Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation (Third Attempt)

No Item Qty Unit Rate Amount

1 Excavation for foundation upto 1.5 m depth including sorting out 6386.42 cum 657.36

and stacking of useful materials and disposing off the excavated

stuff upto 50 Meter lead.(E) Hard Rock

[SOR Ref:-R&B/state/SOR/24-25/Item Code.04001E/Page No.

2 Excavation for foundation upto 1.5 m depth including sorting out 178.11 cum 279.81

and stacking of useful materials and disposing off the excavated

stuff upto 50 Meter lead.(C) Hard Murrum

[SOR Ref:-R&B/state/SOR/24-25/Item Code.04001C/Page No.

3 Providing and laying cement concrete 1:2:4 (1- Cement : 2- 1465.07 cum 3,842.91

Coarse sand : 4- graded stone aggregates 20 mm nominal size)

and curing complete excluding cost of formwork in (A)

Foundation and Plinth

[SOR Ref:-R&B/state/SOR/24-25/Item Code.05010AA/Page No.

4 Providing formwork of ordinary timber planking so as to give a 895.87 Sqm 188.98

rough finish including centering shuttering strutting and propping

etc. Height of propping and centering below supporting floor to

ceiling not exceeding 4 M. and removal of the same for in situ

reinforced concrete and plain concrete work in. (A) Foundations

Footings Bases of Columns etc. and Mass concrete.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.09001AA/Page No.

5 Providing and laying controlled cement concrete M.250 and 224.83 cum 4,429.65

curing complete excluding the cost of formwork and

reinforcement for reinforced concrete work in (A) Foundations,

footings, Base of columns and Mass concrete.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.05025AA/Page No.

6 Filling available excavated earth (excluding rock) in trenches. 6218 cum 137.47

plinth, sides of foundations etc. in layers not exceeding 20 cm. in

depth consolidating each disposite layer by ramming and

[SOR Ref:-R&B/state/SOR/24-25/Item Code.04006/Page No. 69]

7 Providing and laying controlled cement concrete M.250 and 65.55 cum 4,818.63

curing complete excluding the cost of formwork and

reinforcement for reinforced concrete work in (D) Columns,

Pillars posts and struts, upto floor two level.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.05025DA/Page No.

8 Providing formwork of ordinary timber planking so as to give a 527.04 Sqm 330.72

rough finish including centering shuttering strutting and propping

etc. height of propping and centering below supporting floor to

ceiling not exceeding 4 M. and removal of the same for in situ

reinforced concrete and plain concrete work in. (G) Columns

PillarsPosts and struts. (1) Square Rectangular Polygonal in plan.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.09001G1A/Page

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

9 Providing and laying controlled cement concrete M.250 and 2567.32 cum 4,713.23

curing complete excluding the cost of formwork and

reinforcement for reinforced concrete work in (C)

Slabs,landing,shelves,Balconies, Lintels, Beams, Girders and

Cantilever upto floor two level.

[SOR Ref:- R&B/state/SOR/24-25/Item Code.05025CA/Page No.

10 Providing formwork of ordinary timber planking so as to give a 490.61 Sqm 215.23

rough finish including centering shuttering strutting and propping

etc. height of propping and centering below supporting floor to

ceiling not exceeding 4 M. and removal of the same for in situ

reinforced concrete and plain concrete work in. (H) (1) Sides and

soffits of Beams Beam Haunchings cantilevers Girders

Bressumers and Lintels not exceeding 1 M. in Depth.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.09001H1A/Page

11 Filling in foundation and plinth with murrum or selected soil in 1713.01 cum 307.41

layers of 20cm. thickness including watering, ramming and

consolidating etc. complete.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.04008A/Page No.

12 Filling in foundation and plinth with brick Bats Chhara in layers 1687.41 cum 629.48

of 20cm. thickness including watering, remming and

consolidating etc. complete.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.04009A/Page No.

13 Providing formwork of ordinary timber planking so as to give a 77.78 Sqm 276.48

rough finish including centering shuttering strutting and propping

etc. Height of propping and centering below supporting floor to

ceiling not exceeding 4 M. and removal of the same for in situ

reinforced concrete and plain concrete work in. (B) Flat surfaces

such as soffits of supspened floors slabs Landings and the like.

