Laying of 33 KV line and Supply, Installation and Commissioning of 33 KV Ring Main Unit at Badripur Road of Ajabpur Section under EDSD, Araghar under EDD, Raipur.

SCHEDULE OF QUANTITY AND RATE FOR LAYING OF 33 KV LINE AND SUPPLY, INSTALLATION AND COMMISSIONING OF 33 KV RING MAIN UNIT AT BADRIPUR ROAD OF AJABPUR SECTION UNDER EDSD, ARAGHAR UNDER EDD, RAIPUR AGAINST E-TENDER SPECIFICATION NO.48/EDCRDDUN/2025-26

Name of The Bidder's Firm:

Part [A] (Supply Portion)

Holding Clamp for ST Pole SP-55 with N&B

Nut & Bolts

PP & Clamp for ST Pole SP-55 with N&B

33 KV Isolator Clamp for Panther N&B

33 KV HS Cable END Termination Kit 3x400mm2 Outdoor

33 KV XLPE HS Jointing Kit 3x400mm2 straight

33 KV Indoor Touch Termination Kit for RMU

33KV Ring Main Unit

Al. Crimping Type Lugs 400 sqmm.

MS Flat 40x6 mm

Part [B] (Labour Portion)

Cartage of ST Pole SP-55 from store centre to nearest road site with loading, unloading at both points. (Loading, unloading plus carriage per pole) (0 to 20 km).

Cartage of other material by vehicle from store centre to nearest road site including loading and unloading at both ends. (0 to 20 km).

Head load Cartage of ST Pole SP-55 from road side to construction site (rates are per Pole / Km. including loading/unloading at both points) (0 to 1 km).

Head load cartage of small material by vehicle from store centre to nearest road site including loading and unloading at both ends. (0 to 1 km).

Making Cable Trench

Making Special type separate earthing for neutral /body of Power transformer by digging 3x4x12 feet deep pit at corner of Swithchyard with duly provided 1 No. GI/Copper plate of size 18"x18"x½" jointing them with 6" long bolt duly coverod with layer of softcoal 60 Kg and salt 20 Kg. (Total 80 Kg.) , The earth plate shall be connected with 35x6 mm Gl tftrip and Gl strip shall be laid upto the neutral and T/F body separately (Including supply of steel).

Fabrication of M.S. Channel Angle iron after cutting in required sizes with drilling of holes upto good finish for top channel, bracing and special type bracket etc as per RESPO sehedule and local approved drawing.

Fixing of GI Pipe

Fixing of RCC Cable Route Marker

Excavation of earth for pole pit of size 0.9X0.6X1/6 of full length of pole for erection of pole in all type of soil including proper dressing of sides and ramming of bottom including getting out the excavated soil and disposal of surplus excavated soil as directed complete work.

Erection of SP-55 Single support pole in proper level and alignment alongwith fixing of all accessories.

Erection of SP-55 double support pole in proper level and alignment along with fixing of all accessories like top channel, X bracings, & clamps as per RESPO manual

Grouting of pole in size 0.45x4.45x1/9 of the support in CC ration 1:4:8(1 cement:4 graded stone20 mm niminal size: 8 coarse sand) b lock including cost of cement, sand and stone ballast back filling of soil and boulders in pit and ramming and proper alignment, lev elling as per RESPO cnstruction manual

Muffing of poles size 0.45cmX0.60cm radious with CC 1:3:6 (1cement:3coarse sand:6 graded stone 10mm nominal size) block size 45cm height from ground level including cost of cement, stoneand sand etc.

Laying of Underground 33 KV Cable Trenchless

Making of Seciton Pole

Fixing of 33 KV XLPE Jointing Kit

Fixing of 33 KV XLPE Straight Through

Road Cutting and Repairing

Fixing of 33 KV Isolator Vertical Type

Fixing of Channel, Angle on Pole

Installation of 3 Way RMU and other work

Making Loop of 33 KV XLPE Cable

Laying of 33 KV Cable in HDPE Pipe HDD Mach.

Supply and Laying of HDPE Pipe in open cut

Fencing of RMU with all accessories

Fixing of 33 KV RMU Bushing

Total - Part [B]

TOTAL [Part-(A) + Part (B)]

Place