Construction of 33 KV Ring Main Unit(RMU) to be connecting 33 KV Line Joljivi to 33 KV Line Seraghat Munsyari under EDD Dharchula on turnkey basis

Amount

Supply of Material

33 KV XLPE CABLE OF SIZE 3Cx400 SQMM

M.S CHANNEL 100x50 MM

ST POLE SP-33 (BPHD)

STAY SET 20X1800MM

STAY WIRE 7/10 SWG

M.S ANGLE 65X65X6 MM

M.S CHANNEL 125x65x6 MM

33 KV POLYMER DISC INSULATOR

33 KV DISC FITTING 70 KN

33 KV LIGHTNING ARRESTER

ACSR DOG CONDUCTOR

33 KV CABLE END TERMINATION J/KIT FOR 3Cx400 SQMM CABLE (O/D) (RAYCHEM MAKE)

CABLE HOLDING CLAMP WITH N&B for SP -33

AL LUGS OF SIZE UPTO 400 SQMM

MS BOLTS & NUT WITH WASHER

EARTHING STRIP

36KV 630A 25KA/3SEC SF6 INSULATED OUTDOOR (IP55) NON-EXTENSIBLE MANUAL OPERATED THREE VCB PANEL BOARD RING MAIN UNIT

33KV 3X400 SQMM PUSHON TERMIATION KIT INDOOR TYPE FOR 33KV RMU

TOP CHANNEL CLAMP FOR SP-33 WITH N&B

BRACING SET CLAMP FOR TOP SP-33 WITH N&BOLT

BRACING SET CLAMP FOR BOTTOM SP-33 WITH N&BOLT

STAY CLAMP FOR STP SP-33 POLE WITH N&B

Erection Work

CARTAGE OF OTHER STOCK MATERIAL (OTHER THEN POLES) BY VEHICLE FROM STORE CENTER TO NEAREST CONSTRUCTION SITE STORE INCLUDING LOADING AND UNLOADING AT BOTH ENDS. (0-20KM)

TRANSPORTATION OF 33 KV RMU

MANNUAL CARTAGE OF MATERIAL UNLOADING POINT TO WORK SITE ( 0 TO 0.5 KM) (A) STOCK MATERIAL

FABRICATION OF MS CHANNEL / ANGLE IRON AFTER CUTTING IN REQUIRED SIZES WITH DRILLING OF HOLES UPTO GOOD FINISH

MAKING OPEN TRENCH IN MIXED SOIL FOR 33KV CABLE AT 1.5 MTR DEPTH BELOW GROUND LEVEL INCLUDING LAYING OF GI / HDPE PIPE (AS PER REQUIRMENT).

SUPPLY AND LAYING OF HDPE PIPE 160 MM OUTER DIA & HAVING THICKNESS 9.1 TO 10.3 MM

SUPPLY AND FIXING OF GI PIPE (WITH SOCKET) 6 INCH DIA AT POINTS OF ROAD CROSSING, BRIDGE CROSSING, CABLE RISING AT POLE ETC AS PER SITE REQUIREMENT

SUPPLY AND FIXING OF SPECIAL EARTHING FOR CABLE AT DIFFERENT POLE STRUCTURE BY 450X450X10MM G.I. PLATE VERTICALLY 3M BELOW THE GROUND LEVEL WITH ALTERNATE LAYERS OF CHARCOAL & SALT ATLEAST 200MM THICK AROUND CONNECTED WITH G.I STRIP RUNNING TILL TOP OF POLE COMPLETE.

