Construction of Bagli Pacca Bharo to Nalsuha via Sukhar road Km. 0/0 to 2/680 (SH. Formation cutting, Retaining wall, Cross Drainage work, P/L Granular Sub Base, Metalling and Tarring, CC Pavement, Road side Drain and Parapets). Under NABARD RIDF-XX

Amount

Excavation for road way in hilly areas in all heights and depths and in all kinds of soil by manual/ mechanical means, including saturated soil comprising of ordinary soil, ordinary rock, soft rock, hard rock chiseling or wedging out of rock (where blasting is prohibited) and their intermediate classification of soil complete including setting out true to the required lines grades, cutting and trimming of side slopes, camber, super elevation and levels shown as per the drawings and as directed by the Engineer-in Charge complete in conformity with the requirements of MORD Technical Specification section 300 and 1600 and sorting out and stacking of useful materials with in all leads and lifts of material in acquired road width and transporting of un-useful materials for filling in road ways, camber, embankments for grade improvements and disposal of all surplus materials to the approved dumping sites through all modes of transportation including head load or animal transport or by mechanical means including leveling, fine dressing and carriage of machineries, materials, tools, equipments and safety measures and other incidentals necessary to complete the work by mechanical means and labour if required. Recovery of stones to the tune of 415.64 cubic metre quantity at the rate of Rs. 300/- only (Rupees three hundred only) per cubic metre shall be effected from the contractor running bills on pro-rata basis as per actual quantity executed. Any loss to the public/private property during the course of execution shall be the absolute responsibility of the contractor which shall have to be compensated by him to the extent of damage occurred in all cases. The rate is including Octroi, Royality, Malkhana, toll tax, sale tax, GST or any other taxes imposed by the Government.

Construction of embankment with approved materials deposited at site obtained from roadway cutting and excavation from drains and foundation of all other structures or other sources, graded and compacted to meet requirement, including setting out, true to the lines, grades, width and side slopes in accordance with drawings, including spreading the embankment material with motor–Grader in successive layers of 200mm (two hundred millimetre) uniform thickness, and compacting with vibratory roller 8-10 (eight to ten) Tonne static weight to meet the requirements of table 300.1 & 300.2 of MORD technical specification clause 301 and 1603.5 and as per the entire satisfactions and directions of Engineer-in-Charge, including carriage of material within all leads, lifts and other incidentals. The rate including Octroi, Royality, Malkhana, toll tax, sale tax, GST or any other taxes imposed by the Government.

