(SECOND TRY) YEARLY RATE OF GUTTER, R.C.C.ROAD REPAIRING,NP2 PIPE LINE ETC.. REPAIRING WORK IN VADNAGAR NAGARPALIKA,AT.VADNAGAR DIST.MEHSANA

Item No. Item Rate Per

Item No. 1 Excavation for foundation up to 1.5 m. Depth

including sorting out and stanching of useful materials and

disposing of the excavated stuff up to 50 Meter lead (A)

Loose or soft soil

Item No. 2 Providing and laying cement concrete 1:5:10 (1

Cement : 5 Coarse Sand, 10 Hand broken stone aggregate

mm nominal size) and curing complete excluding cost of

form work in (a) Foundation and Plinth (up to 10 ton)

Item No. 3 : Providing and laying cement concrete 1:4:8 (1

cement 4 coarse sand 8 hand broken stone aggregate 40 mm

nominal size) and curing complete excluding cost of Form

work in. (a) Foundation and Plinth (up to 10 ton)

Item No. 4 Providing and laying cement concrete 1:2:4 (1

cement : 2 coarse sand : 4 graded stone aggregate 20 mm

4 nominal size) and curing complete excluding cost of form

work and reinforcement for reinforced cement concrete work

(A) Foundations, footing, base of columns and mass concrete

Item No. 5 : Providing Thermo Mechanically Treated bat

(T.M.T.) (I.S.I. Mark) Conforming to I.S.-1786 Fe-415 for

R.C.C. work Including bending, binding & placing in

position comp. up to floor two level (up to 10 ton)

Item No. 6 : Uncoursed rubble masonry with hare stone

with hard stone of approved quality in foundations and plinth

in cement mortar 1:6 (1 Cement : 6 Coarse Sand) Including

leveling up etc. complete (up to 10 ton)

Providing and laying ordinary cement concrete 1:3:6 (1

Cement : 3 Coarse Sand: 6 Crushed store aggregate 20 mm

nominal size) and Curing Complete including the cost of

Form work in Wall Caps/Copings (up to 10 ton)

Pointing on uncoursed stone masonry with cement mortar

1:3 (1 cement, 3 sand) (A) Flush Pointing

Filing available excavated earth (excluding rock) in trenches

plinth sides of foundation etc. layers not exceeding 20cm. in

depth consolidating each deposited layer by ramming and

Item No. 10 : Brick work using common burnt clay building

bricks having crushing strength not less than 35 Kg./Sq. cm

in foundation and plinth in cement mortar 1 :6 ( 1 cement :6

fine sand ) in (B) Conventional (up to 10 ton)

Item No. 11 : (2) Half Brick masonry in common burnt clay

building bricks having crushing strength not less than

Kg./Sq. cm in cement mortar 1 : 5 ( 1 cement :5 coarse sand )

in foundation & plinth (B) Conventional (up to 10 ton)

Item No. 12 : Providing 10 mm. thick cement plaster in

single coat on fair side brick / concrete walls for interior

plastering up to floor two level and finished even and smooth

in (i) cement mortar 1:3

Item No. 13 : Providing 20 mm thick sand faced cement

plaster on walls up to height 10mt. Above ground level

13 consisting of 12mm thick backing coat of C.M. 1:3 ( 1- 321.1 Sq. M.

cement : 3-sand ) and 8mm thick finishing cost of C.M.1 :1 (

1-Cement : 1-Sand) etc. complete.

Item No. 14 : Earthwork for embankment including breaking

clods. with all lead and lift (Excluding watering and

(A) From borrow pits within lead width 150 Cu.M.

(B) From borrow pits within 0.5 km. lead 287.5 Cu.M.

(C) From borrow pits within 1.0 km. lead 297.5 Cu.M.

(D) From borrow pits within 2.0 km. lead 317.5 Cu.M.

(E) From borrow pits within 3.0 km. lead 336.25 Cu.M.

