PROVN OF FILTRATION PLANT FOR EXISTING OPEN WATER STORAGE SUMPAT GBAR SINGH CAMP KOTDWARA UNDER AGE I LANSDOWNE

Amount

Supply, installation,testing and commissioning of sand filteration plant made of Bobbin Wound fibre glass reinforced tank with UV resistant surace finish, top mount filter,filter dia 900mm, cross section area 0.63sqm working pressure -2- 2.5 Bar, equiped with 6-Position multiport valve with handle & ABS laterals, suitable for max flow rate of 23 Cum/Hr,Filteration Velocity of 19 Cum/Hr/M Pressure gauge fitted, installation on including foundation and connection/testing/commissioning ,complete all as specified and directed. . Make - Ion Exchange item code -T 900-36 /Emaux/Astral

Supply and filling of Filter media Silica Sand/White Selex quartz fine media 0.4 and 0.8mm with the Uc value less than 4 to promote movement of water and prevent clogging. ,complete all as specified and directed.

Supply, installation, testing and commissioning of Filtration Recirculating pump set in PP body, Wet ends made of high reinforced engineering thermal plastic with compact structure with Noryl impeller, 2” inlet/outlet, Insulation Class F/ Protection IP 55,continuous operation, motor/ pump shaft has no contact with water. Total electrical sepration with 2.2 ltr inbuilt pre filter with transparent lid for inspection , 2 HP,Single Phase, 25 Cum/Hr with 10m head ,complete all as specified and directed. . Make-Ion Exchange Item Code AQ 200 /Emaux/Shakti/ABB/Kirloshkar as approved by AGE(I)

Supply, installation, testing and commissioning of Chemical dosing and pH correction metering pump with fittings with chemical holding tank.supplied with the following accessories as standard : a) One level switch & suction fitter fitted on pump suction assembly. b) One length of tubing for pump discharge. c) One Dosing valve (for installation at the point of dosage to create back pressure). d) Dosing tank with level indicator, Flow: 6 LPH Make-Ion Exchange/Emaux/Astral/Certican as approved by AGE(I)

Supply, lay and jointing UPVC pipe confirming to IS :4985:1988 (Sch-80) 65 mm dia complete incl fittings and fixtures and special e.g couplings, tees, bends, Reducers, bushes, male female threaded adopters , flunged tail, pieces etc jointing with solvent cement joints for connection to filter, sump , pumps etc as required at site (Earth work shall be measured separately).,complete all as specified and directed. Make of UPVc and Pipe fittings :- Finolex/Prince/ Supreme,

M&L Motor Starter in Sheet Steel enclosure with 2P contactor -16 A for single phase Motor application upto 2 HP, overload relay range - 13-20A, fixed with Ammeter, voltmeter, 160 - 220v AC coil, connected to Motor and fixed at site on wall with unarmoured AL cable of size 4 sqmm, 3-core upto a length of 5m, suitable fixing screws, plugs etc for starter panel and testing complete. Make-BCH/L&T/SIEMENS make/model approved by Engr-in-Charge

Supplying, laying, commisioning and testing of 1.1 KV grade XLPE insulated PVC sheathed steel armoured aluminum stranded conductor LT UG cable ( Conforming to IS 7098) ISI marked in trenches / ducts / through GI pipes under roads of size 25 sqmm 4 core complete all as specifed and directed. Note;- The earth work, GI pipe shall be measured and paid sepretely under appropriate item of Sch A

M&L Bus bar chamber 4 pole, 63 Amps, 415 V, with anodised AL Bus bar of rating 200 Amps upto length of 40 cm mounted on DMC insulator, Sheet steel enclosure of CRCA of thickness 3.0mm IP-54 protection including necessary MS work/angle irion work/ PCC work in foundation complete all as specifed and directed. Suitable glands may be included in rate.Make Universal switch Gear/ABB/Schneider

Material & labour for earthing complete with galvanised steel earth plate electrode 600x600x6mm thick burried directly in ground. ( earth pit not less than 2.25 mtr depth below ground level at any type of strata ) with top edge of the earth plate not less than 1.5mtr below normal ground level surrounded with adequate quantity of charcoal dust mixed with salt to a packed thickness of 15cm all around the plate.connected by 25x4 mm GI strip as earth lead by means of brass nuts and bolt,thimbles check nuts, washers including concrete chamber of PCC 1:3:6 type C-1 using 20mm graded stone aggregate with fair finish, internal surface of concrete chamber shall be given internal dia 300mm x300mm, 15mm thick plaster in CM 1:4 funnel with wire mesh, RCC pit cover of 320x320x80mm size (1:2:4) Type B1 using 20mm graded stone aggregate rainforced with XPM all as shown in electrical plate No 3 of MES SSR Part-1(2009) and specified including and provision of GI wire upto 7.5 mtrs long with 40 mm dia light grade GI strip protection and watering pipe of GI 20 mm bore, medium grade, including all exavation and earth work and connecting the earthing wire to panel, including testing on completion complete all as specified and directed by Engr-in-charge. Note:- (i) RCC pit cover shall be precast of RCC(1:2:4) type B1, 80mm thick rainforced with XPM weighting not less than 4kg/sqm in lieu of CI cover. (ii) Cost of additional GI wire more than 7.5 mtrs will be measured and paid seperately under relevant items.

Earth continuity conductor or main earthing lead fixed to wall on batten or recess or chases or buried in ground or drawn in conduit/pipe or fixed to poles or any other indicated situation for loop earthing etc. as required 25x4 dia galvanised iron or steel strip complete all as specified and directed

Excavation in trenches in any type of soil and not exc 1.5 m wide and n.exc 1.5 m in depth for laying of cable and fixing poles, stays etc and getting out complete all as specified and directed

Returning filling in soft/loose soil including spreading levelling watering and well ramming in layers n.exc 25cm each layer complete all as specified and directed.

Removal of excavated surplus soft/loose soil to a distance not exc 50 mtr and depositing where directed at a level not exc 1.5 mtr above the starting point complete all as specified and directed.

M&L for fine dry sand cushioning for underground cable by providing layers of sand 8 cm before laying and 15 cm deep after laying the cable including streching the cable (measurement to be taken after punning down consolidated thickness). complete all as specified and directed.

M&L Cable protection by brick, sub class B, old size, common burnt clay, desig 75 complete all as specified and directed.

Supply and laying in trenches/fixed on wall GI tubing light grade of Size 40 mm dia ISI Marked with necessary heavy duty fittings such as bend, tee,elbow etc complete all as specified and directed.

M&L for PCC 1:3:6 type C-1 (using 20 mm graded stone crushed aggrigate) as in foundation,complete all as specified and directed.

Supply only Suction Sweeper for pool cleaning with SS trolley, 3 HP Pump, 3-core,4 sqmm water proof copper conductor wire lead 25 RM, On/Off switch, Vacuum Head 18", telescopic pole 5 M, Hose Pipe 30m, wall brush 18", Algae brush 10", Leaf net deep, Test kit complete all as specified and directed.. Make-Ion Exchange /Austin/ACL/Pentolex Pool as approved by AGE(I)

Ghuman Builders

PIONEER REFRIGERATION AND ELECTRICALS

KANISHKA ENTERPRISES