GENERAL MIPTA Annual Maintanance 2024 25 of Erattady L I Station Mechanical amp Civil works under M I Section Adoor General Civil Work

Amount

1 APPENDIX- A- MECHANICAL

OD1879/2024-2025:Conveying pump,motor and accessorries from department store to pump house and after season back to store.

OD20547/2024-2025:Overhauling existing 25hp , 15 hp motor, separate the starter and motor, remove the dust, cleaning with petrol, varnishing the winding with best quality varnish, heating, greasing the bearing, assembling and refitting the same and conducting test run etc complete as per directions of departmental officers at site.

OD1896/2024-2025:Re erection of of pump and motor , fixing to bed and alignment setting of motor and pump erection of pipe line suction and delivery etc complete

OD1881/2024-2025:Charges for supplying 3/4 inch coupling bolt including cost, conveyance etc. complete.

OD1882/2024-2025:Charges for supplying rubber bush

OD1883/2024-2025:Charges for supplying oil seal for 25 hp motor.

OD1884/2024-2025:Supplying 12 mm/16 mm gland packing

OD1887/2024-2025:Supplying good quality pump oil including all cost and conveyance

OD1888/2024-2025:Supplying good quality transformer oil including all cost and conveyance etc complete

OD1889/2024-2025:Supplying iron nut and bolt (specified dia)

OD1890/2024-2025:Supplying Cotton waste

OD1891/2024-2025:Supplying bearing grease good quality

OD1892/2024-2025:Supplying 2" good quality brush

OD1893/2024-2025:Supplying rubber bush

OD15024/2024-2025:Supplying and fixing 150 mm (4.85 mm thick) MS pipe including fixing at correct alignment including all cost convayance and all other incidental charges etc complete

OD17016/2024-2025:Supplying and fixing Fuse 100 Amps(3 nos)

OD18525/2024-2025:Supplying and fixing Suction Strainer of SS 304 mesh (1/2) and SS 304 connecting plate of thickness 5 mm used to remove debris and waste .

OD20548/2024-2025:Supplying and fixing 100 Amp 3 phase main switch

1 APPENDIX- B- CIVIL WORK

2.31:Clearing jungle including uprooting of rank vegetation, grass, brush wood, trees and saplings of girth up to 30 cm measured at a height of 1 m above ground level and removal of rubbish up to a distance of 50 m outside the periphery of the area cleared

2.6.1:Earth work in excavation by mechanical means (Hydraulic excavator)/manual means over areas (exceeding 30 cm in depth, 1.5 m in width as well as 10 sqm on plan) including disposal of excavated earth, lead up to 50 m and lift up to 1.5 m, disposed earth to be levelled and neatly dressed.All kinds of soil

14.43:Removing white or colour wash by scrapping and sand papering and preparing the surface smooth including necessary repairs to scratches etc. complete.

14.54.1:Painting with synthetic enamel paint of approved brand and manufacture of required colour to an give even shade:One or more coats on old work

22.6:Providing and laying water proofing treatment on roofs of slabs by applying cement slurry mixed with water proofing cement compound consisting of applying : a) after surface preparation, first layer of slurry of cement @ 0.488 kg/ sqm mixed with water proofing cement compound @ 0.253 kg/ sqm. laying second layer of fibre glass cloth when the first layer is still green. Overlaps of joints of fibre cloth should not be less than 10 cm. c) third layer of 1.5 mm thickness consisting of slurry of cement @ 1.289 kg/ sqm mixed with water proofing cement compound @ 0.670 kg/sqm and coarse sand @ 1.289 kg/sqm. This will be allowed to air cure for 4 hours followed by water curing for 48 hours. The entire treatment will be taken upto 30 cm on parapet wall and tucked into groove in parapet all around. d) fourth and final layer of brick tilling with cement mortar (which will be paid for separately. For the purpose of measurement the entire treated surface will be measured)

13.7.2:12 mm cement plaster finished with a floating coat of neat cement of mix:1:4 ( 1 cement : 4 fine sand)

OD18533/2024-2025:Fixing ex.electrical panel board including cleaning painting and fixing

OD18613/2024-2025:Fire extinguishers class c type co2 -2 kg

14.44:Distempering with dry distemper of approved brand and manufacture ( one or more coats ) and of required shade on old work to give an even shade.

OD18645/2024-2025:Thermoplastic poly propylene back chair with arm for indoor use

OD18646/2024-2025:Electrical insulated rubber gloves as per OSHA(29 CFR 1910.137(C))2(VIII)and reference table 1-5

OD18647/2024-2025:Checkered rubber floor mat of size 120x60 cm ,10 -20mm thick for sefety purpose of the worker

SUMA T P

MURALEEDHARAN M R

Bidder Name

MURALEEDHARAN M R

RONAK S

SUMA T P