(1) Floors etc. upto 200 mm in thickness.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.09001B1A/Page

14 Providing TMT Bar FE 500D reinforcement for R.C.C. work 277892.56 kg 87.45

including bending, binding and placing in position complete upto

floor two level

Providing fusion bonded Epoxy coating not less than 175 micron

thickness and up to 300 micron to reinforcement bars as per IS-

13620-1993/ASTM-775 M including testing of coating at plant

and all taxes (A) 10mm to 16mm dia bar

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

15 Providing and fixing window having extruded aluminum Colour 193.71 sqm 2,140.33

anodized section frame main outer size 127mm x 38.10mm x

1.35mm @wt. 1.384kg/m, horizontal Four track member size

122.20mm x 31.75mm x 1.10mm@ wt 1.205 kg/m, vertical

member of size 122.20mm x 31.75mm x 1.50mm @1.398 kg/mt

with sliding shutters of horizontal member size 40mm x 18mm x

1.29mm@ 0.456kg/mt ,vertical member of size 40mm x 18mm x

1.29mm @ 0.456 kg/mt with 5 mm thick transparent bronze

colour tinted float glass with powder coated aluminum fittings

and fixtures and transparent silicon sealant glass fixing to frame

as per details etc complete for window.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.11026/Page

16 Providing and fixing rolling shutters of approved make made of 82.8 sqm 3,784.54

80 mm wide M.S. laths inter locked together through their entire

length and jointed together at the ends by end locks mounted on

specially designed pipe shaft with bracket plates, guide channels

and arrangements for inside and outside locking with push-pull

operation complete but excluding the cost of hood cover and

spring. (B) Shutters having width above 3.5 M.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.11006B/Page

17 White Stone Bela mesonry block in course in superstructure with 142.49 cum 6,524.01

stone of approved quality in Lime Mortar 1:6 (1- Cement : 6-

course sand) including packing the joints etc. complete.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.07011A/Page

18 Providing 15 mm thick cement plaster by using Ready Mix 802.43 sqm 171.84

Mortar for plaster in single coat on rough (similar) side of single

or half brick walls for interior plastering upto floor two level and

finished even and smooth in Cement mortar 1:4 (1 Cement :

[SOR Ref:-R&B/state/SOR/24-25/Item Code.17022/Page No.

19 Providing 20 mm thick cement plaster by using Ready Mix 1254.023358 sqm 233.98

Mortar for plaster in single coat on single or half brick walls for

interior plastering upto floor two level and finished even and

smooth in Cement mortar 1:4 (1 Cement : 4 sand)

[SOR Ref:-R&B/state/SOR/24-25/Item Code.17021/Page No.

20 Wall painting (two coats) with plastic emulsion paint of approved 2843 sqm 132.00

brand and manufacture on undecorated wall surface to give an

even shade including throughly brushing the surface free from

mortar droppings and other foreign matter and sand papered

Extra over item for every subsequent coat of wall painting with

plastic emulsion pain of approved brand.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.18031+18032/Page

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

21 Steel work, welded in built up sections framed work including 1573.81 Quintal 9,108.48

cutting, hoisting, fixing in position and applying a priming coat of

red lead paint. (A)In beams and joists, channels angles Tees, flats,

with connecting plates or angle cleats as in main and cross beams.

Hip and jack rafters, purlins conneted to common rafters and the

[SOR Ref:-R&B/state/SOR/24-25/Item Code.11002AA/Page No.

22 Providing corrugated G.I. sheet of class-3 roofing fixed with 8755.07 sqm 734.19

glavanished iron J or L Hooks, Bolts and nuts 8mm diameter with

bitumen and G.I. limpet washer or G.I. limpet washer. filled with

white lead complete excluding the cost of purlins, Rafters and

Trusses.(1) 0.80 mm thick sheet.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.15001A/Page No.

23 Carring out plinth treatment to post construction / existing 7254.415 sqm 124.35

structure by spraying chemical solution for termite control

treatment including labour and material consistment with I.S.I

specification. Using Chlordene and Chiorpurfiles 20 EC. As Per

6131_paret-II Consentration Weight one percent is recommended

i.e one litre 20 EC chemical emulsion with 19 liter give 1 %

concrentration inclusive of one litre chemical emulsion appication

at the rate of 5 Litre chemical / Sqm of surface is recommended as

[SOR Ref:-R&B/state/SOR/24-25/Item Code.22007/Page No.

