Nos

suitable for cable of following size evenly crimped with high Only

pressure tool & connected to switchgear terminals with

brass/cadmium plated nut bolts in an approved manner. (C)

Qnty. Unit Ite Item Description Rate in Rate in Words Per Amount

32 Nos 29 Solder less crimping type Aluminium lugs conforming to IS 25.25 Rupees Twenty Five And Paise Nos

suitable for cable of following size evenly crimped with high Twenty Five Only

pressure tool & connected to switchgear terminals with

brass/cadmium plated nut bolts in an approved manner. (E)

95 Nos 30 Supplying and erecting approved make Octagonal pole made 11411.99 Rupees Eleven Thousand Four Nos

from HR sheet steel. The pole should be made as per IS. and Hundred Eleven And Paise Ninety

shall be coated with hot dip galvanizing as per IS Nine Only

2629/2633/4759, suitable suspend local wind speed with

integral Junction box consist of terminal plate of min 6mm

Hylam sheet, standard profile 35mmX7.5mm Din-Rail for MCB

Mounting, stud type terminal and arrangement for cable

termination to be erected With Suitable foundation (Included)

as per details given by manufacturer considering site

requirement. (E) 7 Mtr. Long 70 mm Top X 135 mm bottom

dia, 3 mm thickness with 225mmX225mmX16mm base plate, 4-

M20 Bolts and 600mm long with necessary G.I. J Bolts

.Approx Pole weight 67 kg

28 Nos 31 Providing and erecting street light pole bracket comprising main 614.08 Rupees Six Hundred Fourteen And Nos

B Class GI pipe of 4.2 cm/require outside dia. complete with Paise Eight Only

suitable B Class G.I sleeve tubing of approx. 45cms.length and

suitable for 76.5 mm / 80mm. / require size pole top having

sufficient fasteners for fixing the brackets and having spread of

1 mtr. length with suitable rise as per site condition & suitable

welded stiffener reducer and nipple with check nut complete

painted with one coat of Red oxide / PU base primer and two

coats of Aluminium / PU paint. paint with following nos of

arms. [A] Single Arm bracket 1 Mtr

60 Nos 32 [B] Double Arm Bracket 1 Mtr 829.21 Rupees Eight Hundred Twenty Nine Nos

And Paise Twenty One Only

7 Nos 33 [C] Three Arm Bracket 1 Mtr 1045.35 Rupees One Thousand Forty Five Nos

And Paise Thirty Five Only

50 Mtr 34 Supplying and erecting B class Galvanized iron pipe having 249.47 Rupees Two Hundred Forty Nine And Mtr

smooth finished bore of the pipe on both ends erected nuts and Paise Forty Seven Only

bolts along the pole / wall shaping the pipe as per site

requirement. Pipe dia as following. (C) 40 mm dia.

2 Nos 35 Supplying & erecting IP 55 grade following size section pillar 3595.60 Rupees Three Thousand Five Nos

fabricated from joint less M.S. Sheet with angle iron legs made Hundred Ninety Five And Paise Sixty

from jointless M.S. Angle with cable clamps to be buried in Only

ground to have appropriate erection to work uniform until

erected with cement concrete foundation and 45 cm high bricks

work finishing with plaster etc. hinged double door internally

supported on both side, with internal and outside looking

arrangement with look and keys in duplicate 35 x 35 x 5 mm

M.S. Angle of Two Nos. one is welded and other with nut and

bolt for erecting Bakelite sheet. Painting the Section Pillar

inside and out side with three tank powder coated paint. section

pillar roof should be without joint with water leakage proof &

tested as per IP 55 test & followed by IS 2147 of 1962 (B) 75 X

60 X 45 cm section pillar fabricated from 16 Gauge MS Sheet

with angle iron legs 45 cm long made from 35 X 35 X 5 mm

thick MS angle.

Qnty. Unit Ite Item Description Rate in Rate in Words Per Amount

4 Nos 36 Supplying & erecting IP 55 grade following size section pillar 1884.66 Rupees One Thousand Eight Hundred Nos

fabricated from joint less M.S. Sheet with angle iron legs made Eighty Four And Paise Sixty Six Only

from jointless M.S. Angle with cable clamps to be buried in

ground to have appropriate erection to work uniform until

erected with cement concrete foundation and 45 cm high bricks

work finishing with plaster etc. hinged double door internally

supported on both side, with internal and outside looking

arrangement with look and keys in duplicate 35 x 35 x 5 mm

M.S. Angle of Two Nos. one is welded and other with nut and

bolt for erecting Bakelite sheet. Painting the Section Pillar

inside and out side with three tank powder coated paint. section

pillar roof should be without joint with water leakage proof &

tested as per IP 55 test & followed by IS 2147 of 1962 (C) 60 X

30 X 45 cm section pillar fabricated from 16 Gauge MS Sheet

with angle iron legs 45 cm long made from 35 X 35 X 5 mm

thick MS angle.

