Construction of 40.00 mtrs Span PSC Box Girder Bridge over Jandar Khad on Garli Sahan Road at RD 1/100

Excavation in hilly areas in all heights and depths and in all kinds of soil by manual/mechanical means including saturated soil comprising of ordinary soil, soft rocks, hard rocks, chiseling/wedging out of rock (where blasting is prohibited) and other intermediate classification of soil, setting out true to the required lines, grades width cutting and trimming of side slopes and level as shown in the drawing and as directed by the Engineer-in-Charge at site according to the MORD technical specification 2014 clause 1601,1602,1603 and sorting out useful materials and stacking the same in all leads and lifts in acquired width of the road and transportation of un-useful material for filling in road ways, camber, embankments for grade improvements and disposal of all surplus un-useful material to acquired width of the road or on approved dumping sites through all modes of transportation including head load or animals transport or mechanical means alongwith its leveling fine dressing and carriage of machineries, materials, tools equipments and safety measures and other incidentals necessary to complete the work by mechanical means and/or labour if required. Any loss to the public/private property during the course of execution shall be the absolute responsibility of the contractor which shall have to be duly compensated by him in all cases as per direction of the Engineer-in-Charge including carriage of material within all leads and lifts. A recovery of useful stone for 455.52cum ( Four hundred fifty five point five two ) cubic metre @ Rs. 300/- (Rupees Three hundred only) per cubic metre shall be effected on pro-rata basis in each running bill from this item. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Earth work in excavation for all type of road structure such as retaining walls, breast walls, culverts, drains and parapets etcetra in all type of classification of soil comprising of ordinary soil, ordinary rock, hard rocks, chiseling/wedging out of rocks (where blasting is prohibited) as per drawings and technical specification MORD 2014 clause 305.1 and as per direction of the Engineer-in-Charge including setting out, construction of shoring and bracing, removal of stumps and other deleterious materials and disposal of materials upto all leads and lift including dressing of sides and bottom and back filling in trenches with excavated suitable approved material to the original surface in layers not exceeding 150mm (One hundred fifty millimetre) compacted thickness including shoring and strutting and pumping and bailing out water (surface and sub soil water) upto any depth and any quantum of water including cleaning of slush which may arise out during dewatering as per the direction of the Engineer-in-Charge and carriage of material within all leads and lifts and other incidentals The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Earth work in excavation for foundation of bridge structures (Abutments) in all depths as per drawing and MORTH specification clause 304 including setting out, construction of shoring and bracing, removal of stumps and other deleterious materials and disposal in all lead and lift including dressing of sides and bottom and back filling in trenches with excavated Suitable materials. All work of rock cutting by blasting shall be carried out by taking all necessary precautions against soil erosion damage to hill side water pollution etc. and to protect stability of hill side rock shall be excavated with chiseling and wedging out rock(where blasting is prohibited). All type of classifications of soil by manual / mechinical means comprising of ordinary rock, soft rock, / Hard rock as per drawing and technical specfication and as per direction of Engineer -In - Charge including carriage of materials with in all leads and lifts and other incidential. Hauling and stacking of useful materials for construction at suitable sites and safe disposal of unsuitable cut materials in specified manner triming filling of unevenness blindage and finishing of the brigde site to specified dimension or as directed by the Engineer-in-Charge. If the foundation of the structure is in an area with stagnant water or water is met with in the excavation due to spring seepage rain and other causes it shall be remove by suitable diversion bailing out or pumping as directed and the area of the foundation shall be kept dry. Any loss to the public or private property during the course of excavation shall be the sole responsibility of the contractor which shall have to be duly compensated by him in all cases. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST , Labour cess, or other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated concrete for plain/reinforced concrete in sub structures , drains and open foundation for all type of structures complete of plain cement concrete Grade M-10 (ten) design mix on ground or under water and curing complete including pumping or bailing out water, dewatering removal of slush as required at site which may arise at the time of laying under water complete for all heights/depths including the cost of form work as per drawings and technical specification MORTH 2013,2100 clause per direction of Engineer-in-Charge including entire carriage of material within all leads and lifts and other incidentals. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Providing and laying Plain / reinforced cement concrete Mechanically mixed and vibrated cement concrete M-30 (Thirty)grade using graded/ crushed stone aggregate minimum cement contents not less than 407( Four hundred seven) Killogramme per Cubic metre design mix in substructure complete as per drawing and MORTH technical specifications 2013 clause 1500,1700 & 2100 including the cost of form work, curing complete in dirt wall and bed block of abutment/pier and including entire carriage of material in all leads, lifts and heights as per the entire satisfaction and direction of Engineer-in-charge. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST, Labour cess or other taxes imposed by the Government.