24 Providing 20 mm thick cement plaster by using Ready Mix 7990.42 sqm 251.08

Mortar for plaster in single coat on single or half brick walls for

interior plastering upto floor two level and finished even and

smooth in Cement mortar 1:3 (1 Cement : 3 sand)

[SOR Ref:-R&B/state/SOR/24-25/Item Code.17024/Page No.

25 Excavation for foundation for depth from 1.5 m to 3.0 m 140 cum 682.27

including sorting out and stacking of useful materials and

disposing off the excavated stuff upto 50 Meter lead.(E) Hard

[SOR Ref:-R&B/state/SOR/24-25/Item Code.04002E/Page No.

26 Providing formwork of ordinary timber planking so as to give a 6.48 sqm 299.22

rough finish including centering shuttering strutting and propping

etc. Height of propping and centering below supporting floor to

ceiling not exceeding 4 M. and removal of the same for in situ

reinforced concrete and plain concrete work in. (B) Flat surfaces

such as soffits of suspended floor roof slabs Landings and the

like. (2) Floors etc. above 200mm in thickness.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.09001B2A/Page

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

27 Providing formwork of ordinary timber planking so as to give a 168 sqm 258.97

rough finish including centering shuttering strutting and propping

etc. height of propping and centering below supporting floor to

ceiling not exceeding 4 M. and removal of the same for in situ

reinforced concrete and plain concrete work in. (C) Vertical

surface such as walls (any thickness) partitions and the like

including attached buttresses & string course & the like.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.09001CA/Page No.

28 Providing and fixing C.I. Manhole cover 0.60 M. x 0.45M. size 1 Each 958.17

having weight not less than 35Kg.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.23038/Page No.

29 Providing and laying damp proof course 25mm thick cement 28 sqm 337.30

concrete 1:2:4 (1-Cement : 2 coarse sand : 4 stone aggregate

mm nominal size) and curing complete

[SOR Ref:-R&B/state/SOR/24-25/Item Code.05021A/Page No.

30 Providing and fixing 35 mm thick shutters for Doors, windows 22.89 sqm 5,533.68

and clerestory windows including Indian teak wood frames 12 cm

x 7 cm. size including anodized alluminium fixtures and

fastenings including primer coat of approved quality and two

coats of oil painting etc, complete. (ii) Fully Panelled.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.10032B/Page

31 White Stone Bela mesonry block in course in superstructure with 36.18 cum 6,524.01

stone of approved quality in Lime Mortar 1:6 (1- Cement : 6-

course sand) including packing the joints etc. complete.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.07011A/Page

32 Providing and laying Ceramic tiles 6mm thick in flooring treads 133.32 sqm 1,017.30

of steps and landing laid on a bed of 12mm thick cement mortar

1:3 (1-cement : 3-coarse sand ) finishing with flush pointing in

[SOR Ref:-R&B/state/SOR/24-25/Item Code.14008BA/Page No.

33 Providing and laying broken chine mosaic flooring for terrace 130.75 sqm 779.70

using 12 mm to 20 mm broken pieces of glazed tiles to be laid

over cement mortar 1:3 to plain or slope and to be tempered to

bring mortar creme out upto surface using white cement including

rounding off junctions and extending them upto 15 cm along the

wall,clearing with water and oxalic acid etc. as directed.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.14035/Page No.

34 Providing and laying damp proof course 25mm thick cement 9.32 sqm 337.30

concrete 1:2:4 (1-Cement : 2 coarse sand : 4 stone aggregate

mm nominal size) and curing complete

[SOR Ref:-R&B/state/SOR/24-25/Item Code.05021A/Page No.

35 R.C.C. post for barbed wire 346 Nos 250.00

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

36 Providing and fixing 1.20 Metre high fencing with 2.0 Metre long 925.76 Rmt 391.93

M.S. Angle posts 40mm x 40 mm x6 mm and oil painting 3 coats

fixed at 2.5 Mt,C/c. with five Horizontan lines and two diagonals

of galvanised steel barbed wire weighting 9.38 Kg. per

Metre, strained and fixed to posts with G.I,staples including

fixing the postsin ground with 0.5 M x 0.5.M x 0.5 M. block in

C.C1:5:10 etc complete.UADD SOR 2021 : Vol 2,Cha.-10,Item

No.:-10.22.1,Page No.119

[SOR Ref:-R&B/State/SOR/21-25/Item Code.22001/Page No.