Earth work in excavation for all type of road structure such as Retaining walls, Breast walls, culverts, drains and parapets etcetera in all type of classification of soil comprising of ordinary soil, ordinary rock, hard rock, chiseling/wedging out rocks (where blasting is prohibited) as per drawings and M.OR.D. technical specification section 300 and 1600 as per direction and entire satisfaction of Engineer-in-Charge, including setting out construction of shoring and bracing, removal of stumps and other deleterious materials and disposal of materials up to any lead and lift including dressing of sides and bottom and back filling in trenches with excavated suitable approved material to the original surface in layers not exceeding 150mm (One hundred fifty millimetre) compacted thickness including shoring and strutting and pumping and bailing out water (surface and sub soil water) up to any depth any quantum of water including cleaning of slush which may arise out during dewatering as per direction and entire satisfaction of Engineer-in-Charge including carriage of materials within all leads and lifts and other incidental. The rate is including Octroi, Royality, Malkhana, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated cement concrete nominal mix 1:5:10 (one cement isto five sand isto ten graded crushed stone aggregate 40mm (forty millimetre) nominal size) for plain cement concrete in all heights/depths, on ground or under water, including pumping or bailing out water/dewatering (surface and sub-soil water) and removal of the slush which may arise at the time of laying concrete, for all heights/depths and any quantum of water, including cost of form work and curing complete in all type of structures like Retaining Walls & Breast Walls etcetera complete as per drawing and MORD technical specification section 800, 900 and 1200 and as per the direction and the entire satisfaction of Engineer-in-Charge, including carriage of materials up to all leads, lifts and other incidentals. The rate including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Back filling behind abutment Retaining wall/Breast wall, Wing walls and the like with approved granular materials complete as per drawings and MORD technical specification clause 1203 and 1604 as directed by the Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing and laying 100mm (One Hundred millimetre) dia PVC pipe Weep Holes in brick masonry/plain /reinforced concrete abutments, wing wall/ return wall, retaining walls and breast walls etcetra, extending through the full width of the structure with slope of 1V:20H (One vertical : twenty Horizontal) towards draining face complete as per drawing and MORD technical specification clause 709, 1206.6 and as per the directions and entire satisfactions of Engineer-in-Charge, including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sales tax, GST or any other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated concrete for plain cement concrete, Nominal mix 1:3:6 (one cement isto three sand isto six graded crushed stone aggregate (40mm) forty millimetres nominal size) on ground or under water in open foundations and the like for all types of structures, including pumping or bailing out water/dewatering (surface and sub-soil water) and removal of the slush which may arise at the time of laying concrete, for all heights/depths and any quantum of water, including cost of form work and curing complete as per drawing and MORD technical specification clause 802, 803, 1202 & 1203section 800, 900 and 1200 and as per the direction and the entire satisfaction of Engineer-in-Charge, including carriage of materials within all leads, lifts and other incidentals. The rate including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated concrete for plain cement concrete Nominal mix 1:2½:5 (one cement isto two and half sand isto five graded crushed stone aggregate (40mm) forty millimetre nominal size) on ground or under water, including pumping or bailing out water/ dewatering (surface and sub-soil water) and removal of the slush which may arise at the time of laying concrete, for all heights/depths and any quantum of water, in Abutments, toe walls, parapets etcetera including cost of form work and curing complete as per MORD technical specification section 800, 900 and 1200 and as per the direction and the entire satisfaction of Engineer-in-Charge, including carriage of materials within all leads, lifts and other incidentals. The rate including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing and laying flooring of Rubble stone laid in cement mortar 1:3 (one cement isto three sand) laid over cement concrete bedding M-10 (M-ten) complete as per drawing and technical specification Clause 1303 and as per the direction and the entire satisfaction of Engineer-in-Charge, including carriage of materials within all leads, lifts and other incidentals. The rate including Royality, Malkhana, Octroi, toll tax, sale tax GST or any other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated concrete for plain cement concrete in cradle bedding for hume pipe of plain cement concrete Nominal mix 1:2½:5 (one cement isto two and half sand isto five graded crushed stone aggregate 40mm (forty millimetre) nominal size on ground or under water, including pumping or bailing out water/ dewatering (surface and sub-soil water) and removal of the slush which may arise at the time of laying concrete, for all heights/depths including cost of form work and curing complete as per MORD technical specification section 800, 900 and 1100 and as per the direction and the entire satisfaction of Engineer-in-Charge, including carriage of materials within all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Earth filling (for marshy soil) in foundation, trenches and the like for Earth cushion over Hume pipe culverts etcetera with granular material/Earth obtained from Approved quarry approved by Engineer-in-Charge including thoroughly watering ramming/compacting with plate compactor/ power rammer, in layers not exceeding 150mm (One Hundred fifty millimetre) in thickness complete as per MORD technical specification as per clause 305.3.9 and as per the direction and the entire satisfaction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rates including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing and laying (to level or slope) 900mm dia (Nine hundred millimetre) diametre reinforced cement concrete heavy duty non pressure pipes IS Class NP-3 for culverts on first class bedding or granular material in single row including fixing collar with cement mortar 1:2 (One cement isto two sand) but excluding the cost of excavation, protection works, back filling, concrete and masonry work in head walls and parapets as per drawing and M.O.R.D. technical specifications clause 1101 and as per direction of Engineer-in-Charge including carriage of materials within all leads and lifts and other incidental. The rate is including Octroi, Royality, Malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Supplying fitting and placing HYSD bar reinforcement (Fe-415) in sub structure including cutting bending binding shifting to site and placing in position complete including the cost of binding wire upto all height/depth complete as per drawing and MORD technical specificationssection 1000 and 1200 and as per the directions and the entire satisfaction of Engineer-in-Charge including carriage of materials within all leads, lifts and other incidental. The rate including of Octroi, Royality, Malkhana, Toll Tax, Sale Tax, GST or other Taxes imposed by the Government.

