Construction of new 33 kv line from 33/11 kv S/S Radha Madhav to 33/11 kv S/S Harunagla in district Bareilly

Amount

Note - Any material/Labour required to complete the work (which is not covered in above) will be provided by the firm.

Part (A) - Increasing capacity

Loading, unloading and safe carriage of the following materials from any Electy. Store Center of Electricity store division of Bareilly zone.

33 KV Line type Isolator 800A.

MS Channel 125x65mm

MS Angle 75x75x8 mm

MS Angles 50x50x6mm

STP 11Mtr. long

33 KV Pin insulator

33 KV Pin with nut

ACSR Dog conductor

33 KV 3x300mm XLPE Cable

33KV 3x300mm cable joitng kit O/D

33 KV 3x300mm cable jointing kit S/through

Earthing complete

T off channel 125x65x6mm 1300mm

M.S angle lron 65x65x6mm, for bracing

M.S.Channel 100X50X2240mm

Supply of GI strip of size 50x6mm for earthing of all newly erected structures and equipments in switchyard including cutting, fixing & proper welding with equipments. All LA will be seprately earth also as per RESPO norms. (All the required materials will be provided by firm and will be inspected by AE (Works) before installation.)

Fabrication, erection and grouting of the Bus Isolator structures as per RESSPO/ Approved Drawing and its, plinth 30cm above ground leval as directed by the Engineer Incharge (All steel sections will be provided by Deptt).

Installation of Bus Isolator equipments on their respective structures including mechanical & electrical fixing after proper adjustment on their structure.

Making of M.S. Angle Ladder type frame of Angle (75x75x8mm) & GI Strip (50x6mm) near power transformer for power cable with concreting of the same in the ground and proper clamping (50x6mm) of the same with transformer cable.

Erection of the following supports including cutting, making holes, fixing of all types of accessories digging of pits complete in all respect, as per RESSPO drawing. All types of clamps, stone pad, nut, bolt washers would be provided by the contractor.

Cable Exposer double pole structure on S.T. Pole 11mtr long complete with bracing.

Concreting of supports at the time of erection of pole in 1:4:8 concrete ratio from bottom of pole to ground level and plinthing of supports upto 300mm above ground level by using cement, sand & coarse aggregate in ratio 1:4:8 as per RESSPO drawing with watering/curing properly upto proper setting of plinthing. All matrial would be provided by the contractor.

Earthing of each S.T Poles of the line is to be done by inserting the MS earth rod (1800x20mm) into soil by hammering and properly fastning with GI wire to each support by nut & bolt. Earthing rod must be 0.15Mtr.above from the plinth of the support. All type nut & bolt would be given by the contractor.

Fixing of danger board and G.I barbed wire on each pole including proper clamping. All material would be provided by firm.

Write serial number on each pole in English with black paint in yellow paint background. All material would be provided be firm.

Painting of cable exposer double pole support of 33 KV line with one coat of red oxide primer and two coats of aluminium white paint of ISI mark and top danger portion of each support must be painted by providing two coat of Post Office Red Paint (1.5mtr upper portion of support.) Paint and material would be given by contractor to complete of work.

Laying of double circuit 33 KV 3X300 Sq. mm XLPE cable in normal soil by digging of trench 1500 mm deep, 750 mm wide including supply of required material as fine sand, 1st class bricks, stone slab. Inter axial spacing between the two cable should be in between 0.25 m to 0.40m. The two cables should be seprated by a partition of single bricks (All the material required for laying will be supplied by the contractor except 33 KV XLPE cable)

33 KV Cable laying by drill method in single circuit

Hoisting of 33 KV 3X300 Sq. mm. XLPE cable on double pole in GI pipe including its jumpering complete along with cost of A class GI pipe of size 6" dia 3 M long, clamps, nuts and bolts.

Fixing of 11 KV 3x185sqmm O/D & S/Th.

Fixing of 33 KV Cable Marker. (all material would be provided be firm.)

Bharat Trading Corporation

M/S SUPER ENGINEERING TRADERS