Replacement of ACSR Weasel Conductor by 11 KV AAAC AL-59, 99 sqmm. Covered Conductor at Villages Rakhwala Gaon, Baagi and Nawakot area etc. under 33/11 KV Sub-Station, Ranipokhri under EDSD, Jollygrant under EDD, Doiwala.

Total amount of the "Rate Schedule" sheet

SCHEDULE OF QUANTITY AND RATE FOR REPLACEMENT OF ACSR WEASEL CONDUCTOR BY 11 KV AAAC AL-59, 99 SQMM. COVERED CONDUCTOR AT VILLAGES RAKHWALA GAON, BAAGI AND NAWAKOT AREA ETC. UNDER 33/11 KV SUB-STATION, RANIPOKHRI UNDER EDSD, JOLLYGRANT UNDER EDD, DOIWALA AGAINST E-TENDER SPECIFICATION NO.64/EDCRDDUN/2025-26

Name of The Bidder's Firm:

Part [A] (Supply Portion)

Stay Clamp for SP-33 with Nut & Bolt

PP & Clamp with N&B ST Pole SP-33

Earth Wire Clamp for SP-33 With N&B

11 KV IPC for Covered Conductor to Covered Conductor

11 KV IPC for Covered Conductor to Bare Conductor

11 KV Mid Span Jointing Kit

11 KV IPC With Al. Bail for Earthing

11 KV Suspension Ties/Cable Ties on Pin Insulator

11 KV AAAC Covered Conductor AL-59,99 Sqmm

11 KV Tension Clamp with Bail & IPC

Total - Part [A]

Part [B] (Labour Portion)

Cartage of ST pole from store centre to construction site with loading, unloading at both points and proper stacking. (51-70 Km.)

Cartage of other material (other than poles) by vehicle fro Store Center to nearest construction site Store including loading and unloading at both ends. (51-70 Km.)

Rs.Per Qtl.

Head load cartage of following Poles from road to site

Upto 0 to 1 Km.

Head load cartage of Small material. Rates are per Km/Quintal including loading and Unloading.

Upto 0 to 1 Km.

Excavation of earth for pole pit of size 0.9x0.6x1/6 of full length of pole for erection of pole in all type of soil including proper dressing of sides and ramming of bottom including getting out the excavated soil and disposal of surplus excavated soil as directed complete work

Erection of following Single support pole in proper level and alignment alongwith fixing of all accessories, like top channel & clamps as per RESPO construction Manual.

Grouting of pole in size 0.45x0.45x1/5 of the support in CC ratio 1:4:8 (1 cement: 4 graded stone 20mm nominal size : 8 coarse sand ) block including cost of Cement,sand and stone ballast back filling of soil and boulders in pit and ramming and proper alignment, leveling as per RESPO construction Manual.

Muffing of poles size 0.45 cm x 0.60 cm radius with cc 1:3:6 (1 cement: 3 coarse sand : 6 graded stone 10mm nominal size) block size 45cm height from ground level including cost of cement, stone and sand etc.

Fabrication of M.S. Channel Angle iron after cutting in required sizes with drilling of holes upto good finish for top channel, bracing and special type bracket etc. as per RESPO sehedule and local approved drawing.

Excavation of earth for Stay pit of size 0.6x0.6x1.2mtr in all type of soil including proper dressing of sides and ramming of bottom including getting out the excavated soil and disposal of surplus excavated soil as directed complete work

Erection of 11 KV Stay Set

Fixing , tightening and nozzaling of Stay with pole and stay rod on required tension as per drawing / RESPO manual.

11 KV line

Grouting of Stay in size 0.6x0.6x0.3 in CC ratio 1:4:8 (1 cement : 4 graded stone 20mm nominal size : 8 coarse sand ) block including cost of Cernent,sand and stone ballast back filling of soil and boulders in pit and ramming and proper alignment, leveling as per RESPO Manual.

Erection of Bracket in 11 KV line

Making of Section Pole

Fixing of IPC with AL Bail for Earthing

Disconnection & Reconnection of Consumer

Fixing of 11 KV 90 KN Tension Clamp B & IPC

Fixing of 11 KV Suspension Ties

Fixing of 11KV IPC for Covered Conductor to Covered Conductor

Fixing of 11KV IPC for Covered Conductor to Bare Conductor

Straightening of Tilted ST Poles

Tightening of Stay Set

Fixing of 11 KV Mid Span Jointing Kit

Removing Old Conductor by Opening Jumper

Laying spreading, Stringing, AAAC Conductor

Back Cartage of Scrap Material

Lopping and Chopping of Tree Branches

Total - Part [B]

TOTAL [Part-(A) + Part (B)]

Place