Supplying fitting and placing HYSD bar reinforcement in super structure complete as per drawing and MORD technical specifications section 1000 and 1400 including cutting, bending, binding and placing in position complete in all respect including cost of binding wire upto all height/depth as per direction of Engineer-in-Charge including carriage of materials within all leads, lifts. The rate including of Octroi, Royality, Malkhana, Toll Tax, Sale Tax, GST or other Taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated reinforced cement concrete Grade-M-20 (M-Twenty) Design mix with minimum cement contents of 330 kgs. (three hundred thirty kilograms) per cubic metre with 20mm (Twenty millimetre) nominal size graded crushed stone aggregate in bed block, Dirt walls and the like, etcetera for all heights, including cost of form work and curing complete but excluding the cost of reinforcement for R.C.C work as per MORD technical specification section 800, 900 and 1200 complete and as per the direction and the entire satisfaction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated concrete for plain cement concrete Grade-M20 (M-Twenty) Nominal mix 1:2:4 (one cement isto two sand isto four graded crushed stone aggregate (40mm) forty millimetre nominal size) on ground or under water in open foundation for all types of structure and the like in Catchpit flooring etcetera, including cost of form work and curing complete as per drawing and MORD technical specification section 800, 900 and 1200 and as per the direction and the entire satisfaction of Engineer-in-Charge, including pumping or bailing out water/dewatering (surface and sub-soil water) and removal of the slush which may arise at the time of laying concrete for all heights/depths and any quantum of water complete including carriage of materials up to all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated reinforced cement concrete Grade-M25 (M-Twenty Five) design mix with minimum cement contents of 400 kgs. (four hundred kilograms) per cubic metre with 20mm (Twenty millimetre) nominal size graded crushed stone aggregate in Deck slab, wheel guard, guide posts and the like up to all heights, including cost of form work and curing complete but excluding the cost of reinforcement for Reinforced work as per drawing and MORD technical specification section 800, 900 and 1400 complete and as per the direction and the entire satisfaction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated reinforced cement concrete Grade-M-30 (M-Thirty) design mix with minimum cement contents of 407kgs. (four hundred seven kilograms) per cubic metre with 20mm (twenty millimetre) nominal size graded crushed stone aggregate in Wearing Coat including cost of reinforcement for Reinforced work form work and curing complete, as per drawing and MORD technical specification section 1400 complete and as per the direction and entire satisfaction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rates including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Construction of reinforced cement concrete mechanically mixed and vibrated, railing of RCC M-30 grade (M-Thirty), design mix with minimum cement contents not less than 407 Kg (four hundred seven kilogram) per cubic metres with 20 mm (twenty millimetres) nominal size graded crushed stone aggregate and curing complete, constructed true to line and grade, tolerance of vertical railing post not to exceed 1 in 500 (One in five hundred) centre to centre, spacing between vertical post not to exceed 2000mm (two thousand millimetre) including the cost of reinforcement and form work as per drawing and MORTH technical specifications section 1500, 1600, 1700 and 2700 complete as per the direction of Engineer-in-Charge including carriage of materials within all leads, lifts and other incidental. The rate is including Octroi, Royality, Malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Providing and fixing drainage spouts complete with 100mm (one Hundred millimetres) diametre galvanised mild steel down pipe corrosion resistant structural steel grating complete as per drawings and MORD technical specification clause 1209 and as per direction and entire satisfaction of the Engineer-in-Charge including carriage of materials within all leads, lifts and other incidental. The rate including Octroi, Royality, Malkana, Toll Tax, Sale Tax, GST or other Taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated reinforced cement concrete Grade-M25 (M-Twenty Five) designed mix with minimum cement contents of 400 kgs. (four hundred kilograms) per cubic metre with 20mm (twenty millimetre) nominal size graded crushed stone aggregate in Approach Slab and the like up to all heights, including cost of form work, reinforcement for Reinforced work and curing complete as per drawing and MORD technical specification section 1400, complete as per the direction and satisfaction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sales tax or any other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated plain cement concrete nominal mix 1:2.5:5 (one cement isto two and half sand isto five graded crushed stone aggregate 40mm (forty millimater) nominal size leveling Course below approach slab complete as per drawing and technical specifications section 800, 900 and 1200 and as per the direction and entire satisfaction of the Engineer- in-charge including carriage of materials within all leads and lifts and other incidental. The rate is including Octroi, Royality, Malkhana, toll tax, sale tax, GST or other taxes imposed by the Government.

