Replacement of ACSR Conductor by Aerial Bunch Cable with supply and erection of associate material in different areas of Nathuawala Phase-II feeder under 33/11 KV Sub-Station, Balawala under EDSD, Balawala under EDD, Raipur.

Total amount of the "Rate Schedule" sheet

SCHEDULE OF QUANTITY AND RATE FOR REPLACEMENT OF ACSR CONDUCTOR BY AERIAL BUNCH CABLE WITH SUPPLY & ERECTION OF ASSOCIATE MATERIAL IN DIFFERENT AREAS OF NATHUAWALA PHASE-II FEEDER UNDER 33/11 KV SUB-STATION, BALAWALA UNDER EDSD, BALAWALA UNDER EDD, RAIPUR AGAINST E-TENDER SPECIFICATION NO.73/EDCRDDUN/2025-26

Name of The Bidder's Firm:

Part [A] (Supply Portion)

Holding Clamp J-I hook for AB cable

LT Clamp for PCC Pole with N&B

Stay Clamp for SP-21 with Nut & Bolt

Suspension Clamp with Eye Hook

LT Clamp for Distribution Box

Dead End Clamp with I Hook

Piercing Connector 16 sqmm. - 16 sqmm.

Insulation Piercing Connector 120-50 sqmm.

Bolt & Nuts off Size

MS Clamp 65x6 mm. with N&B

Heat shrink type end caps for LT AB Cable

LT XLPE Cable 1x50 sq.mm.

LT AB Cable 3x70+1x50+1x16 Sq.mm.

LT Distribution Box 1 Phase

LT Distribution Box 3 Phase

Jointing Sleeve 4 mm.

Al. Lugs 50 sq.mm.

LT Bare neutral PG Clamp

Total - Part [A]

Part [B] (Labour Portion)

Erection of LT Stay set

Grouting of Stay in size 0.6x0.6x0.3 in CC ratio 1:4:8 (1 cement : 4 graded stone 20mm nominal size : 8 coarse sand) block including cost of Cernent, sand and stone ballast back filling of soil and boulders in pit and ramming and proper alignment, leveling as per RESPO Manual.

Excavation of earth for pole pit of size 0.9x0.6x1/6 of full length of pole for erection of pole in all type of soil including proper dressing of sides and ramming of bottom including getting out the excavated soil and disposal of surplus excavated soil as directed complete work

Erection of Single support poles SP-21 in proper level and alignment along with fixing of all accessories. Like top channel & clamps as per RESPO construction Manual.

Grouting of pole in size 0.45x0.45x1/9 of the support CC ratio 1:4:8 (1 cement : 4 graded stone 20mm nominal size : 8 coarse sand) block including cost of Cement, Sand and stone ballast back filling of soil and boulders in pit and ramming and proper alignment, leveling as per RESPO construction manual

Muffing of poles size 0.45 cm x 0.60 cm radius with cc 1:3:6 (1 cement: 3 coarse sand : 6 graded stone 10mm nominal size) block size 45cm height from ground level including cost of cement, stone and sand etc.

Dismantling of old ACSR conductor (weasel) (LT line) including Re- rolling back its conductor, wire, clamp insulator etc. including stacking & transportation of material to the UPCL store :

1 Phase 2 Wire

2 Phase 3 Wire

Cartage of ST pole from store centre to construction site with loading, unloading at both points and proper stacking (0-20 Km).

Cartage of other material (other than poles) by vehicle fro Store Center to nearest construction site Store including loading and unloading at both ends (0-20 Km.)

Rs.Per Qtl.

Head load cartage of following Poles from road to site

Upto 0 to 1 Km.

Head load cartage of Small material. Rates are per Km/Quintal including loading and Unloading.

Upto 0 to 1 Km.

Disconnection & Reconnection of Consumer

Laying, Stringing and Sagging of AB Cable size (LT AB Cable 3x95+1x70 sqmm.)

Straightening of Tilted ST Poles

Installation of LT DB 1 Phase for LT AB Cable

Installation of LT DB 3 Phase for LT AB Cable

Fixing of Head Shrink Cap for AB Cable

Fixing of Jointing Sleeves for AB Cable

Fixing of MS Clamp

Fixing of Dead End Clamp

Fixing of LT Clamp for PCC Pole

Fixing of 1x50 sqmm. XLPE Cable

Installation of 50 sqmm. LT Al. Lugs

Fixing of Suspension Clamp with I Hook

Fixing of IPC

Fixing of Piercing Connector 16 sqmm. - 16 sqmm.

Fixing of LT Distribution Clamp

Laying, Stringing and Sagging of AB Cable size (LT AB Cable 3x70+1x50+1x16 sqmm.)

Back Carriage of Scrap Material

Total - Part [B]

TOTAL [Part-(A) + Part (B)]

Place

Please Enable Macros to View BoQ information