37 Providing and fixing M.S. grills of required pattern to wooden 343 kg 170.78

frames of windows etc. with M.S. flats at required spacings and

frame alround, square or round bars with round headed bolts and

nuts or by screws. (B) ORNAMENTAL GRILL

[SOR Ref:-R&B/state/SOR/24-25/Item Code.10025BA/Page No.

38 Providing formwork of ordinary timber planking so as to give a 2.64 sqm 330.72

rough finish including centering shuttering strutting and propping

etc. height of propping and centering below supporting floor to

ceiling not exceeding 4 M. and removal of the same for in situ

reinforced concrete and plain concrete work in. (G) Columns

PillarsPosts and struts. (1) Square Rectangular Polygonal in plan.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.09001G1A/Page

39 Providing formwork of ordinary timber planking so as to give a 109.25 sqm 258.97

rough finish including centering shuttering strutting and propping

etc. height of propping and centering below supporting floor to

ceiling not exceeding 4 M. and removal of the same for in situ

reinforced concrete and plain concrete work in. (C) Vertical

surface such as walls (any thickness) partitions and the like

including attached buttresses & string course & the like.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.09001CA/Page No.

40 Finishing wall with water proofing cement paint of on wall 1.56 Sqm 63.69

surfaces (Two coats) to give an approved brand and manufacture

and of required shape even shade after thoroughly brushing the

surface to remove all dirt and remains of loose powered materials.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.18027/Page No.

41 Providing formwork of ordinary timber planking so as to give a 2.08 sqm 276.48

rough finish including centering shuttering strutting and propping

etc. Height of propping and centering below supporting floor to

ceiling not exceeding 4 M. and removal of the same for in situ

reinforced concrete and plain concrete work in. (B) Flat surfaces

such as soffits of supspened floors slabs Landings and the like.

(1) Floors etc. upto 200 mm in thickness.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.09001B1A/Page

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

42 Providing and fixing Urinal of approved quality including 1 Nos 1,706.08

connection with trap and with integral longitudinal flush pipe.(A)

Squating plate pattern white earthenware 550mm x 300mm.

[SOR Ref:-R&B/state/SOR/24-25/Item Code.23034/Page

43 Providing and fixing Kitchen sink with C.I. or M.S. brackets, 2 Nos 2,326.66

painted white including cutting holes in walls and making good

the same but excluding fittings. (C) Vitreous China Sink.(i)

600mm x 450mm x 150mm size

[SOR Ref:-R&B/state/SOR/24-25/Item Code.23019/Page

44 Providing and fixing water closet squatting Pan (Indian type 4 Nos 1,034.15

W.C. Pan) size 580mm (Earthwork, bed concrete, foot reste and

trap to be measured and paid for separately) (A) Vitreous

China.(I) Long pattern = White colour

[SOR Ref:-R&B/state/SOR/24-25/Item Code.23009/Page

45 Drilling of 250 mm dia. bore well in all strata including dual over 152 Mtr 1,258.00

burden strata by Combination DR / DTH rig including lowering

200 mm dia MS ERW pipes in bore hole as suggested by

Hydrologist (Except Surendranagar district)

GWSSB Mech. SOR 22-23 Sec.A, It.3.5 Pg.3

46 Manufacture, supply and delivery of ISI marked ERW M.S. pipes 152 Mtr 2,407.00

conforming to IS: 4270/2001 with latest amendment Rates are

exclusive of GST

a) 200 mm dia ( Min 6.00 mm thick)

GWSSB Mech. SOR 22-23 Sec.B, It.7 Pg.18

47 Conducting pumping test of 200 / 250 mm dia. DR tube well by 1 Job 36,607.00

submersible pump of adquate capacity using DG set of required

rating including providing all required tools / tackles etc. as

mentioned below for all districts. For 1st 24 hours.(31 to 70HP)

GWSSB Mech. SOR 22-23 Sec.B, It.7B Pg.7

48 Providing and supplying Single phase Borewell sub pump motor 1 Nos 21,313.00

set MOC: Casing: CI-FG260, Impeller : Bronze & Shaft : SS:410

Category Q 2.5, 40 LPM, 180 m Head, 4 HP

GWSSB SOR22-23 ELEC- MECH , SEC E Item 6, Pg.