Item No. 15 Demolition and disposal or unserviceable

materials with all lead and lift. (i) Cement concrete

Item No. 16 : Box Cutting the road surface to proper slop

proper and camber for making base for road work incl.

removing the excavated stuff & depositing on the road slop

as directed up to 50 mt. Lead

Item No. 17 Providing & Laying ordinary concrete M-200 (1

Cement : 1.5 coarse Sand : 3 graded stone aggregate 20 mm

nominal size) and curing completed excluding the cost of

17 formwork in and reinforcement if rainforced concrete work 3849.01 Cu.M.

in (UP TO 10 TON) including surface vibrator and rough

finish to surface as per instruction including leveling, channel

vibrating etc. complete

Item No. 18 : Providing and laying cement concrete flooring

1: 2: 4 (1 Cement : 2 course sand : 4 graded stone aggregate

20 mm nominal size) laid in one layer finished with a

floating coat of neat cement.

(A) 40 mm Thick 182.7 Sq.M.

(B) 50 mm Thick 213.15 Sq.M.

Item No. 19 : Providing and fixing pre-cast Rubber Dye inter

locking concrete block 60mm thick with grade of concrete M-

300 pneumatic compressed by mechanically pressed and as

per approved design including 35mm sand layer for leveling

and filling the joint with sand in praper line nand level etc.

Item No. 20 Providing and laying broken chine mosaic

flooring for terrace using 12 mm to 20 mm broken pieces of

glazed tiles to be laid over cement mortar 1:3 to plain or

20 slope and to be tempered to bring mortar crème out up to 779.7 Sq.M.

surface using white cement including rounding of junctions

and extending them up to 15 cm along the wall, clearing with

water and oxalic acid etc. as directed

Item No. 21 : Providing and fixing M.S. grills required

pattern of window etc. with M.S. flats at required spacing &

frame around square or round bars with round headed bolts

21 & nuts and welding or by screws and including one coat of 105.24 Kg.

primer and two coats of oil paintng etc. complete as

approved by the Architect and Engineer-in-charge, (A) Plain

Item No. 22 Providing and laying (to level or slopes and

jointing reinforced concert light duty non pressure pipes IS

22 class NP2 of the following internal dia. meter with clears and

butt ends prepared for collar joints including testing of

jointing completed.

(B) 150 mm (up to 10 ton) 257.13 Meter

(C) 250 mm (up to 10 ton) 359.74 Meter

(D) 300 mm (up to 10 ton) 677.9 Meter

(E) 450 mm (up to 10 ton) 1076.89 Meter

(F) 500 mm (up to 10 ton) 1252.18 Meter

(G) 600 mm (up to 10 ton) 1400.6 Meter

Item No. 23 : Supplying and fixing reinforced concrete

R.C.C. heavy duty Non- pressure pipe with collars for

23 culverts including setting and jointing the pipe in C.M 1:2

watering and lying(to level or slopes) of i.S. class NP-3 of

following internal diameters.

900 mm dia. 3824.55 Rmt.

1050 mm dia. 5211.21 Rmt.

1200 mm dia. 6205.81 Rmt.

Item No. 24 : Providing and fixing 1.20 m. high fencing with

2.0 meter long M.S. angle posts 40 mm x 40 mm x 6 mm and

oil painting 3 coats fixed at 2.5 m. c/c with five horizontal

24 line and two diagonals of galvanized steel barbed wire 339.15 Rmt.

weighing 9.38 K.G. per 100 meter, stained and fixed to posts

with G.I. staple including fixing the posts in ground with

m. x 0.5 m. x 0.5. Block in C.C. 1:5:10 etc. Complete.

Item No. 25 Providing Soak Pit 6' dia.& 20' deep with

necessary excavation dry encores rubble maso. or dry

b.b.maso. Recast R.C.C. over 6" th. as per instruction (every

5th layer in c. m. 1:4

Item No. 26 Providing and fixing to wall, ceiling and floor

6.0 KgF/cm2 working pressure polyethylene pipes of the

26 following outside dia low density complete with special

flange compression type fitting, wall clips etc. including

making good the wall ceiling and floor.

(A) 20 mm 52.08 Meter

(B) 25 mm 67.31 Meter

Item No. 27 : Providing and fixing to wall, ceiling and floor

10.0 KgF/cm2 working pressure polyethylene pipes of the

27 following outside dia low density complete with special

flange compression type fitting, wall clips etc. including

making good the wall ceiling and floor.