1 Sq.Mtr 37 Supplying and erecting HYLAM sheet on existing angle iron 1156.45 Rupees One Thousand One Hundred Sq.Mtr

frame.for following thickness (C) 6mm Fifty Six And Paise Forty Five Only

8 Nos 38 Supplying & erecting approved make Digital time switch having 3168.37 Rupees Three Thousand One Nos

lithium cell 6 years operative and operate battery backup 1 Hundred Sixty Eight And Paise Thirty

channel day clock with 14 memory programme, suitable to Seven Only

operate on 240V + 5%, 16A with, floating contacts Minimum

switching setup time 1 minimum & LCD display. Also

comprised permanent ON/OFF switching. Programming

switches & housed in fire proof thermoplastic enclosure &

transparent cover erected as required with necessary connection

erected as directed.

8 Nos 39 Supplying & erecting power contactor ,AC3 duty for time 2782.55 Rupees Two Thousand Seven Nos

switch complete erected as per direction Cat III (D) 4 pole Hundred Eighty Two And Paise Fifty

440V 40 Amp. Five Only

4 Nos 40 Supplying, erecting, testing, commissioning approved make 141616.14 Rupees One Lakh(s) Forty One Nos

M.S. Polygonal High Mast Pole having following general Thousand Six Hundred Sixteen And

Specification. Paise Fourteen Only

(a) Polygonal Section fabricated from M.S. Plate confirms

BSEN 10025 & Hot deep galvanized minimum 65/86 micron

(as per IS 2629 /1985) Lantern carriage with ring and rubber

lines for erection of luminaries of suitable site.

(b) Maximum telescopic section not more than four

(c) Double drum gear pipe motorized winch with 6mm dia S.S.

Rod (For 16 mtr and above size)

(d) Approved make L.E.D. aviation light = 1 No. Lightening

arrestor = 1 No. with necessary wiring of 2.5 sq.mm 5 core ISI

copper cable Unarmoured.

(e) Bottom most section suitable for mounting reversible motor

and switchgears having door not more than 1400mm x 300mm

with waterproof gasket & hinges & locking arrangement.

(f) Pole structure comprises suitable size of reversible motor,

cable and necessary switchgears with control panel. (g) bottom

section shall have suitable size of thickness supports ribs

foundation bolts nuts etc.

(h) Item not comprises the cost of lanterns.

(i) Necessary Cement Concrete foundation as per IS including

testing & commissioning of the entire structure for following

size of High Mast poles [1] High Mast 12 Mtr. TOP A/F

2 Nos 41 mm, BOTTOM

Supplying A/F 360mm,

and erecting No. of make

approved Sec. No. - 1, mounting

panel Bottom type 1275.63 Rupees One Thousand Two Hundred Nos

Digital Voltmeter having 3 digits LED display, 0 to 750 AC Seventy Five And Paise Sixty Three

Volts range erected on existing panel board with all Only

connection, wiring etc .with manufacturers calibration

2 Nos 42 Supplying and erecting approved make panel mounting type 1558.43 Rupees One Thousand Five Hundred Nos

Digital Ammeter having 3 digits LED display, external CT Fifty Eight And Paise Forty Three

operated, calibrated for 0 to 1000 Amps suitable to operate on Only

500 Volt AC , erected on existing panel board with all

connection, wiring etc .with manufacturers calibration

16 Nos 43 Supplying and erecting Ammeter / Voltmeter selector switch 317.14 Rupees Three Hundred Seventeen Nos

for 3 phase AC Supply 500 V on existing panel board with And Paise Fourteen Only

necessary connections.

6 Nos 44 Providing & erecting L.T. Current Transformer with bar 274.72 Rupees Two Hundred Seventy Four Nos

primary 50/5 to 1000/5 ratio 15 VA burden erected in existing And Paise Seventy Two Only

CRCA box duly secured with insulating materials connected to

Qnty. Unit Ite Item Description Rate in Rate in Words Per Amount

14 Nos 45 Supplying and erecting approved make suitable panel indicator 43.43 Rupees Forty Three And Paise Forty Nos

LED type lamp, lens cover, complete erected with necessary Three Only

Deputy Executive Engineer Executive Engineer

Electrical R & B sub-Division Electrical (R & B) Division