Loosening of the ground upto the level of 300mm (three hundred millimetre) below sub-grade level watered graded with motor grader and compacted in layers to meet requirement of Tables 300.1 and 300.2 of MORD Technical Specification section 300 and as per direction and the entire satisfaction of the Engineer-in-Charge including carriage of materials within all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Construction of sub grade and earthen Shoulder with approved materials obtained from borrow pits within all leads and lifts, transporting to site, spreading, grading to required slope and compacted to meet requirement of 300-2 as per MORD technical specification clause 407 including hauling of material with in all leads, lifts and other incidentals and as per the entire satisfaction and direction of Engineer-In-Charge. The rate is including Royality, Malkhana, Octroi, toll tax, sales tax, GST or any other taxes imposed by the Government.

Construction of Granular sub base compacted thickness by providing well graded material of spreading in uniform layers with tractor mount grader on prepared surface, mixing by mix in place method at OMC with tractor mount appropriate rotavator attachment and compacting with three wheel 80-100 (eighty – Hundred) kN static roller capacity to achieve the desired density, complete as per MORD technical specification clause 401 for grading-I material and as per the direction and entire satisfaction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sales tax, GST or any other taxes imposed by the Government.

Providing laying, spreading by mechanically means and compacting to 75mm (seventy five millimetre) compacted thickness, crushed stone aggregates of Grading-II, 63mm to 45mm (sixty three millimetre to forty five millimetre) nominal size to water bound macadam specification including spreading in uniform thickness using templates, hand packing rolling with three wheeled roller 80-100 (eighty to hundred) kN static weight in stages to proper grade and camber including applying and brooming with stone screening Type-B of size 11.2mm (Eleven point two millimetre) nominal size at the rate of 0.20 (zero point two zero) cubic metre per 10 Sqm. (ten square metre) and binding material at the rate 0.06cum (Zero point zero six cubic metre) per ten square metre of road surface to fill up the interstices of coarse aggregate, watering and compacting to the required density as per MORD Technical specification clause 405 and as per direction and satisfaction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sales tax, GST or any other taxes imposed by the Government.

Providing laying, spreading by manual/mechanically means and compacting to 75mm (seventy five millimetre) compacted thickness, stone aggregates of Grading-III, 53mm to 22.4mm (fifty three to twenty two point four millimetre) size to water bound macadam specification including spreading in uniform thickness, using template, hand packing motor grader, rolling with three wheeled roller 80-100 (eighty to hundred) kN static weight in stages to proper grade and camber including applying and brooming stone screening type-B of size 11.2mm (eleven point two millimetre) nominal size at the rate of 0.18cum (zero point one eight cubic metre) per ten square metre of road surface to fill up the interstices of coarse aggregate, watering and compacting to the required density for grading-III as per MORD Technical specification clause 405 and as per entire satisfaction and direction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing and applying primer coat with bitumen emulsion (SS-I) on prepared surface of granular base including cleaning of road surface with hydraulic brooms and spraying primer with bitumen emulsion pressure distributor at the rate of 0.85 kg (zero point eight five kilogram) per square metre of road surface as per MORD Technical specification clause 502 as per the entire satisfaction and direction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sales tax, GST or any other taxes imposed by the Government.