Providing and laying Plain / reinforced cement concrete Mechanically mixed and vibrated cement concrete M-35(Thirty)grade using graded/ crushed stone aggregate minimum cement contents not less than 422( Four hundredtwenty two ) Killogramme per Cubic metre design mix in substructure complete as per drawing and MORTH technical specifications 2013 clause 1500,1700 & 2100 including the cost of form work, curing complete in dirt wall and bed block of abutment/pier and including entire carriage of material in all leads, lifts and heights as per the entire satisfaction and direction of Engineer-in-charge. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST, Labour cess or other taxes imposed by the Government.

Supplying, fitting and placing HYSD bar reinforcement made of TATA SAIL, TISCO. in foundation & substructure of bridge complete as per drawings and technical specifications MORTH 2014 clause 1600 & 2200 including the cost of bending, binding, cutting and placing in postion of bars complete and including the cost of winding wire including entire carriage of material in all leads, lifts as per the entire satisfaction and direction of Engineer-in-charge. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST, Labour cess or other taxes imposed by the Government.

Back filling behind abutment , wing walls and return walls complete as per drawings and technical specification MORTH 2013Clause 710.1.406 IRC 78 & 2200 with Granular Material and as per direction of Engineer-in-Charge including entire carriage of material in all leads, lifts as per the entire satisfaction and direction of Engineer-in-charge specfication. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Providing weep holes in brick masonry/stone masonry, plain/reinforced concrete abutment, wing walls, return walls with 110mm (One hundred ten millimeter) diameter AC Pipe made of implet/ supreme extending through the full width of structures with slope of 1(Vertical) : 20 (Horizontal) towards drawing face complete as per drawing and technical MORTH 2013 specifications clauses 706 and 2200 including entire carriage of material in all leads, lifts as per the entire satisfaction and direction of Engineer-in-charge specfication. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated concrete for plain/reinforced concrete in sub structures , drains and open foundation for all type of structures complete of plain cement concrete Grade M-15 (Fifteen) nominal mix 1:2.5:5 (One cement : three sand : six graded crushed stone aggregate) on approach slab including the cost of form work as per drawings and technical specification clause 802, 803, 1202 and 1203 as per direction of Engineer-in-Charge including entire carriage of material within all leads and lifts and other incidentals. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Providing and laying filter media with granular crushed aggregates as per specification to a thickness of not less than 600 mm (Six hundred millimetre) with smaller size towards the soil and bigger size towards the wall and providing over the entire surface behind abutment, wing wall, return wall to the full height, compacted to firm condition complete as per drawing and MORDtechnical specification Clause 1204 including entire carriage of materials within all leads lifts and other incidentals and per direction of Engineer-in-Charge. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Supplying, fitting and fixing in postion true to line and level POT-PTFE bearing consisting of a metal piston supported by a disc or unreinforced elastomer confined within a metal cylinder, sealing rings, dust seals, PTEF surface sliding againset stainless steel mating surface, completre to be of cast steel/ fabricated structural steel, metal and elstomer elements to be as per IRC ;83 part -I & part-II respectively and other parts conforming to BS: 5400 section 9.1 & 9.2 and clause 2006 of Morth 2013 specfication Clause 2000 and 2200 complete as per drawing and approved technical specfications. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Furnishing and Placing Reinforced/Prestressed RCC/PSC grade M-35 (Thirty five ) grade using graded /crushed stone aggregate miniumem cement contents not less than 422 (Four Hundred twenty two ) Killogramme design mix minimum in super-structure as per drawing and Technical MORTH specification Clause 1500,1600 and 1700 including the cost of form work and curing complete including entire carriage of material in all leads, lifts and heights as per the entire satisfaction and direction of Engineer-in-charge. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST, Labour Cess or other taxes imposed by the Government.

Supplying, fitting and placing HYSD Bars reinforcement made of TATA SAIL, TISCO in superstructure complete as per drawing and MORTH technical specifications clause1600 including the cost of bending, binding, cutting and placing in postion of bars complete and including the cost of winding wire including entire carriage of material in all leads, lifts as per the entire satisfaction 2013 and direction of Engineer-in-charge. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST, Labour cess or other taxes imposed by the Government.

Providing and laying reinforced Cement concrete M-30 (Thirty) Mechanically mixed and vibrated minimum cement contents not less than 407 ( Four hundred seven) Killogramme design mix minimum in Approach slab including reinforcement complete as per drawing and MORTH technical specifications 2013 clause 1500,1600,1700 including the cost of form work and curing complete and entire carriage of material in all leads, lifts as per the entire satisfaction and direction of Engineer-in-charge. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST,labour cess or other taxes imposed by the Government.

Providing and fixing of Reinforced Cement Concrete Crash Barrier Provision of an Reinforced cement concrete crash barrier at the edges of the road, approaches to bridge structures and medians, constructed with M-20(twenty) grade concrete with HYSD reinforcement conforming to IRC:21 and dowel bars 25 mm (twenty five millimetre)dia, 450 mm( four hundred fifty millimetre) long at expansion joints filled with pre-moulded asphalt filler board, keyed to the structure on which it is built and installed as per design given in the enclosure to MOST circular No. RW/NH - 33022/1/94-DO III dated 24 June 1994 as per dimensions in the approved drawing and at locations directed by the Engineer, all as specified. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST,labour cess or other taxes imposed by the Government.