49 Manufacture, Supply and Delivery of 80 mm Nominal dia UPVC 152 Mt 399.66

Column Pipes including PVC Socket (Coupler), Density of Pipe

1.38 to 1.43 Gm per Cm3 OD : 87.5 TO 88.2MM, Wall

Thickness End : 9.8mm to 11.9mm, Berral : 7.3mm to 9.0mm,

GWSSB SOR22-23 ELEC- MECH , SEC B Item 16A, Pg.

50 PVC insulated flat submersible cable as per detailed technical 152 Mt 194.00

specifications of R/C of GWSSB conforming to IS 694, IEC

GWSSB SOR22-23 ELEC- MECH , SEC E Item 3.1 (e), Pg.

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

51 Manufacture, Supply and Delivery of 80 mm size CI Pipe 1 Set 979.32

Adaptor and Pump Adaptor forUPVC column Pipes.

GWSSB SOR22-23 ELEC- MECH , SEC B Item 16A.6, Pg.

52 LT Power Capacitor 2 KVAR 285.00

Supply & erecting heavy duty APP type capacitor unit, vacuum

impregnated with non-PCB / non toxic oil, internally delta

connected with built in

internal fuses complete with discharge resistances & terminal

cover, rated for 440 V AC, 3 Phase, 50Hz as per IS - 13585 Part-

GWSSB SOR22-23 ELEC- MECH , SEC E Item 34.1, Pg.

53 Supplying & erecting funnel type earthing having earth plate of 1 Nos 2,700.00

following size burred in specifically prepared earth pit 3 mtr.

below ground with 40 kg. charcoal and salt with alternate layers

of charcoal & salt, 20mm.dia. G.I. pipe with Funnel with a wire

mesh for watering & bricks masonry block, C.I. Cover complete

as per para 7.3 of IS 3043 with necessary length of double

Galvanised Iron / copper earth wire No 6 SWG bolted with lug to

the plate and covered in 12 mm dia. G.I. pipe 2.5 mtr long

complete connected to the nearest switch gear with end socket as

per direction & duly tested by earth tester confirming to IS (As

per drawing) with following specification

(A) With 30 x 30 x 0.35 cms: C.I. earth plate

GWSSB SOR2022-2023 ELEC- MECH , page 31 SEC D Item

should be taken from Electrical SOR 2021/2022 of R & B

[R&B SOR 2021-22 Electrical, 3.14.12 Pg. 92]

54 Lowering / Lifting of 3 phase submersible pump set with MS / GI 1 Job 2,800.00

column pipe into bore well inculding checking of therads of each

pipe with coupling / welding & jointing cable with fuse unit box /

control panel board including fitting accessories by means of

mechanised derrick / chain pulley block including satisfactory

(b) Above 150 to 300 M depth

[GWSSB SOR22-23 ELEC- MECH , SEC E Item 50.2-b Pg.

55 Providing dust and vermin proof Mild Steel Cabin having two 1 Unit 20,323.80

compartment one for panel board and other for GEB meter and

fuse unit with required locking arrangement , minimum degree of

protection IP 52 as per IS 2147 fabricated from CRCA sheer steel

minimum thickness for base frame/channel/gland plates for 3 mm

for load bearing members ,1.6 mm for ineternal members

including cutting,bending,drilling,welding, riveting with ineternal

partitions.The sheet steel enclosure shall be powder coated as per

applicable standard with shade as required with finish thickness

of paint film not less than 80 microns.The Cabin have following

GWSSB SOR22-23 ELEC- MECH , SEC B Item 12-2 Pg.

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

56 DOL / Star Delta starter suitable for local & remote pump control 1 Unit 8,383.00

application consisting of MPCB, overload relay and contactors as

per Type II coordination including digital voltmeter, analogue

ammeter with selector switch, run hour meter, required protective

relays & control accessories. D. O. L. up to 7.5 HP

GWSSB SOR22-23 ELEC- MECH , SEC E Item 2, Pg.

