RESOURCE MANAGEMENT FOR MAIN RECEIVING STATION TAKE OVER POINT 11 KV AND MAP PUMP HOUSE AT HARNI CAMP AT AF STN BARODA

Amount

Resource Management of MES main Recieving Station HT 11 KV at Harni for three shifts, with one electrician each shift round the clock,24 hours(i.e three shift per day) including sundays & Gazette holidays for operation complete all as specified and directed.

1st shift - 0600h to 1400h

2nd shift - 1400h to 2200h

3rd shift - 2200h to 0600h

The Sub Station consisit the following equipment:-

Vaccum Circuit Breaker type 11000 volts. Make : Areva - 03 as outgoing, RMU - 01 for incomming (Make:Areva).

Transformer 200 KVA - 01 No.

LT panel for outgoing feeder to pump house, domestic area, street lights, parameter lights.

Centrifugal pump of cap 40 HP - 03 Nos

LT panel for outgoing feeder to 2231 SQDN, Street Lights.

Resource Management for water supply map pump house installation with one FGM operater in each shift round the clock,24 hours(i.e three shift per day) including sundays & Gazette holidays for operation of pump set and diesel Engine (stand by) including operation of connected valves, maintain equipment in perfect conditions, maintaining proper timing of distribution of water supply, maintaining proper condition of equipments, cleaning of installation and surrounding areas as directed by Engineer-in-charge at pump and consisting of the following:-

Ist Shift - 0600h to 1400h

IInd Shift - 1400h to 2200h

IIIrd Shift - 2200h to 0600h

Centrifugal pump type DB 80/20 (Make Kirloskar ),2900 RPM, motor- 25HP capacity - 02 Nos.

Electrical panel board consisting of following 2 Nos

Oil immersed starter 25 HP make jyoti- 02 Nos.

Standby diesel engine generator set (Make Greaves) Capacity 63 KVA complete with panel board, battery 180 AH and battery charger - 01 No.

Chloronome plant pressure feed, 200 Gms/Hr( Make:- Sweta) - 01 Nos.

Pump house bldg including connected accessories, internal wiring, sluice valves, pipe lines etc.

NOTE for Ser item No. 1 and 2

The contractor shall employ FGM/Electrician shall be ITI pass or minimum matriculate with three years experence in the trade from recognized government institute and helper minimum 8th pass from reconized government institution

Staff will always remain on duty & shift staff shall not change over duty unless proper handling taking over signed.

Logsheet/Log book of HT/ LT shut down MES/ MGVCL and running of DG set handling/ Taking over register, attendance register, will be maintained properly and form will be issued and printed form by the contractor.

A record should be maintained for HT pannel on standard MES type format (i.e Logsheet) will by provided by the contractor w/o any extra cost.

Logsheet/Logbook of plant running and running of DG set handing/taking over register,attendance register shall be maintained proper and from will be issued and printed form by the contractor.

Installation and complex should be kept clean and tidy in presentable look, otherwise a recovery at the double rate of the quoted will be charged if the installation and complex are not kept cleaned at the time.

They shall carry out normal maintenance of Gen set such as checking oil level cleaning of terminals and charging of battery tightening of nuts and bolts greasing of manning parts, applying petroleum galley to battery terminals pouring distilled water in Gen Set etc.

T & P such as torch light, spanners, screw drivers, cotton waste will be issued to the operator by the contractor without any extra cost.

Tradesmen shall take preventive measure and will use protective clothing as per code of practice of IE rules and department will not be responsible for any type of on towards incidents.

Any negligence of duty during operation of Gen Set/ Switches off maintaining records will be taken seriously and compensation will be made as per contract procedures.

Contractor shall ensure that no trade men shall work more than 48 hrs in a weak.

Contractor shall provide Life Insurance of min 1 Lac to all the employed manpower & copy of Life insurance shall be deposited with department within one month of acceptance.

No one absent on duty, if any one found absent a recovery at the double rate of the quoted will be chargable.

The Contractor also maintain daily log sheet shutdown records and attendance registers regular

Contractor shall submit all the documents like, Insurance copy, Educational Qualification, Log book, Attendance Register, Absentees Register, proof of payment in the Bank, EPF/ESIC details, proof of payment of EPF/ESIC/Bonus while claiming the payments of RARs and Final bill. No payments shall be entertained by the department in the absence of the above said documents.

K A ELECTRIC CO