FILLING & FIXING OF 33KV END TERMINATION CABLE J.KIT (O/D)

FIXING AND COMMISIONING OF 33KV SF6 RING MAIN UNIT INCLUDING MAKING OF FOUNDATION AND 2 NOS SPECIAL EARTHING

FIXING AND COMMISSIONING OF 33KV 3X400 PUSHON TERMINATION KIT INDOOR TYPE FOR 33KV RMU

CARTAGE OF ST POLE SP-33 FROM STORE CENTRE HALDWANI TO CONSTRUCTION SITE WITH LOADING,UNLOADING AT BOTH POINTS AND PROPER STACKING 220 KM

STP POLE SP-33

CARTAGE OF OTHER STOCK MATERIAL (OTHER THEN POLES) BY VEHICLE FROM STORE CENTER TO NEAREST CONSTRUCTION SITE STORE INCLUDING LOADING AND UNLOADING AT BOTH ENDS.

STOCK MATERIAL

HEAD CARTAGE OF FOLLOWING POLES FROM ROAD TO SITE

STP POLE SP-33

HEAD CARTAGE OF FOLLOWING POLES FROM ROAD TO SITE

STOCK MATERIAL

EXCAVATION OF EARTH FOR POLE PIT OF SIZE 0.9X0.6X1/6 OF FULL LENGTH OF POLE FOR ERECTION OF POLE IN ALL TYPE OF SOIL INCLUDING PROPER DRESSING OF SIDES AND RAMMING OF BOTTOM INCLUDING GETTING OUT THE EXCAVATED SOIL AND DISPOSAL OF SURPLUS EXCAVATED SOIL AS DIRECTED COMPLETE WORK

ERECTION OF FOLLOWING SINGLE SUPPORT POLE IN PROPER LEVEL AND ALIGNMENT ALONG WITH FIXING OF ALL ACCESSORIES,LIKE TOP CHANNEL & CLAMP AS PER RESPO CONSTRUCTION MANUAL.

GROUTING OF POLE IN SIZE 0.45X0.45X1/9 OF THE SUPPORT IN CC RATIO 1:4:8(1 CEMENT:4 GRADED STONE 20MM NOMINAL SIZE : 8 COARSE SAND) BLOCK INCLUDING COSTOF CEMENT,SAND ALIGNMENT,LEVELING AS PER RESPOCONSTRUCTION MANUAL.

MUFFING OF POLES SIZE 0.45 CMX0.60 CM RADIOUS WITH CC 1:3:6 (1 CEMENT : 3 COARSE SAND : 6 GRADED STONE 10 MM NOMINAL SIZE) BLOCK SIZE 45 CM HEIGHT FROM GROUND LEVEL INCLUDING COST OF CEMENT, STONE AND SAND ETC.

EXCAVATION OF EARTH FOR STAY SET PIT OF SIZE 0.6X0.6X1.2MTR IN ALL TYPE OF SOIL INCLUDING PROPER DRESSING OF SIDES AND RAMMING OF BOTTOM INCLUDING GETTING OUT THE EXCAVATED SOIL AND DISPOSAL OF SURPLUS EXCAVATED SOIL AS DIRECTED COMPLETE WORK

FIXING,TIGHTENING AND NOZZELING OF STAY SET WITH POLE AND STAY ROD ON REQUIRED TENTION AS PER DRAWING/RESPO MANUAL.

GROUTING OF STAY SET IN SIZE 0.6X0.6X0.3 IN CC RATIO 1:4:8 (1 CEMENT : 4 GRADED STONE 20MM NOMINAL SIZE : 8 COARSE SAND ) BLOCK INCLUDING COST OF CEMENT,SAND AND STONE BLLAST BACK FILLING OF SOIL AND BOULDERS IN PIT AND RAMMING AND PROPER ALIGNMENT.LEVELING AS PER RESPO MANNUAL.

MOUNTING & FIXING OF LIGHTNING ARRESTOR SET(3 NOS) ON DOUBLE POLE STRUCTURE INCLUDING MAKING ALL CONNECTION BY G.I STRIP SIZE 35X6 MM TO EARTH POINT COMPLETE WORK (INCLUDING COST OF G.I STRIP)

PLINT FOR 33 KV RMU 3.5X2X2

FENCING OF 33 KV RMU

Modern Electric Company