57 Supplying, erecting, testing, commissioning approved make M.S. 2 Each 1,25,566.23

Polygonal High Mast Pole having following general

(a) Polygonal Section fabricated from M.S. Plate confirms BSEN

10025 & Hot deep galvanized minimum 65/86 micron (as per IS

2629 /1985) Lantern carriage with ring and rubber lines for

erection of luminaries of suitable site.

(b) Maximum telescopic section not more than four

(c) Double drum gear pipe motorized winch with 6mm dia S.S.

Rod (For 16 mtr and above size)

(d) Approved make L.E.D. aviation light = 1 No. Lightening

arrestor = 1 No. with necessary wiring of 2.5 sq.mm 5 core ISI

copper cable Unarmoured.

(e) Bottom most section suitable for mounting reversible motor

58 Supplying and erecting LED street light / Flood light fittings with 12 Each 10,646.41

High power White LEDs wattage of 3 Watt and above assembled

on single MCPCB, efficiency more than 130 lm/w and corrosion

free High pressure die cast aluminum housing with smooth finish

powder coated and heat sink extruded aluminium with diffuser

and Polycarbonate optics/ lenses, with toughened glass with

company mark/name engraved or embossed 160 to 270 V,Power

Factor more than 0.95, THD < 10 %, CCT 3000 K to

59 Supplying and erecting LED Solar street lights with High power 35 Each 25,635.82

White LEDs wattage of 1Watt and above assembled on single

MCPCB, efficiency more than 130 lm/w and corrosion free High

pressure die cast aluminum housing with smooth finish powder

coated and heat sink extruded aluminium with diffuser and

Polycarbonate optics/ lenses with company mark/name engraved

with 36 hours battery backup & MPPT 24V,7.5 A charge

controller with 12 hours automatic switch on/off with wind speed

resistance 44 m/s as per IEC

60 Lighting Arrestor 10 Nos 9,323.00

SITC of Vertical Air Termination Solid aluminium with Base-

mm dia and 1000 mm long. Air Termination Base tested for

conditioning, Ageing Test & Lightning impulse current withstand

test: 100 kA of 10/350µs waveform in an accredited Third party

laboratory as per 6.3 & 6.4 of IEC 62561-1 2017 protocol with

MAST 34mm dia 3000 mm long- Cold Galvanized

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

61 Providing & erecting capacitor duty contactor 3 phase, 415 V 3 Nos 9,115.00

with proper connection for following rating:

Suggested step configuration (three-phase, 415 V, 50 Hz)

170 kVAr total (approx. from 300 kW, PF 0.80 → 0.98).

Recommended step set (simple, common sizes):

3 × 50 kVAr = 150 kVAr

2 × 10 kVAr = 20 kVAr

Total = 170 kVAr

62 Providing & erecting capacitor duty contactor 3 phase, 415 V 2 Nos 1,802.00

with proper connection for following rating:

Suggested step configuration (three-phase, 415 V, 50 Hz)

170 kVAr total (approx. from 300 kW, PF 0.80 → 0.98).

Recommended step set (simple, common sizes):

3 × 50 kVAr = 150 kVAr

2 × 10 kVAr = 20 kVAr

Total = 170 kVAr

63 Design, Supplying, installing, testing of factory fabricated ready 1 Nos 5,74,578.00

made Three phase APFC Panel Cubical Panel fabrication should

be type tested as per IEC 61921, 61439:1&2 Capacitor Duty

Contactor for switching as per following Steps Incomer Switch of

MCCB type Icu=Ics=50KA at 400/440 Volts, with OC, SC,

internal earth fault protection Incomer Switch of MCCB type

Icu=Ics=50KA at 400/440 Volts, with OC, SC, internal earth

fault protection,Copper tinned insulated Busbar,Cubical panel

should be indoor type with IP 43 and IK 10,Metalized

polypropylene film tye3-phase 550Volt Capacitor,De tuning

Reactor for each capacitor,Panel having Short Circuit and

Overload protection,Each step Capacitor having suitable MCB

with Sc, OL, internal earth fault relay,Each stage having Stage

Contactor (Capacitor load rating),PF regulator master controller

having suitable steps with LCD display, Rs 485 Communication

port, Indication LED Lamps for main incomer and ON-OFF for

each capacitor bank,MS Chanel for Floor mounting, Cable entry

as per site situation,Cooling fans for panel

(f)200KVAR (Main Panel)

