WORK FOR REPLACEMENT OF 02 NOS. OF S/C TOWERS BY NARROW BASE MULTI CIRCUIT TOWERS (MC-06) OF 132 KV GARH-GAJRAULA LINE FOR

Amount

Work for replacement of 02Nos of S/C towers by Narrow base multi circuit towers(MC-06) of 132kV Garh-Gajraula line for 132 KV Jubilant Ingrevia line under deposit scheme Under ETD-Amroha. Note- The quantities mentioned above are provisional and can vary as per actual requirement /as per approved BoQ

Electrical Supply

Towers

A-Fabrication, galvanizing, inspection and supply of (MC+06) 132KV Towers including stubs, tower extension and stub setting templates, gantry structures as per drawings and bom and hangers, D-shackles, pack washer etc.

i-High Tensile Steel

ii-Mild steel

B(i)-Hot dip galvanized, hexagone round hexagone head transmission tower nut,bolts and washers for above structures as per BOM including step bolts and spring washers

ii-Hex antitheft bolts, nuts & spring washers

For Panther Conductor

PG Clamp Panther-Panther

Vibration Dampers

Mid Span Compression Joint

Repair Sleeves

Pipe type earthing material per tower

Single tension fittings for Panther Conductor.

Double tension fittings for Panther Conductor.

Single suspension fittings for Panther Conductor.

Number Plate for towers

Danger Plate

Phase Plate in sets of red,blue,yellow

Circuit Plate (Set of 02)

120 KN Polymer insulator string for tension towers

Work of replacement of 02Nos of S/C towers by multi circuit towers of 132kV Garh-Gajraula line under deposit scheme Under ETD-Amroha

Complete arrangement of back stay for tower No. 103 of 132 KV Garh-Gajraula line for safety of the tower.

Dismantling of all 3 phases of existing ACSR Panther conductor for 132KV Garh-Gajraula line, all Hardware fittings & conductor accessories e.g. armour rod, vibration dampers, insulator strings etc. of existing line and re-rolling of dismantled conductor on empty drums for re-use, safely transportation of all removed material to UPPTCL stores.

Dismantling of existing Earthwire necessary hardware, Rerolling of earthwire on empty drums & safely transportation of all removed material to UPPTCL stores.

Carriage of Panther conductor (01 Drum) from UPPTCL store/ any other substation to work site including loading & unloading.

Survey including preparation of schedule of materials, marking of locations( Route length) , GPS survey of line with co-ordinates of each tower (the length of line shall be authenticated by GPS Survey)

Check Survey

Soil Investigation (All kind of soil )

Cost of excavation of foundation pits including all earth work, backfilling and levelling etc. for Wet soil

Setting of stubs including all foundation work but excluding the cost of concreting an excavation (rate per location) for MC Towers

Installation of steel reinforcement bars in R.C.C. foundation including cost of steel reinforcement bars with cutting, bending, placing, binding etc.

Cost of concreting of all type of tower foundation including cost of cement, dewatering, shoring, and shuttering, forming, curring but excluding cost of reinforcement bars.

a-1 :1.5:3 concreting

b-1:3:6/PCC concreting

Dismantling of existing towers after cutting/opening of nut & bolts section by section after cutting of tack welding bolts etc. as per dirction of supervising engineer with all cost of men and T&P required for work.

Carriage of material from sub-station/storage place to site of work or vice versa as per site requirment with all cost of men, T&P, vehicle etc. required for work.

Erection of superstructure of 132 KV Towers and Anchor tower and their extensions wherever required including all work above ground level excluding hoisting of insulators, hardware & accessories, but including fitting of danger number, phase plates, bird guard and fixing & punching for 132 KV MC lines.

Laying, stringing, tensioning clamping, jointing etc. of all 06 phases of DC Line Panther Conductor on newly erected multicircuit tower (MC+06) including hoisting of insulators, fitting of all necessary hardware & accessories i.e. fittings, armour rods, vibration dampers etc alongwith all related works upto re-energisation of line

Laying of Earthwire after cutting in suitable size after neccssary fitting of hardware etc.

Tack welding

Pipe type earthing (as per technical specifications) of newly erected towers

Jumpering at section towers after cutting of conductor, fixing of cones etc. with all cost of men, T&P etc. required for work.

NIRMAL ENTERPRISES

SHIVAM ENTERPRISES

Jagad Electrical & Fabricators