(C) 32 mm 81.38 Meter

(D) 40 mm 110.25 Meter

(E) 50 mm 157.5 Meter

Item No. 28 : Compaction and finishing of cement concrete

road by tremix process. providing extra labor charge for

tremix (Vacuum dewatering service) process on cement road

28 surface by using vacuum dewatering pump floater surface 51.87 Sq.M.

vibrator including making groves and rough finish to surface

as per instruction including leveling etc. Complete Consider

10.0 mt Length & 5 mt. width of road

Item No. 29 Providing & Fixing Chhino & vata fitting in

nagarpalika area

Item No. 30 Providing Laying kotah stone slab flooring over

20 (average) thick base of cement mortar 1:6 (1 Cement :

30 course sand) or L.M. 1:1.5 and laid over and jointed with 627.9 Sq.M.

grey cement slurry including rubbing and polishing etc.

complete (A) 25 mm thick (up to 10 ton)

Item No. 31 Providing and laying white glazed tiles 6mm

thick in skrting risers of steps and dedo on 10mm thick

cement plaster 1:3 (1-cement : 3-coarse sand) and jointed

with white cement slurry

Item No. 32 Providing and Laying 24" x 24 " vitrified mm.

thick tiles, flooring over 20 mm (Average) base of cement

mortar 1:6 (1 cement : 6 coarse sand) on new surface or

fixing on existing flooring by adhesive materials including

dismantling of existing flooring and joined with colour

cement slurry including finished with flush pointing &

cleaning the surface etc. complete. for light shade finished

with flush pointing in white cement (up to 10 ton)

Item No. 33 : Providing and fixing Water Closet Squatting

pan ( Indian type W.C.pan) size 580mm (Earthwork, bed

concrete, foot rest and trap to be measured and paid for

separately) (A) Vitreous China -(i) Long pattern-white colour.

NAME PLATE Providing and fixing of black granite stones

name plate with engraved letters of matters in any size and

34 any language and filled with golden paints in to engraved 7095 Smt.

matters. The above matters to be done as per architect

drawing and instruction on site.

Collecting and Carting Paver Block From Nagarpalika

Fixing Paver Block leveling and filling the joint with sand in

proper line and level

SPEED BREAKERS: - Must be supplied with the DIV

segment interlocking sub-units made of ABS (Acrilinatorial -

Boutadie - Styrene) / PE (Poly Ethylene). So that it fits

completely into one generation bump. Difficulties are pre-

37 colored (black-yellow) and UV settled. Each sub unit should 2000 1 RMT

be packed with good quality reflections somewhere. The

bump is hollow from the back and will be filled with a

concrete base. And then have to be fixed on the ground

surface with adhesive (epoxy and resin) and bolt or fasteners.

SPEED BREAKERS: - Must be supplied with the DIV

segment interlocking sub-units made of ABS (Acrilinatorial -

Boutadie - Styrene) / PE (Poly Ethylene). So that it fits

completely into one generation bump. Difficulties are pre-

colored (black-yellow) and UV settled. Each sub unit should

be packed with good quality reflections somewhere. The

bump is hollow from the back and will be filled with a

concrete base. And then have to be fixed on the ground

HIGHT 2.0 INCH 1 RMT

IN 1 METER 2 PCS (YELLOW) & 2 PCS (BLACK)

SIZE W350 X L250 X H50 MM (PER/PCS)

CAPACITY 25 TON

MATERIALS 30 % ABS & MIX PLASTIC

TOP FINISH BOTH SIDE PLATE TYPE REFLECTORS

REFLECTOR 3 YEAR

WARRANTY 2.0 INCH

Item No. 39 Providing formwork of ordinary timber planking

so as to give a rough finish including centering shuttering

strutting and propping etc. Height of propping and centering

below supporting floor to ceiling not exceeding 4 M. and

removal of the same for in situ reinforced concrete and plain

concrete work in. (B) Flat surfaces such as soffits of

suspended floor roof slabs Landings and the like. (2) Floors

etc. above 200mm in thickness. (up to 10 ton)

Distempering with dry distemper of approved brand and

manufacture (two coats) and of required shade on wall

40 surfaces of given an even shade, over and including a 32.24 Sqm.

priming coat of whiting after thoroughly brooming the

surface free from mortar dropping and other foreign matter.

Painting one coats (excluding priming coat) on previously

printed steel and other metal surface with synthetic enamel

paint, brushing to give an even shade including cleaning the

surface of all dirt, dust and other foreign matter.