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

64 Design, Supplying, installing, testing of factory fabricated ready 2 Nos 2,86,018.00

made Three phase APFC Panel Cubical Panel fabrication should

be type tested as per IEC 61921, 61439:1&2 Capacitor Duty

Contactor for switching as per following Steps Incomer Switch of

MCCB type Icu=Ics=50KA at 400/440 Volts, with OC, SC,

internal earth fault protection Incomer Switch of MCCB type

Icu=Ics=50KA at 400/440 Volts, with OC, SC, internal earth

fault protection,Copper tinned insulated Busbar,Cubical panel

should be indoor type with IP 43 and IK 10,Metalized

polypropylene film tye3-phase 550Volt Capacitor,De tuning

Reactor for each capacitor,Panel having Short Circuit and

Overload protection,Each step Capacitor having suitable MCB

with Sc, OL, internal earth fault relay,Each stage having Stage

Contactor (Capacitor load rating),PF regulator master controller

having suitable steps with LCD display, Rs 485 Communication

port, Indication LED Lamps for main incomer and ON-OFF for

each capacitor bank,MS Chanel for Floor mounting, Cable entry

as per site situation,Cooling fans for panel

(C)100KVAR (2 Screen)

65 Design, Supplying, installing, testing of factory fabricated ready 2 Nos 2,16,103.00

made Three phase APFC Panel Cubical Panel fabrication should

be type tested as per IEC 61921, 61439:1&2 Capacitor Duty

Contactor for switching as per following Steps Incomer Switch of

MCCB type Icu=Ics=50KA at 400/440 Volts, with OC, SC,

internal earth fault protection Incomer Switch of MCCB type

Icu=Ics=50KA at 400/440 Volts, with OC, SC, internal earth

fault protection,Copper tinned insulated Busbar,Cubical panel

should be indoor type with IP 43 and IK 10,Metalized

polypropylene film tye3-phase 550Volt Capacitor,De tuning

Reactor for each capacitor,Panel having Short Circuit and

Overload protection,Each step Capacitor having suitable MCB

with Sc, OL, internal earth fault relay,Each stage having Stage

Contactor (Capacitor load rating),PF regulator master controller

having suitable steps with LCD display, Rs 485 Communication

port, Indication LED Lamps for main incomer and ON-OFF for

each capacitor bank,MS Chanel for Floor mounting, Cable entry

as per site situation,Cooling fans for panel

(B)75KVAR (1 Dry Waste Plant & 1 Wet Waste Plant)

66 For Site Outside Electrification 1000 Meter 1,527.00

Providing and erecting ISI Marked 3core 120 Sq.mm XLPE

insulated 11 KV armoured cable Aluminium conductor IS-7098

to be laid on wall with clamps or in provided cable trench / pipe

approved manner as directed.

67 For Inside Wiring 1000 Meter 318.00

Providing and erecting XLPE(IS:7098)(I)-88 ISI armoured cable

multistrand Aluminium conductor for 1.1 KV. to be laid on wall

with necessary clamps or in existing trench / pipe of following

size of cables.

(I) 3 core 70 Sq. mm

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

68 For Inside Wiring 2000 Meter 189.00

Providing and erecting XLPE(IS:7098)(I)-88 ISI armoured cable

multistrand Aluminium conductor for 1.1 KV. to be laid on wall

with necessary clamps or in existing trench / pipe of following

size of cables.

(G) 3 core 35 Sq. mm

69 For Inside Wiring 3500 Meter 106.00

Providing and erecting XLPE(IS:7098)(I)-88 ISI armoured cable

multistrand Aluminium conductor for 1.1 KV. to be laid on wall

with necessary clamps or in existing trench / pipe of following

size of cables.

