Replacement of existing 02 Nos. of lifts having capacity 8/10 passengers, G+7 Floor Elevators (MRL Lift) SITC with 5 years Operation and 4 years Comprehensive Maintenance service Contract (After DLP) of 02 Nos. Passenger Elevator at C Block of Danapith office, Ahmedabad Municipal Coporation.

Name OF Work:-Replacement of existing 02 Nos. of lifts having capacity 8/10 passengers, G+7 Floor Elevators (MRL Lift) SITC with 5 years Operation and 4 years

Comprehensive Maintenance service Contract (After DLP) of 02 Nos. Passenger Elevator at C Block of Danapith office, Ahmedabad Municipal Coporation.

Sr. No. Description Unit Qty. Rate

(Excluding GST)

Supply, Installation, Commissioning and Testing of 8/10 passanger elevator(MRL Lift) as per R & B

S.O.R(category Premium) Having following Specifications:- G+7 Floor

Supply, Eracting, Commissioning and Testing the Passanger lift having following Main Faeture

[1] GEAR LESS LIFT DRIVE (MRL) comprising of High Starting torque Lift 3 phase 440 V A. C.

Permanent Magnet Synchronous motor of proper rating with high efficiency shall be used.[2] Micro

processor based / PLC, ACVVVF, vector control drive with encoder feedback closed loop system shall

be used for lift car and door operation which shall be full collective selective operation hall call

demand response, UP/DOWN hall stops, Main, Up/ Down Contactor with overload and phase

reversal relay and safety controls.

[3] Car with M S platform with bracings of adequate size and to sustain the impact load cabin +

passenger with safety factor of fire for steel and side panels of Stainless steel of sheet of grade

duty. Car ceiling will be S.S. finishes with aesthetic appearance with LED ceiling lights. Car flooring

shall be of s/s 304 chaker plate design sugeested of engineer in charge. of engineer in charge. Car

doors shall be of stainless steel grade 304, hairline finish with centre opening / telescopic automatic

doors. Car panel will also be S.S. 304 finished with emergency stop device, mechanical door safety

device, facility of auto/ attended mode. All car panel buttons and all floor switches must be with

brail language as per lift act.

[4] All landing doors must be fire rated for 2 hour shall be fully automatic centre opening/ telescopic

opening made of hairline finish steel grade of 304 with key holes and infrared curtains with

Unlocking facility from outside

[5] Appropriate battery operated emergency light in the car along with alarm switch shall be

provided. Also, Emergency Light & Fan should start immediately without any Time Delay as soon as

[6] Digital scrolling indicator system for up-down arrow along with floor position indicator shall be

provided inside the car and at all floors.

[7] Full height infra red curtain with multiple cross / crossing light beams shall be provided.

[8] Automatic Rescue Device (ARD) shall be provided accordingly of passenger capacity with Manual

Rescue Operation ( Manual Cranking Facility).

[9] Audio visual indication in the lift car showing over loading shall be provided such that doors kept

open till excess load is removed.

[10] Spring buffers/PU Buffers shall be provided.

[11] Car fan as per passenger capacity with automatic sleep timer shall be provided.

[12] Voice annunciator with suitable music shall be provided in lift car.

[13] Self diagnostics system for operational and safety parameters shall be provided in control

[14] Mechanical over speed governor with governor calibration as per actual site parameters and

submission of calibration certificate submission, door key holes in the floor doors, fireman switch

shall be provided.

[15] Lift machine hoisting arrangement in the lift machine room and monkey ladder for lift pit

should be provided by the lift agency, along with the other steel structure works, foundations for

the machine etc…

[16] In the hoist way fascia plate shall be provided without any extra cost, where ever required as /

if directed by engineer in charge.

[17] Permanent wiring with necessary safety devices like RCCB in all circuit, Over Voltage Under

Voltage protection and THD eliminator in circuit for lift machine room and lift well with proper

numbers of light points, with fixtures, exhaust fan and plug points shall be provided by the agency.

Only 3 phase Power Supply shall be made available by department in lift machine room. Necessary

Earthing as per Lift Act/Rules shall be arranged by Lift Agency.

[18] Any civil/ electrical works for additional and alteration in lift shaft and machine room related to

erection of lift shall be made by lift agency without any extra cost. (granite/marble fixing around all

landing door openings are not in lift agency’s scope.)

[19] Agency has to provide all working drawings and documents and liaison services for obtaining all

necessary permission from lift inspector and other authorities. [20] acrylic transparent

licence/display A4 size holder in lift car

[20A] As per statutory requirement of Govt. Of Gujarat lift & escalator act 2000, lift agency has to

1. Car top safety barricade

2. Push & talk communication system.

3. Fireman's switch operation at Ground Floor. 4.carrying out

third party lift inspection during/after lift erection and provide report by third party authorized by

concern licensing authority 5.agency has to provide third party insurance upto completion of free

maintenance period and submit the document for the same.

[21] Car Panel Operating Buttons with floor position indicator/buttons must be of Auto Glow type

clearly visible when view from inside cabin.

[22] For Physically Handicapped person Full Length Handrails of hairline finish steel grade of

should be provided at appropriate height on the Rear & Side Wall Panels in Lift Car.

(B) SPECIAL FEATURES DESCRIPTION OF LIFTS for PREMIUM category

1. Advanced control system dual 64 bit embedded microprocessor with CANBUS Serial

Communication mode including Regenerative power efficient operation,on site programming

facility, Anti nuisance, Pte-opening, BMS/RMS with necessary online real time monitoring system

having necessary connectivity for remote monitoring & other suitable supporting hardware &

software devices to fulfil the purpose.

2. Floor Indication LCD Display with call registration & brail mark with arrival gong and hall lantern &

TFT Screen in the car with MP3 Voice Announcer.

Name OF Work:-Replacement of existing 02 Nos. of lifts having capacity 8/10 passengers, G+7 Floor Elevators (MRL Lift) SITC with 5 years Operation and 4 years

Comprehensive Maintenance service Contract (After DLP) of 02 Nos. Passenger Elevator at C Block of Danapith office, Ahmedabad Municipal Coporation.

Sr. No. Description Unit Qty. Rate

(Excluding GST)

3. CAR Panel should be Scratch resistive SS Moonrock finish / Hair Line / Honeycomb for car and all

Doors, All landing doors must have fire rating up to 2 hours and car door must have multi-level

crisscross beam door protection.

4. To & fro communication system & wiring (i.e. car , control room & guard room ) and Each elevator

are equipped with remote monitoring system.agency has to provide mobile app and user id and

password for monitoring

1.1 8 / 10 Passengers, Ground plus 7 upper floor with Rated Speed of 1.0 m/sec.,

(C) With General PLUS ADDITIONAL SPECIAL FEATURES attached herewith. Prem. Cat. No 2 1959382

SUB TOTAL of Passangeres Elevator

1.2 ANNUAL COMPREHENSIVE MAINTENANCE WORKS OF PASSENGER Elevator 20 Nos.

Comprehensive Maintenance of the lift for ONE Year after Completion of DLP

1.3 DLP-1 Year Free Job

1 st year Job 1 137156.74

2 nd Year Job 1 156750.56

3rd Year Job 1 176344.38

4th Year Job 1 176344.38

Operators for the Lifts

1.5 Rs.15353.24/- per person per Lift, so for two Lift = Rs. 30706.48/- per month month 60 30706.48

1.5 BuyBack Items no 2 391876.4

Sub Total(C)=(A)-(B)