Providing, laying, spreading & compacting graded machine

crushed black stone aggregates to Wet Mix Macadam

42 (WMM) in layers including premixing the material with 905.13 Cmt

water to OMC in mechanically mix (Pug-mill) carriage of

mix material by tipper to site, laying

Lowering, laying and jointing PVC pipes and specials of

following class and diameter including cost of conveyance

43 from stores to site of works including cost of labour,

material, except cement solvent, giving satisfactory hydraulic

testing as per ISI code.

Providing and laying compacted WBM 150 mm thick of

44 machine crushed BT metal of size 45 mm to 90 mm with 1139.01 CUM

using and stone dust including complete

Providing and laying cement concrete work 1:2:4 (1- Cement

: 2- Coarse sand : 4-graded stone aggregates 20 mm nominal

size) and curing complete excluding cost of formwork and

reinforcement for reinforced concrete work in (A)

Foundations, footings, Base or columns and Mass concrete

(more than 10 ton)

Steel work, riveted in built up sections framed work

including cutting, hoisting, fixing in position and applying a

priming coat of read lead paint. (A) In beams and joists,

46 channels angles Tees, flats, with connecting plates or angle 6174.18 CMT

cleats as in main and cross beams. Hip and jack rafters,

purlins connected to common rafters and the like. (upto

Item No.47 Providing corrugated G.I. sheet of class-3

roofing fixed with glavanished iron J or L Hooks, Bolts and

nuts 8mm diameter with bitumen and G.I. limpet washer or

G.I. limpet washer. filled with white lead complete excluding

the cost of purlins, Rafters and Trusses.(1) 0.80 mm thick

sheet. (upto 10 ton)

RCC precast M.H. frame & Cover Manufacture, supply &

delivery at store or at site of work precast RCC M.200 frame

& cover suitable to drainage M.H. and as per type design &

drawing including cost of reinforcement M.S. Angles or Flat,

curing mold work etc. (frame suitable for 50cm opening of

RCC precast M.H. frame & Cover Manufacture, supply &

delivery at store or at site of work precast RCC M.200 frame

& cover suitable to drainage M.H. and as per type design &

drawing including cost of reinforcement M.S. Angles or Flat,

curing mold work etc. (cover suitable for 50cm opening of

Renovation of manhole by increasing the height at top

including cost of excavation, refitting of C.I. manhole frame

and cover curing etc. complete incl. all carting and providing

of materials which is required for the purpose (except

manhole frame and cover)for all type manhole by providing

RCC 1:2:4 partition walls with required reinforcement 25cm

thick and circular opening with 500mm clear dia and

Providing and fixing concealed center point to wall ceiling &

floor CPVC (SDR 13.5) PIPE having National Sanitation

51 Foundation (NSF) seal for potable water of following dia. 136.5 RMT

nominal bore tube fittings and clamps including making good

the wall, ceiling and floor etc. complete. [A] 15mm.

Providing and fixing concealed center point to wall ceiling &

floor CPVC (SDR 13.5) PIPE having National Sanitation

52 Foundation (NSF) seal for potable water of following dia. 177.45 RMT

nominal bore tube fittings and clamps including making good

the wall, ceiling and floor etc. complete. [B] 20 mm.

Providing and fixing concealed center point to wall ceiling &

floor CPVC (SDR 13.5) PIPE having National Sanitation

53 Foundation (NSF) seal for potable water of following dia. 226.8 RMT

nominal bore tube fittings and clamps including making good

the wall, ceiling and floor etc. complete. [C] 25 mm.

Providing and fixing concealed center point to wall ceiling &

floor CPVC (SDR 13.5) PIPE having National Sanitation

54 Foundation (NSF) seal for potable water of following dia. 317.9 RMT

nominal bore tube fittings and clamps including making good

the wall, ceiling and floor etc. complete. [D] 32mm.

Providing and fixing concealed center point to wall ceiling &

floor CPVC (SDR 13.5) PIPE having National Sanitation

55 Foundation (NSF) seal for potable water of following dia.

nominal bore tube fittings and clamps including making good

the wall, ceiling and floor etc. complete. [E] 40mm.

Providing and fixing concealed center point to wall ceiling &

floor CPVC (SDR 13.5) PIPE having National Sanitation

56 Foundation (NSF) seal for potable water of following dia. 655.29 RMT

nominal bore tube fittings and clamps including making good

the wall, ceiling and floor etc. complete. [F] 50mm.

