Chipping and Painting, Cleaning, Priming and Painting of Outside Hull, Internal Tanks, Superstructure,Mechinary Compartment, Bilges, Decks and Pipes of Vessels Under Ship Repairs on rate contract basis

Amount

SURFACE PREPARATION AND PAINTING AT VARIOUS LOCATIONS

General Cleaning (Removal of loose dust by wire brushing/mopping/light scrapping)

Removal of Marine Growth/Barnicals

Manual cleaning (thorough chipping/hard scraping,)

Surface roughness by light discing

Mechanical Cleaning to Bare Metal (ST2/ST3)

Chemical Cleaning

Fresh Water Cleaning/hosing

High Pressure Water Jet Cleaning with contractor's equipment

High Pressure Water Jet Cleaning with HSL's equipment

Application of one coat of Primer/conventional paint/ epoxy paint /Oil coat/Cement Wash (either by brush or by airless spray) with contractor's equipment

Application of one coat of Primer/conventional paint/ epoxy paint /Oil coat/Cement Wash (either by brush or by airless spray) with HSL's equipment

Note: 1) Above operations in Fuel tanks 75% extra will be considered and other than Fuel tanks 50% extra will be considered. 2) Above operations in Bilges 150% extra will be considered 3) Above operations for various foundations, Outfit items, Deck Machinery, Engine Room Machinery 100% extra will be considered. 4) Above operations for STP /Sludge/ Sewage /Soil tank 100% extra shall be considered. 5) Repetition of above operations due to various exigencies shall be paid at extra. i.e. 2nd time - 50%, 3rd time - 25%, so on. 6) Washing/cleaning for the purpose of application of paint and removal of rust, grease, oil, burnt marks shall not be paid at extra.

Ballast Tanks/ Cofferdam/Void Spaces/FW Tanks/SW Tanks/Fore & Aft Peak/Decantation/Center Keelson/Fuel Tanks/Chain locker and enclosed spaces where spaces are measured in cumtr /ton capacity

General Cleaning ( Removal of loose dust by wire brushing/mopping/light scrapping)

Manual cleaning (thorough chipping/hard scraping)

Mechanical Cleaning to bare metal (ST2/ST3)

Fresh Water Cleaning/hosing/Mopping

Chemical Cleaning

Apply One coat of paint/Oil/Epoxy Paint/cement wash.

Note: Repetition of above operations due to various exigencies shall be paid at extra. i.e. 2nd time - 50%, 3rd time - 25%, so on.

STP /Sludge/ Sewage /Soil tank: Bail out sludge, scrap, clean, chip entire tank, wire brush, mopping of tank and to apply paint. [Minimum charges for 3 cumtr shall be paid]

Repeated cleaning shall be paid as per tank cleaning rates as per serial No. 2.07

DISPOSAL OF OIL / WATER / MUD / MUCK / SLUDGE

Pump out water with contractor's portable pump.

Water removal /Bailing out water

Oil/Muck/Mud/Sludge removal

Letter/Number Painting

Letter Painting on Display board/Name board

Paint of draught marks Fwrd, Aft, Midship and P&S either light load line or full load line.

Painting of Plimsol marks (P&S)/IMO Number

Painting of ship's name, Port of Registry on Bow & stern in English & Hindi.

Painting of Bow Thrust Emblem

Painting of funnel marking.

Painting of Pendent Numbers.

Inscription (marking new inscription by dot punch) of Ship Names in English & Hindi Letters.

Helo Deck Marking with Florescent paint with two coats of Orange, Green, Red, White and Lemon Yellow

Painting of white boarder 4" to 9" around the ship/line cutting between boot top and top side.

PORT HOLES

Port hole eye brow: Cleaning & painting of port hole eye brow

Port holes/Anodes/Windows/Propellers/Echo sounder/ Log: Apply and removal of grease and clean with thinner.

ANCHOR CHAIN CABLES AND ANCHOR (P&S)

Anchor Chain cable of link dia upto 25mm

Cleaning, wire brushing of anchor chain

Chipping, wire brushing and cleaning of chain

Hose down of chain and anchor

High Pressure Water jet of chain and anchor

Application of one coat of paint for chain

Chipping, wire brushing, cleaning and painting of Anchor

Anchor Chain cable of link dia from 26 mm to 50mm

Cleaning, wire brushing of anchor cable

Chipping, wire brushing and cleaning of chain

Hose down of chain and anchor

High Pressure Water jet of chain and anchor

Application of one coat of paint for chain

Chipping, wire brushing, cleaning and painting of Anchor

Anchor Chain cable of link dia above 50mm

Cleaning, wire brushing of anchor cable

Chipping, wire brushing and cleaning of chain

Hose down of chain and anchor

High Pressure Water jet of chain and anchor

Application of one coat of paint for chain

Chipping, wire brushing, cleaning and painting of Anchor

PIPES (measurements outer dia)

Chipping, cleaning and applying one coat of paint

Upto 80 mm

80 mm to 200 mm

201 mm to 300 mm

301mm to 500mm

501mm to 1000mm

Chemical cleaning

Upto 80 mm

80 mm to 200 mm

201 mm to 300 mm

301mm to 500mm

501mm to 1000mm

Application of addl. Coat of paint.

Upto 80 mm

80 mm to 200 mm

201 mm to 300 mm

301mm to 500mm

501mm to 1000mm

Pipes of above 1000 mm dia shall be considered as per Item No.I.

Inter connecting pipe between forward machinery and pump room in the Center Keelson: Choke Cleaning of pipes Insitu.

up to 500 mm pipe

501 to 1000 mm pipe

SRI KARTHIK SAI WORKERS WELFARE SOCIETY

SYAMALA ENTERPRISES

SRI VENKATA KRISHNA ENTERPRISES

SHRAVANI ENGINEERING WORKS

ENGINEERING AND GENERAL WORKERS SOCIETY

GAJUWAKA SRI VAMSI KRISHNA WORKERS WELFARE SOCIETY

MAHASAKTHI WELFARE SOCIETY

BHANU CHANDRA WELFARE SOCIETY

GANGADHAR WELFARE SOCIETY

SREE SAIRAM TECHNICAL SERVICES

JEEVAN SAI BLASTING WORKS AND PAINTING WORKS

SRI LAKSHMI NARASIMHA ENTERPRISES

RAJ MARINE SERVICES

SIRICON ENGINEERS AND CONTRACTORS

SRISAI OILFIELD EQUIPMENTS AND MARINE SERVICES PVT LTD

PAVANPUTRA BLASTING WORKS

MANJULA C.C.AND P WELFARE SOCIETY

SRI KANAKA SHIPPING PAINTING AND CLEANING PANIVARALA SAMKSHEMA SANGHAM

Sadiya Enterprises