Providing and applying tack coat with bitumen emulsion RS-I, including cleaning the road surface with hydraulic brooms and spraying with emulsion pressure distributor at the rate 0.275 kg (zero point two seven five kilogram) per square metre on the prepared granular surface treated with primer complete as per MORD Technical specification clause 503, and as per the entire satisfaction and direction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing, laying and rolling of open graded premix carpet of 20mm (twenty millimetre) thickness, composed of 13.2mm to 5.6mm (thirteen point two millimetre to five point six millimetre) aggregates at the rate of 0.27 cum (zero point two seven cubic metre) premixed with bitumen binder VG-Grade-10 (Ten) at the rate of 14.6 kgs (fourteen point six kilogram) per 10 (ten) square metre of road surface, laid to the required line, grade and level to serve as wearing coarse on a previously prepared base including mixing in hot mix plant of 30/40 (thirty/forty) tonne per hour capacity, laying with paver finisher with sensor attachment and rolling with three wheeled 80-100 (eighty to hundred) kN static roller finished to required level and grades complete as per MORD Technical specification clause 506 and as per the entire satisfaction and direction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing and laying seal coat for sealing the voids in a bituminous surface laid to the specified levels, grade and cross falls using Type-B as per MORD technical specification clause 508 using bitumen VG-10 (viscosity grade-ten) at the rate of 6.80kg (six point eight zero kilogram) premixed with 0.06 (zero point zero six) cubic metre of fine aggregate per 10 Sqm. (Ten square metre) of road surface heated in hot mix plant and laying of mixed material and rolling with power road roller 80-100 (eighty to hundred) kN static weight roller, as per the entire satisfaction and direction of Engineer-in-Charge including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Construction of Un-reinforced, dowel jointed at expansion and construction joint only, plain cement concrete pavement, thickness as per design, over a prepared sub base, with 43 (Forty three) grade cement or any other equivalent type as per clause 1501 using M-30 (Thirty) Grade, (design mix) concrete having coarse and fine aggregates conforming to IS : 383, maximum size of coarse aggregate not exceeding 25mm, (Twenty five millimetres) mixed in a concrete mixer of not less than 0.2 (Zero point two) cubic metre capacity and appropriate weigh batcher using approved design mix, laid in approved fixed side form work (steel channel) laying and fixing of 125 (one hundred twenty five) micron thick polythene film, wedges, steel plates including levelling the form work as per drawing, spreading the concrete with shovels, rakes, compacted using needle, screed and plate vibrators and finished in continuous operation including provision of contraction and expansion, construction joints, applying debonding strips, primer, sealant dowel bars, near approaches to bridge/culvert and construction joints, admixtures as approved, curing of concrete slabs for 14 (Fourteen) days using curing compound (where specified) and water, finishing to lines and grade as per drawing and MORD technical specification clause 1501 and as per the direction and the entire satisfactions of Engineer-in-Charge including carriage of materials within all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax or any other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated concrete for plain-cement concrete, nominal mix 1:3:6 (one cement isto three sand isto six graded crushed stone aggregate 20mm (twenty millimetres) nominal size) on ground or under water in open foundations for all Type of structure, such as Drains and the like including pumping or bailing out water/ dewatering removal of the slush as required at site which may arise at the time of laying concrete, for all heights/depths, including cost of form work complete as per drawing and MORD technical specification section 800, 900 and 1200 or as directed by Engineer-in-Charge, including carriage of materials with in all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sales tax, GST or any other taxes imposed by the Government.

Providing and laying stone soling properly hand packed as per drawing and MORD technical specifications section 1300 and as per direction and the entire satisfaction of the Engineer-in-Charge including carriage of materials up to all leads, lifts and other incidentals. The rate is including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Providing and laying of boulder apron Gabion wall laid in wire crates with 4mm (four millimetre) dia GI wire conforming to IS:280 and IS:4826 in 100mmx100mm (One hundred millimetre into one hundred millimetre) mesh (woven diagonally) including 10 (Ten) per cent extra for laps and joints laid with stone boulders weighing not less than 40kg (Forty kilogramme) each as per drawing and MORD technical specifications Clause 1301 and as per direction and the entire satisfaction of the Engineer-in-Charge including carriage of materials up to all leads, lifts and other incidentals. The rate including Royality, Malkhana, Octroi, toll tax, sale tax, GST or any other taxes imposed by the Government.

Ashok Kumar