(C) 3 core 6 Sq. mm

70 Point wiring for independent PLUG with following size mains 150 Nos 585.00

earth wire of 1.5 sq.mm (green) both are of ISI marked 1.1 KV

grade FRLS PVC insulated multi strand copper wires upto 10 mt

length, in following below of pipe erected complete with ISI

marked 3 / 5 Pin socket and tissino type switch erected with earth

continuity connection erected on Metal / PVC/Wooden box

covered with 3 mm thick PC(Polycarbonate) / Acrylic/Laminated

(b) with 16 swg(1.6 mm thick) HGS metal conduit pipe and

accessories painted black erected flushed on wall/ceiling

71 Design, Construction, Fabrication, Supply, Errection of Plant, 1 Nos. 1,11,50,000.00

Machineries & Equipments for - Screening Unit (100 mm) for

Pre Sorting or Pre Processing Section including feeding, Accept

and Rejection conveyor belt & Electric pannel board and cabling

72 Design, Construction, Fabrication, Supply, Errection of Plant, 1 Nos. 41,50,000.00

Machineries & Equipments for - Horizontal Conveyor System

for waste sorting with Pre Sorting or Pre Processing Section with

Air blower and Magnetic Seprator

73 Design, Construction, Fabrication, Supply, Errection of Plant, 1 Nos. 1,58,00,000.00

Machineries & Equipments for Screening Unit (35 & 16 mm) for

Preparatory Section including feeding, Accept and Rejection

conveyor belt & Electric pannel board and cabling

74 Design, Construction, Fabrication, Supply, Errection of Plant, 1 Nos. 97,00,000.00

Machineries & Equipments for Screening Unit (4-6mm) for

Compost Finishing & Bagging Section including feeding, Accept

and Rejection conveyor belt & Electric pannel board and cabling

75 Design, Construction, Fabrication, Supply, Errection of Leachate 1 Nos. 39,659.67

76 Procurement of Plastic Shredder Machine with feeding and 1 Nos. 88,55,000.00

output conveyor & Electric pannel

77 Procurement of Bailing Machine 1 Nos. 17,50,000.00

78 Procurement of Dust Remover Machine 1 Nos. 10,50,000.00

79 Construction and installation of Calibrated Weigh Bridge 1 Nos. 18,00,000.00

including Civil Works (100 MT)

80 Procurement of Office Hardware /Computer, Printer, Scanner 1 Nos. 34,650.00

PORBANDAR MUNICIPAL CORPORATION - PORBANDAR

DIST: PORBANDAR

Selection of Developer for design, supply, installation, erection and commissioning of Municipal Solid Waste Processing

Plant including civil works with Operation & Maintenance (O&M) for 5 years in Porbandar Municipal Corporation

No Item Qty Unit Rate Amount

81 Procurmenet and Installation of CCTV Camera (10 Nos) , Lan 1 Nos. 3,50,029.00

Connection (30 M wire per CCTV), video recorder (1 Nos) and

82 Procurement of Office Furniture, Chair-15 Nos., Tables-3 Nos., 1 Nos. 2,24,385.00

door Steel Cupboard-2 Nos.

83 Procurement and Supply of Electricity Connection/ Standby Oil 1 Nos. 19,62,422.93

Cooling Diesel Generator (DG) Set 250 Kva

84 Tractor (66 HP) 1 Nos. 12,60,000.00

85 Trailer (2 Tonne) 1 Nos. 69,990.00

86 Transformer 500 Kva 1 Nos. 11,15,387.44

87 Fire Extinguisher 15 Nos. 950.00

88 Frount and Backhoe Loader 1 Nos. 41,25,000.00

For Operation And Maintenance

No Item Qty Unit Rate Amount

Operation, Maintenance of Processing of the Solid Waste

Processing Plant (Dry Waste and Wet Waste) for a period of Five 1 Ton

(05) Years As per Terms and Conditions of The Tender

I / We am / are willing to carry out above work at .................. % above / below. In words........................ percentage above / below the tender rate,

which mentioned above.

Or any other Item subjected to the tender required as per the instruction shall be executed as per the SOR with effect of above / below for this

1. The Contractor shall exhibit a board with detailed specification and details of work as directed by the Engineer-In-Charge for which no extra

payment shall be made.

2. The labour cess will be deducted as per prevailing rules i.e. 1% of the work done.

3. Applicable GST TDS & Income tax TDS will be deducted at a source while making payments of bills

4. In all R.C.C. Items in Rate Analysis Standard Cement Consumption has been taken as per Govt. G.R.: PRC-10/2017 Cement

Consumption/16/C Date:11/05/2017 as stated in S.O.R. therefore in R.C.C. items where there is a change as per actual mix design the cost of

difference of cement consumption have been deducted from the rate of original item at the rate of input rate mentioned in all the tender.

5. GST will be Paid as per Terms and Conditions of Tender.

Stamp with signature of contractor