Providing and fixing Drainage Spouts complete as per drawing and Technical specification of MORTH 2013 section 2705 as directed by the Engineer-in-Charge including the cost of Labour for febrication and for fixing in postion including entire carriage of material in all leads, lifts as per the entire satisfaction and direction of Engineer-in-charge. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST, Labour cess or other taxes imposed by the Government.

Providing external prestressing with high tensile steel wires/strands including drilling for passage of prestessing steel, all accessories for stressing and stressing operation and grouting complete as per drawing and Technical specification .The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST, Labour cess or other taxes imposed by the Government.

Providing and laying of a strip seal expansion joint catering to maximum horizontal movement upto 70 (Seventy) millimetres , complete as per approved drawings and standard specifications to be installed by the manufacturer / supplier or their authorised representative ensuring compliance to the manufacturer's instructions for installation and MORTH Specfication 2607 including the cost of form work and curing complete including entire carriage of material in all leads, lifts as per the entire satisfaction and direction of Engineer-in-charge. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Mastic Asphalt (Providing and laying 12 mm (twelve millimetre)thick mastic asphalt wearing course on top of deck slab excluding prime coat with paving grade bitumen meeting the requirements given in table 500-29 (five hundred to twenty nine), prepared by using mastic cooker and laid to required level and slope after cleaning the surface, including providing antiskid surface with bitumen precoated fine grained hard stone chipping of 9.5 mm (nine point five millimetre) nominal size at the rate of 0.005cum ( zero point per 10 sqm and at an approximate spacing of 10 cm center to center in both. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Providing concrete for plain/reinforced concrete mechanically mixed and vibrated in open foundation retaining walls, breast walls and like substructures etcetra complete as per drawings nominal mix 1:5:10 (One cement : five sand : Ten graded crushed stone aggregate) 40mm (Forty millimetre) nominal size including cost of form work and curing complete without plum as per MORD2014 specification 800 & 1200 complete in all respect including entire carriage of materials within all leads and lifts and other incidentals. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Providing weep holes in brick masonry / Stone masonry / plain/reinforced concrete in abutment retaining walls, breast walls and the like with 110 mm ( One hundred ten millimetre ) dia PVC pipe Finolex/ Supreme having pressure not less than 4.00 Kg/Cm² ( four kilogramme ) per centimetre square extending through the full width of the structure with slope of 1(V):20(H) ( one vertical : twenty horizontal ) towards drawing face complete as per drawing and technical specification MORD 2014 clause 614,709,1204.3.7 in all leads and lifts and carriage of material by all modes of transportation as per the direction of Engineer- in-chrage. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Back filling behind abutment , wing walls and return walls complete as per drawings and technical specification 2014 Clause 1204.3.8. with Granular Material and as per direction of Engineer-in-Charge including entire carriage of materials within all leads and lifts and other incidentals. The rates are inclusive of octroi, royality, malkana, toll tax, sale tax, GST or other taxes imposed by the Government.

Stone soling properly hand-packed filling interstices with spalls and consolidating with power road roller to the requested gradient and comber including spreading watering and rolling of binding materials moorum or earth etc. complete as per HP.PWD specification. 100 mm (hundred) millimetres spread thickness (finished work including materials and labour) upto all floor levels in all heights/ depth including entire carriage of material with in all leads lifts and technical specifications as per the direction by the Engineer-in-Charge and other incidentals. The rates are inclusive of octroi, royality, Malkana, toll tax, sale tax , GST or other taxes imposed by the Government.

Construction of un-reinforced, dowel jointed at expansion and construction joint only, plain cement concrete pavement, thickness as per design, over a prepared sub base, with 43 (forty three) grade cement or any other type as per Clause 1501.2.2 M30 (Grade), coarse and fine aggregates conforming to IS:383, maximum size of coarse aggregate not exceeding 25 mm, mixed in a concrete mixer of not less than 0.2 cum ( zero point two cubic metre)capacity and appropriate weigh batcher using approved mix design, laid in approved fixed side formwork (steel channel, laying and fixing of 125 ( one hundred twenty five) micron thick polythene film, wedges, steel plates including levelling the formwork as per drawing), spreading the concrete with shovels, rakes, compacted using needle, screed and plate vibrators and finished in continuous operation including provision of contraction and expansion, construction joints, applying debonding strips, primer, sealant, dowel bars, near approaches to bridge/culvert and construction joints, admixtures as approved, curing of concrete slabs for 14-days, using curing compound ( where specified ) and wa ter finishing to lines and grade as per drawing and Technical specification clause 1501 including hauling of material within all leads and lifts and other incidental charges and as per direction of Engineer-In-Charge. The rates are inclusive of octroi, royality, Malkana, toll tax, sale tax , GST or other taxes imposed by the Government.