Providing laying and jointing in true line and level 15mm dia.

U.P.V.C. Pipe ( SCH- 40) for cold water including fittings as

approved by Engineer In Charge. Pipe shall be fixed on the

57 wall with the help of clamp at every two metre C/C or shall 84.87 RMT

be concealed as directed including necessary fittings etc.

including testing of pipe and joints and fixing the same with

adhesive solvent, including cost of all materials.

Providing laying and jointing in true line and level 25mm dia.

U.P.V.C. Pipe ( SCH- 40) for cold water including fittings as

approved by Engineer In Charge. Pipe shall be fixed on the

58 wall with the help of clamp at every two metre C/C or shall 107.29 RMT

be concealed as directed including necessary fittings etc.

including testing of pipe and joints and fixing the same with

adhesive solvent, including cost of all materials.

Providing laying and jointing in true line and level 32mm dia.

U.P.V.C. Pipe ( SCH- 40) for cold water including fittings as

approved by Engineer In Charge. Pipe shall be fixed on the

59 wall with the help of clamp at every two metre C/C or shall 139.2 RMT

be concealed as directed including necessary fittings etc.

including testing of pipe and joints and fixing the same with

adhesive solvent, including cost of all materials.

Providing laying and jointing in true line and level 40mm dia.

U.P.V.C. Pipe ( SCH- 40) for cold water including fittings as

approved by Engineer In Charge. Pipe shall be fixed on the

60 wall with the help of clamp at every two metre C/C or shall 173.03 RMT

be concealed as directed including necessary fittings etc.

including testing of pipe and joints and fixing the same with

adhesive solvent, including cost of all materials.

Providing laying and jointing in true line and level 50mm dia.

U.P.V.C. Pipe ( SCH- 40) for cold water including fittings as

approved by Engineer In Charge. Pipe shall be fixed on the

61 wall with the help of clamp at every two metre C/C or shall 228.61 RMT

be concealed as directed including necessary fittings etc.

including testing of pipe and joints and fixing the same with

adhesive solvent, including cost of all materials.

Providing and laying B.M 37.50 mm thick (Average)layer

with Asphalt 60/70 for tack coat at the rate of 3.4 kg./

Sqm. with mechanical sprayer on B.T. surface and using B.T.

stone aggregates as per required gradation with the asphalt of

60/70 grade at the rate of 3.4% i.e.34.40 Kg./M.T. by weight

62 by mix including heating and mixing in drum mix plant, 2536.25 M.T

transporting the mix spreading the same by sensor paver

finisher and consolidation by vibrator roller MORTH

specification including cost of all materials, fuel labours,

tools and plant etc using contractor own drum mix plant etc

Providing & laying 20 mm. thick Mix Seal Surfacing using

stone chipping & aggregate as per M.O.R.T.&H.

specification & asphalt grade 60/70 for mixing at the rate of

50.90 Kg./M.T. i.e. 5.09% of total weight of mix including

heating the aggregate & asphalt in continuous batching drum

63 mix plant & spreading the same by paver finisher & 3331.93 M.T

consolidation with vibratory roller & flushing sand @

Cum/ 100 Smt. including providing all materials

wquipments, tools & plants, fire wood, oil, kerosene, labour

charges etc complete using constractors own machinery drum

mix plant & paver finisher etc complete.

Scarifying gravelled macadam or Bitumen macadam surface

64 6cm to 10cm depth inluding stacking useful materials on 41.6 SQMT

road side and disposing off remaining stuff

Providing and laying Builtup spray grout base 37.50 mm

thick (Average)layer with Asphalt 60/70 for tack coat at the

rate of 2.5 kg./ 10 Sqm. with mechanical sprayer on B.T.

surface and using B.T. stone aggregates as per required

gradation with the asphalt of 60/70 grade at the rate of 1.99%

65 i.e.19.90 Kg./M.T. by weight by mix including heating and 2002.38 M.T

mixing in drum mix plant, transporting the mix spreading the

same by sensor paver finisher and consolidation by vibrator

roller MORTH specification including cost of all materials,

fuel labours, tools and plant etc using contractor own drum

mix plant etc complete.

Vadnagar Vadnagar

Signature of Contractor. Nagarpalika Nagarpalika

Vadnagar Vadnagar